APPENDIX Return To Main Table of Contents INTRODUCTION ............................................... 2 S Y M B O L S ................................................... 6 TROUBLESHOOTING INSTRUCTIONS . . . . . . . . . . . . . . . . 10 FUSE AND RELAY INFORMATION ...................... 15 POWER DISTRIBUTION ........................................ 18 DASH FUSE BOX DETAILS ............................... 22 GROUND DISTRIBUTION ................................. 32 JOINT DISTRIBUTION ..........................
INTRODUCTION WS-2 INTRODUCTION This Group consists of five major diagnostic sections for electrical problem troubleshooting.
INTRODUCTION WS-3 COMPONENT LOCATION INDEXES When you want to locate the schematic components on the vehicle, use the Component Location Index which follows each schematic. A Component Location Index lists major components, connectors, grounds and their physical location and page figure reference.
WS-4 INTRODUCTION HARNESS LAYOUTS Harness layouts show the routing of the major wiring harnesses and the in-line connectors between the major harnesses. These layouts will make electrical troubleshooting easier. An example of Harness Layouts-Engine Harness COMPONENT LOCATIONS Component Locations give easy access to find the schematic components on the vehicle shown in the Component Location Index.
INTRODUCTION WS-5 CONNECTOR CONFIGURATIONS This section shows the cavity or terminal locations in all the multi-pin connectors shown in the schematic diagrams. It is helpful for you to locate check points, together with the wire colors and terminal numbers in the schematic. The configuration drawings show the connector views as seen from a component after the harness connector has been disconnected. When more than on connector is connected to a component, the connectors are all shown together.
SYMBOLS SYMBOLS The symbols and the abbreviations explained in this section are used throughout the manual. SYMBOLS IN SCHEMATIC COMPONENTS DIODE This diode allows current to flow only in the direction of the arrow. A solid line means the entire component is shown. FUSE AND FUSIBLE LINK A broken line indicates only part of the component is shown. The name of the component appears next to its upper right corner. Notes about component function follow its name.
SYMBOLS WIRES A wavy line means the wire is broken but is to be continued. 0.5YEL/RED Wire insulation is yellow with a red strip Current path is continued another page. The arrow shows the direction of current flow. You should look for the ”P” in the Power Distribution schematic to follow the white wire in left example. A wire connects to another circuit. The wire is shown again on that circuit which the arrow is pointing.
WS-8 SYMBOLS SWITCHES JOINT CONNECTORS These switches move together: a dashed line shows a mechanical connection between them. RELAYS INDICATOR This is a relay shown with no current flowing through its coil. When a current flows through coil, contact will toggle. Normally open contact Normally closed contact This indicates seat belt warning indicator continues to other indicaters within instrument cluster. This is an indicator which displays the lighted symbol.
SYMBOLS WS-9 CONNECTOR CLASSIFICATION SYMBOLS Electrical wiring connectors are classified according to the wiring parts in the Harness Layout. A connector identification symbol consists of a wiring harness location classification symbol corresponding to each other wiring harness location and number peculiar to the connector. These connector locations can be found in the WIRING HARNESS LAYOUT.
WS-10 TROUBLESHOOTING INSTRUCTION TROUBLESHOOTING INSTRUCTIONS TROUBLESHOOTING PROCEDURES The following five-step troubleshooting procedure is recommended. Step 1. Verify the customer complaints Turn on all the components in the problem circuit to check the accuracy of the customer complaints. Note the symptoms. Do not begin disassembly or testing until you have narrowed down the probable causes. Step 2. Read and analyze the schematic diagram Locate the schematic for the problem circuit.
TROUBLESHOOTING INSTRUCTION TROUBLESHOOTING EQUIPMENTS Voltmeter And Test Lamp Use a test lamp or a voltmeter on circuits without solid-state units, use a test lamp to check for voltage. A test lamp is made up of 12volt bulb with a pair of leads attached. After grounding one lead to various points along the circuit where voltage should be present. When the bulb goes on, there is voltage at the point being tested.
WS-12 TROUBLESHOOTING INSTRUCTION Jumper Wire With Fuse Use a jumper wire with fuse to by pass an open circuit. A jumper wire is made up of an in-line fuse holder connected to a set of test leads. This tool is available with small clamp connectors providing adaption to most connectors without damage. CAUTION: Do not use a fuse with a higher rating then the specified fuse that protests the circuit being tested.
TROUBLESHOOTING INSTRUCTION TROUBLESHOOTING TEST Testing For Voltage This test measures voltage in a circuit. When testing for voltage at a connector, you do not have to separate the two halves of the connector. Instead, probe the connector from the back. Always check both sides of the connector because dirt and corrosion between its contact surfaces can cause electrical problems. 1. Connect one lead of a test lamp or voltmeter to a ground.
WS-14 TROUBLESHOOTING INSTRUCTION Testing For A Short With A Short Finder 1. Remove the blown fuse. Leave the battery connected. 2. Connect the short finder across the fuse terminals. 3. Close all switches in series in the circuit you’re testing. 4. Turn on the short circuit locator. It sends pulses of current to the short. This creates a pulsing magnetic field around the wiring between the fuse box and the short. 5. Beginning at the fuse box, slowly move the short finder along the circuit wiring.
FUSE AND RELAY INFORMATION FUSE AND RELAY INFORMATION DASH FUSE BOX Layout WS-15
WS-16 TROUBLESHOOTING INSTRUCTION ENGINE COMPARTMENT RELAY BOX Layout
FUSE AND RELAY INFORMATION PASSENGER COMPARTMENT RELAY BOX Layout FUSIBLE LINK BOX Layout/circuit WS-17
WS-18 POWER DISTRIBUTION SCHEMATIC DIAGRAM (1) POWER DISTRIBUTION
POWER DISTRIBUTION SCHEMATIC DIAGRAM (2) WS-19
WS-20 SCHEMATIC DIAGRAM (3) POWER DISTRIBUTION
POWER DISTRIBUTION SCHEMATIC DIAGRAM (4) WS-21
WS-22 DASH FUSE BOX DETAILS SCHEMATIC DIAGRAM (1) DASH FUSE BOX DETAILS
DASH FUSE DETAILS SCHEMATIC DIAGRAM (2)
WS-24 SCHEMATIC DIAGRAM (3) DASH FUSE BOX DETAILS
DASH FUSE DETAILS SCHEMATIC DIAGRAM (4) WS-25
WS-26 SCHEMATIC DIAGRAM (5) DASH FUSE BOX DETAILS
DASH FUSE DETAILS SCHEMATIC DIAGRAM (6) WS-27
WS-28 SCHEMATIC DIAGRAM (7) DASH FUSE BOX DETAILS
DASH FUSE DETAILS SCHEMATIC DIAGRAM (8)
WS-30 SCHEMATIC DIAGRAM (9) DASH FUSE BOX DETAILS
DASH FUSE DETAILS MEMO WS-31
WS-32 GROUND DISTRIBUTION SCHEMATIC DIAGRAM (GO1)-1 GROUND DISTRIBUTION
GROUND DlSTRlBUTlON SCHEMATIC DIAGRAM (G01)-2 WS-33
WS-34 GROUND DISTRIBUTION SCHEMATIC DIAGRAM (G01)-3 GO1
GROUND DISTRIBUTION SCHEMATIC DIAGRAM (G02-1) WS-35
WS-36 SCHEMATIC DIAGRAM (G03) GROUND DISTRIBUTION
GROUND DISTRIBUTION SCHEMATIC DIAGRAM (G04/G05) WS-37
WS-38 GROUND DISTRIBUTION SCHEMATIC DIAGRAM (G05) GO5
GROUND DISTRIBUTION SCHEMATIC DIAGRAM (G06) WS-39
GROUND DISTRIBUTION WS-40 SCHEMATIC DIAGRAM (GO7) E29 GO7
WS-41 SCHEMATIC DIAGRAM (G08 )
WS-42 GROUND DISTRIBUTION SCHEMATIC DIAGRAM (G09/Gl0) G10 G10
WS-43 GROUND DISTRIBUTION SCHEMATIC DIAGRAM (G11/G12) 0.
WS-44 JOINT DISTRIBUTION SCHEMATIC DIAGRAM (E01-1) JOINT DISTRIBUTION
JOINT DISTRIBUTION SCHEMATIC DIAGRAM (E01-2/3) WS-45
WS-46 SCHEMATIC DIAGRAM (M01-1) JOINT DISTRIBUTION
JOINT DISTRIBUTION SCHEMATIC DIAGRAM (M01-2) WS-47
WS-48 SCHEMATIC DIAGRAM (M01-3) JOINT DISTRIBUTION
JOINT DISTRIBUTION SCHEMATIC DIAGRAM (M01-4)
WS-50 SCHEMATIC DIAGRAM (M01-5) JOINT DISTRIBUTION
JOINT DISTRIBUTION MEMO
WS-52 IGNITION SYSTEM SCHEMATIC DIAGRAM
IGNITION SYSTEM COMPONENT LOCATION INDEX Location reference-page Components ECM (C01 -2 ~ C01 -3) ECM control relay (C02) Ignition coil (C14) Ignition switch (M24) Noise filter (Cl 1) Power transistor (Cl 3) WS-182 WS-182 WS-183 WS-189 WS-182 WS-183 Connector MC01 WS-201 Ground G09 WS-204 WS-53
WS-54 STARTING SYSTEM SCHEMATIC DIAGRAM STARTING SYSTEM
STARTING SYSTEM COMPONENT LOCATION INDEX Location reference-page Components Ignition lock switch (M29) Starter motor (C18) Starter relay (M15) Transaxle range switch (E28) WS-195 WS-183 WS-194 WS-189 Connectors EM04/EM05 MC01 WS-191 WS-201 Ground G01 WS-203 WS-55
WS-56 CHARGING SYSTEM SCHEMATIC DIAGRAM CHARGING SYSTEM
CHARGING SYSTEM COMPONENT LOCATION INDEX Location reference-page Components Generator (E31-1 ~ E31-2) Instrument cluster (I13-1) Relay with diode (C07) WS-189 WS-193 WS-182 Connectors El01 EM03 MC01 WS-192 WS-191 WS-201 WS-57
WS-58 COOLING SYSTEM SCHEMATIC DIAGRAM (1) COOLING SYSTEM
COOLING SYSTEM SCHEMATIC DIAGRAM (2) WS-59
WS-60 COOLING SYSTEM COMPONENT LOCATION INDEX Location reference-page Components AC switch (110) Condenser fan (E29) Condenser fan control relay (E04) Condenser fan relay (E05) Radiator fan (E26) Radiator fan relay (E07) Thermo switch (E26-2) Thermo sensor (E44) WS-193 WS-189 WS-188 WS-188 WS-189 WS-188 WS-189 WS-190 Connectors El01 EM03 Ml01 WS-192 WS-191 WS-201 Ground G05 G07 WS-203 WS-203
COOLING SYSTEM MEMO WS-61
WS-62 DOHC SYSTEM (For California) DOHC SYSTEM (For California) SCHEMATIC DIAGRAM (1)
DOHC SYSTEM (For California) SCHEMATIC DIAGRAM (2) WS-63
WS-64 SCHEMATIC DIAGRAM (3) DOHC SYSTEM (For California)
DOHC SYSTEM (For California) SCHEMATIC DIAGRAM (4) WS-65
DOHC SYSTEM (For California) SCHEMATIC DIAGRAM (5)
DOHC SYSTEM (For California) SCHEMATIC DIAGRAM (6) WS-67
WS-68 DOHC SYSTEM (For California) COMPONENT LOCATION INDEX Location reference-page Components NC relay (E08) AC switch (110) Auto cruise module (M21) Crankshaft position sensor (CO9) Data link conn. (M33) ECM control relay (C02) ECM (CO1-1 ~ CO1-3) ELC module (E02-2) ECTS (C20) Fuel pump motor (M50) Idle switch (C30) Ignition switch (M24) Ignition coil (Cl 4) Ignition lock switch (M29) Injectors (C12-1 ~ C12-4) Instrument cluster (113-l) ISC motor (C15) Ignition control adjusting conn.
DOHC SYSTEM (For California) MEMO WS-69
WS-70 DOHC SYSTEM (Except California) DOHC SYSTEM (Except California) SCHEMATIC DIAGRAM (1)
DOHC SYSTEM (Except California) SCHEMATIC DIAGRAM (2) WS-71
WS-72 SCHEMATIC DIAGRAM (3) DOHC SYSTEM (Except California)
DOHC SYSTEM (Except California) SCHEMATIC DIAGRAM (4) WS-73
WS-74 SCHEMATIC DIAGRAM (5) DOHC SYSTEM (Except California)
DOHC SYSTEM (Except California) SCHEMATIC DIAGRAM (6) WS-75
WS-76 DOHC SYSTEM (Except California) COMPONENT LOCATION INDEX Location reference-page Components A/C relay (E08) A/C switch (110) Auto cruise module (M21) Crankshaft position sensor (C09) Data link conn. (M33) ECM control relay (C02) ECM (C01 -1 ~ CO1 -3) ELC module (E02-2) ECTS (C20) Fuel pump motor (M49) Idle switch (C30) Ignition switch (M24) Ignition coil (C14) Ignition lock switch (M29) Injectors (C12-1 ~ C12-4) Instrument cluster (I13-1) ISC motor (C15) Ignition control adjusting conn.
DOHC SYSTEM (Except California) MEMO WS-77
WS-78 VEHICLE SPEED SENSOR SCHEMATIC DIAGRAM VEHICLE SPEED SENSOR
VEHICLE SPEED SENSOR COMPONENT LOCATION INDEX Location reference-page Components A/C switch (I10) Cruise control module (M21) Data link connector (M33) ECM (C01 -1) Instrument cluster (I13-1 ~ I13-4) TCM (E02-2) WS-193 WS-194 WS-196 WS-182 WS-193 WS-188 Connectors EM04 MC01 Ml01 Ml02 WS-191 WS-201 WS-201 WS-201 Ground G01 WS-203 WS-79
WS-80 CRUISE CONTROL SYSTEM SCHEMATIC DIAGRAM (1) CRUISE CONTROL SYSTEM
CRUISE CONTROL SYSTEM SCHEMATlC DIAGRAM (2) WS-81
WS-82 SCHEMATIC DIAGRAM (3) CRUISE CONTROL SYSTEM
CRUISE CONTROL SYSTEM COMPONENT LOCATION INDEX Location reference-page Components Audio (M43) Clutch switch (M30) Cruise control actuator (E09) Cruise control module (M21) Cruise main switch (107) Data link connector (M33) Digital clock (I11) Ignition switch (M24) Multi switch (M26-1) Overdrive switch (M60) Stop lamp switch (M28) Transaxle range switch (E28) TCM (E20-2-E20-3) WS-196 WS-195 WS-188 WS-194 WS-193 WS-196 WS-193 WS-195 WS-195 WS-198 WS-195 WS-189 WS-188 Connectors EM04 EM05(A/T) MC01 Ml02 Ml
WS-84 ELECTRONIC LOCK UP CONTROLS ELECTRONIC LOCK UP CONTROLS SCHEMATIC DIAGRAM (1)
ELECTRONIC LOCK UP CONTROLS SCHEMATIC DIAGRAM (2) WS-85
WS-86 SCHEMATIC DIAGRAM (3) ELECTRONIC LOCK UP CONTROLS
ELECTRONIC LOCK UP CONTROLS COMPONENT LOCATION INDEX Location reference-page Components Accelerator pedal switch (M22) Cruise control module (M21) Data link connector (M33) ECT switch (M41) ECM (CO1 -1) Kick down servo switch (El 1) Oil Temperature sensor (El 2) Over drive switch (M60) Pulse generator (El 3) Transaxle range switch (E28) TCM (E02-1 ~ E02-2) TP sensor (Cl 7) Transaxle valve body (E25) Vehicle speed sensor (I13-2) WS-194 WS-194 WS-196 WS-196 WS-182 WS-188 WS-188 WS-188 WS-188 WS-189 WS-188
WS-88 HORNS SCHEMATIC DIAGRAM HORNS
WS-89 HORNS COMPONENT LOCATION INDEX Location reference-page Components Horn relay (E08-1) Left horn (E38) Multifunction switch (M26-1) Right horn (E18) WS-188 WS-190 WS-195 WS-188 Connector EM03 WS-191
WS-90 CIGARETTE LIGHTER SCHEMATIC DIAGRAM ClGARETTE LIGHTER
CIGARETTE LIGHTER COMPONENT LOCATION INDEX Location reference-page Components Cigarette lighter (M44) WS-197 Ground G11 WS-204 WS-91
WS-92 INDICATORS SCHEMATIC DIAGRAM (1) INDICATORS
INDICATORS SCHEMATIC DIAGRAM (2) WS-93
WS-94 SCHEMATIC DIAGRAM (3) INDICATORS
WS-95 INDICATORS COMPONENT LOCATION INDEX Location reference-page Components A/C switch (I10) Digital clock (I11) Fuel sender (M50) Instrument cluster (I13-1 ~ 113-4) Oil pressure switch (E32) Rheostat (I01) TACM (M38) WS-193 WS-193 WS-197 WS-193 WS-195 WS-193 WS-196 Connectors El01 MC01 Ml01 Ml02 WS-192 WS-201 WS-201 WS-201 Ground G01 G11 WS-203 WS-204
WS-96 GAUGES SCHEMATIC DIAGRAM GAUGES
WS-97 GAUGES COMPONENT LOCATION INDEX Location reference-page Components NC switch (110) Cluster (113-l) Coolant temperature sender (Cl 9) Fuel sender (M50) WS-193 WS-193 WS-183 WS-197 Connectors MC01 Ml02 Ml01 WS-201 WS-201 WS-201 Grounds G01 G11 WS-203 WS-204
WS-98 BRAKE AND CHARGE WARNING SYSTEM BRAKE AND CHARGE WARNING SYSTEM SCHEMATlC DIAGRAM
BRAKE AND CHARGE WARNING SYSTEM COMPONENT LOCATION INDEX Location reference-page Components Generator (E31-2) Brake fluid level sensor (E14) instrument cluster (113-2) Parking brake switch (M36) TACM unit lM38) Relay with diode (C07) WS-189 WS-188 WS-193 WS-196 WS-196 WS-182 Connectors El01 EM03 Ml01/Ml02 WS-192 WS-191 WS-201 Ground GO5 WS-203 WS-99
WS-100 HEAD LAMPS SCHEMATIC DIAGRAM HEAD LAMPS
WS-101 HEAD LAMPS COMPONENT LOCATION INDEX Location reference-page Components Cluster (I13-1) Head lamp relay (E06) LH head lamp (E36) .
WS-102 DAYTIME RUNNING LIGHTS DAYTIME RUNNING LIGHTS (DRL) SCHEMATIC DIAGRAM (1)
DAYTIME RUNNING LIGHTS SCHEMATIC DIAGRAM (2) WS-103
WS-104 DAYTIME RUNNING LIGHTS COMPONENT LOCATION INDEX Location reference-page Components Generator (E31-2) Brake fluid level sensor (El 4) COND. fan motor (E29) COND.
DAYTIME RUNNING LIGHTS MEMO WS-105
WS-106 EXTERIOR LAMPS SCHEMATIC DIAGRAM (1) EXTERIOR LAMPS
EXTERIOR LAMPS SCHEMATlC DIAGRAM (2) WS-107
WS-108 SCHEMATIC DIAGRAM (3) EXTERIOR LAMPS
EXTERIOR LAMPS COMPONENT LOCATION INDEX Location reference-page Components Tail lamp relay (M18) Multi switch (M26-2) Digital clock (I11) LH side marker lamp (E34) LH tail/top lamp (R01) LH license lamp (R12) Trunk lid opener (R15) RH license lamp (R13) Fuel pump (M49) Cigarette lighter illum.
WS-110 STOP LAMPS SCHEMATIC DIAGRAM STOP LAMPS
WS-111 STOP LAMPS COMPONENT LOCATION INDEX Location reference-page Components High mounted stop lamp (M56) LH stop lamp (R01) RH stop lamp (R03) Stop lamp switch (M28) Stop lamp switch (M27) WS-198 WS-202 WS-202 WS-195 WS-195 Connector MR01 WS-201 Grounds GO3 G10 WS-203 WS-204
WS-112 TURN/HAZARD LAMPS SCHEMATIC DIAGRAM (1) TURN/HAZARD LAMPS
TURN/HAZARD LAMPS SCHEMATIC DIAGRAM (2) WS-113
WS-114 TURN/HAZARD LAMPS COMPONENT LOCATION INDEX Location reference-page Components Cluster (113-1, 113-2) Flasher unit (M16) Hazard switch (109) LH front turn (E33) LH rear turn (R01) Multi switch (M26-2) RH front turn (E20) RH rear turn (R03) WS-193 WS-194 WS-193 WS-190 WS-202 WS-195 WS-188 WS-202 Connectors EM02 Ml01 MR01 WS-191 WS-201 WS-201 Ground G01l/G05 G10 WS-203 WS-204
TURN/HAZARD LAMPS MEMO WS-115
WS-116 BACK UP LAMPS SCHEMATIC DIAGRAM BACK UP LAMPS
BACK UP LAMPS COMPONENT LOCATION INDEX Location reference-page Components Transaxle range switch (E28) LH back up lamp (R01) RH back up lamp (R03) WS-189 WS-202 WS-202 Connectors EM02 MR01 WS-191 WS-201 Ground G10 WS-204 WS-117
WS-118 COURTESY LAMPS COURTESY LAMPS SCHEMATIC DIAGRAM (1)-With Sunroof
COURTESY LAMPS SCHEMATIC DIAGRAM (2)-Without Sunroof WS-119
WS-120 COURTESY LAMPS COMPONENT LOCATION INDEX Location reference-page Components Cluster (I13-3) Courtesy lamp (M73) LH door lamp (D10) LH front door switch (M47) LH rear door switch (M52) Map lamp (M71) Overhead console lamp (M78) RH door lamp (D20) RH front door switch (M45) RH rear door switch (M46) Trunk lamp (M55) Trunk lamp switch (R02) WS-193 WS-199 WS-186 WS-197 WS-197 WS-199 WS-199 WS-187 WS-197 WS-197 WS-198 WS-202 Connectors MD01/MD05 Ml02/MR01 WS-201 WS-201 Ground G02 WS-203
COURTESY LAMPS MEMO WS-121
WS-122 DASH, CONSOLE AND SWITCH LAMPS DASH, CONSOLE AND SWITCH LAMPS SCHEMATIC DIAGRAM (1)
DASH, CONSOLE AND SWITCH LAMPS SCHEMATIC DIAGRAM (2) WS-123
WS-124 SCHEMATIC DIAGRAM (3) DASH, CONSOLE AND SWITCH LAMPS
DASH, CONSOLE AND SWITCH LAMPS SCHEMATIC DIAGRAM (4) WS-125
WS-126 DASH, CONSOLE AND SWITCH LAMPS COMPONENT LOCATION INDEX Location reference-page Components Audio ILL. (M43) A/T shift lamp (M66) Cigarette lighter lamp (M44) Cluster (I13-3) Digital clock (I11) ECT switch (M41) Fuel pump (M49) Hazard switch (I09) Heater control ILL.
DASH, CONSOLE AND SWITCH LAMPS MEMO WS-127
WS-128 TRUNK LID OPENER SCHEMATIC DIAGRAM TRUNK LID OPENER
TRUNK LID OPENER COMPONENT LOCATION INDEX Location reference-page Components LH licence lamp (R12) Trunk lid opener (R15) Trunk lid opener switch (D21) WS-202 WS-202 WS-187 Connectors MD01 MD02 MR02 WS-201 WS-201 WS-201 Ground G03 WS-203 WS-129
WS-130 SOUND SYSTEM SCHEMATIC DIAGRAM SOUND SYSTEM
SOUND SYSTEM COMPONENT LOCATION INDEX Location reference-page Components Audio (M43) Heater control illum (M66) LH front speaker (D02) LH rear speaker (M54) Rheostat (101) RH front speaker (D12) RH rear speaker (M57) WS-196 WS-198 WS-186 WS-198 WS-193 WS-186 WS-198 Connectors MD01 MD05 Ml01 MR02 WS-201 WS-201 WS-201 WS-201 WS-131
WS-132 POWER ANTENNA SCHEMATIC DIAGRAM POWER ANTENNA
POWER ANTENNA COMPONENT LOCATION INDEX Location reference-page Components Antenna motor (M58) Audio (M43) WS-198 WS-196 WS-133
WS-134 DIGITAL CLOCK SCHEMATIC DIAGRAM DIGITAL CLOCK
DIGITAL CLOCK COMPONENT LOCATION INDEX Location reference-page Components A/C switch (110) Audio (M43) Cluster (I13-l) Digital clock (I11 WS-193 WS-196 WS-193 WS-193 Connectors Ml01 Ml02 WS-201 WS-201 Ground G01 WS-203 WS-135
WS-136 TAC SYSTEM TIME AND ALARM CONTROL (TAC) SYSTEM SCHEMATIC DIAGRAM (1)
TAC SYSTEM SCHEMATIC DIAGRAM (2) WS-137
WS-138 SCHEMATIC DIAGRAM (3) TAC SYSTEM
WS-139 TAC SYSTEM COMPONENT LOCATION IN Location reference-page Components A/C switch (I10) Generator (E31-2) Chime bell (M32) Cluster (I13-1) Cluster (I13-3) Door warning switch (M23) Front wiper motor (E16) LH front door switch (M47) Multi switch (M26-1) Rear defogger glass (M53) Rear defogger switch (I08) Seat belt switch (M37) TACM (M38) Washer motor (E37) WS-193 WS-189 WS-195 WS-193 WS-193 WS-195 WS-188 WS-197 WS-195 WS-197 WS-196 WS-193 WS-196 WS-190 Connectors EM02 EM03 Ml01 Ml02 WS-191 WS-191
WS-140 BLOWER CONTROLS SCHEMATIC DIAGRAM BLOWER CONTROLS
BLOWER CONTROLS COMPONENT LOCATION INDEX Location reference-page Components Blower motor (M61) Blower relay (M17) Blower resistor (M63) Blower switch (M62) WS-198 WS-194 WS-198 WS-198 Connectors EM02 EM03 WS-191 WS-191 Ground GO1 WS-203 WS-141
WS-142 A/C COMPRESSOR CONTROLS A/C COMPRESSOR CONTROLS SCHEMATIC DIAGRAM (1)
A/C COMPRESSOR CONTROLS SCHEMATIC DIAGRAM (2) WS-143
WS-144 A/C COMPRESSOR CONTROLS COMPONENT LOCATION INDEX Location reference-page Components A/C compressor (C08) A/C control relay (E08) A/C low pressure switch (C06) A/C switch (I10) Blower relay (M17) Blower switch (M62) ECM (CO1-1/C01-2) TCM (E02-1) Thermo sensor-l (El 9) Therm switch (I1 2) Connectors El01 EM02 MC01 Ml01 Ground GO1 WS-182 WS-188 WS-182 WS-193 WS-194 WS-198 WS-182 WS-188 WS-188 WS-193 WS-192 WS-191 WS-201 WS-201 WS-203
A/C COMPRESSOR CONTROLS MEMO WS-145
WS-146 A/T AND IGNITION KEY LOCK CONTROLS A/T AND IGNITION KEY LOCK CONTROLS SCHEMATIC DIAGRAM
A/T AND IGNITION KEY LOCK CONTROLS COMPONENT LOCATION INDEX Location reference-page Components A/T and ignition key lock control module (M35) A/T shift lock sol.
WS-148 POWER WINDOWS SCHEMATIC DIAGRAM (1) POWER WINDOWS
POWER WINDOWS SCHEMATIC DIAGRAM (2) WS-149
WS-150 SCHEMATIC DIAGRAM (3) POWER WINDOWS
POWER WINDOWS COMPONENT LOCATION INDEX Location reference-page Components LH front window motor (D05) LH rear window motor (D32) LH rear window switch (D31) Power window main switch (D03) RH front window motor (D15) RH front window switch (D13) RH rear window motor (D42) RH rear window switch (D41) WS-186 WS-187 WS-187 WS-186 WS-187 WS-187 WS-187 WS-187 Connectors EM03 MD01 MD02 MD05 MD08 MD09 WS-191 WS-201 WS-201 WS-201 WS-201 WS-201 Ground G01 WS-203 WS-151
WS-152 POWER DOOR LOCK SCHEMATIC DIAGRAM POWER DOOR LOCK
POWER DOOR LOCK COMPONENT LOCATION INDEX Location reference-page Components LH front door actor (D06) LH rear door actor (D33) RH front door actor (D16) RH rear door actor (D43) Trunk lid opener switch (D21) WS-186 WS-187 WS-187 WS-187 WS-187 Connectors MD01 MD05 WS-201 WS-201 Ground GO1 WS-203 WS-153
WS-154 POWER DOOR MIRROR SCHEMATIC DIAGRAM POWER DOOR MIRROR
POWER DOOR MIRROR COMPONENT LOCATION INDEX Location reference-page Components Audio (M43) LH power door mirror (D01) Power door mirror switch (M42) RH power door mirror (D11) WS-196 WS-186 WS-196 WS-187 Connectors MD01 MD05 WS-201 WS-201 Ground G11 WS-204 WS-155
WS-156 SUNROOF SCHEMATIC DIAGRAM SUNROOF
WS-157 SUNROOF COMPONENT LOCATION INDEX Location reference-page Components Sun roof close/tilt up relay (M77) Sun roof motor (M80) Sun roof open/tilt down relay (M76) Sun roof switch (overhead console) (M78) WS-199 WS-199 WS-199 WS-199 Connectors M34 M72 WS-196 WS-199 Ground GO1 WS-203
PASSIVE SEAT BELTS WS-158 PASSIVE SEAT BELTS SCHEMATIC DIAGRAM (1) O.5RED/ WHT 0.5BLK 0.5BLK 0.
PASSIVE SEAT BELTS SCHEMATIC DIAGRAM (2) WS-159
WS-160 PASSIVE SEAT BELTS COMPONENT LOCATION INDEX Location reference-page Components Instrument cluster (I13-1) Passive seat belt unit (M48) RH door latch switch (D17) RH lap retractor (D19) RH shoulder retractor (D18) WS-193 WS-197 ws-187 WS-187 WS-187 Connectors MD07 Ml01 Ml02 WS-201 WS-201 WS-201 Grounds GO1 G02 WS-203 WS-203
PASSIVE SEAT BELTS MEMO WS-161
WS-162 ANTI-LOCK BRAKE SYSTEM ANTI-LOCK BRAKE SYSTEM SCHEMATIC DIAGRAM (1) DASH FUSE BOX
ANTI-LOCK BRAKE SYSTEM SCHEMATIC DIAGRAM (2) WS-163
WS-164 SCHEMATIC DIAGRAM (3) ANTI-LOCK BRAKE SYSTEM
ANTI-LOCK BRAKE SYSTEM COMPONENT LOCATION INDEX Location reference-page Components ABS control module (M93) ABS modulator (E57) ABS relay (E58/E59) Cluster (I13-l) Motor pump (E80) Data link connector (M33) Stop lamp switch (M27/M28) Wheel sensor (E55/E56/M94/M95) WS-200 WS-191 WS-191 WS-193 WS-191 WS-190 WS-189 WS-191/200 Connectors EM07-1 EM07-2 WS-192 WS-192 Grounds G01 G02 G05 WS-203 WS-203 WS-203 WS-165
WS-166 AIR BAG SCHEMATIC DIAGRAM AIR BAG
AIR BAG WS-167 COMPONENT LOCATION INDEX Location reference-page Components Clock spring (Initiator) (M84) SRS control module (M81) Data link connector (M33) Cluster (I13-1-I13-2) WS-200 WS-200 WS-196 WS-193 Connectors Ml01 M82 WS-201 WS-200 Grounds GO1 GO2 WS-203 WS-203
WS-168 CONFIGURATION OF CONNECTOR CONFIGURATION OF CONNECTOR C01-1 ~ C20
CONFIGURATION OF CONNECTOR C21 ~ D16 WS-169
WS-170 D17 ~ E05 CONFIGURATION OF CONNECTOR
CONFIGURATION OF CONNECTOR E06 ~ E29 WS-171
WS-172 E30~E58 CONFIGURATION OF CONNECTORS
CONFIGURATION OF CONNECTORS E59 ~ I09 WS-173
WS-174 I10 ~ M12 CONFIGURATION OF CONNECTOR
CONFIGURATION OF CONNECTOR M13 ~ M32 WS-175
WS-176 M33 ~ M57 CONFIGURATION OF CONNECTOR
CONFIGURATION OF CONNECTOR M58 ~ M81 WS-177
WS-178 M82 ~ MD05 CONFIGURATION OF CONNECTORS
CONFIGURATION OF CONNECTORS MD06-R10 WS-179
WS-180 R11 ~ R16 CONFIGURATION OF CONNECTOR
CONFIGURATION OF CONNECTOR MEMO WS-181
WS-182 COMPONENTS (C01-1 ~ C12-4) COMPONENT LOCATION
COMPONENT LOCATION COMPONENTS (C13 ~ C25) WS-183
WS-184 COMPONENTS (C28 ~ C47) COMPONENT LOCATION
COMPONENT LOCATION COMPONENTS (C48 ~ C101) WS-185
WS-186 COMPONENTS (D01 ~ D10) COMPONENT LOCATION
COMPONENT LOCATION COMPONENTS (D13 ~ D33) D13 WS-187
WS-188 COMPONENTS (E02-1 ~ E23) COMPONENT LOCATION
COMPONENT LOCATION COMPONENTS (E24 ~ E31-2) WS-189
WS-190 COMPONENTS (E32 ~ E44) COMPONENT LOCATION
COMPONENT LOCATION COMPONENTS (E50 ~ E60) WS-191
WS-192 COMPONENTS (EM01 ~ El02) COMPONENT LOCATION
r e s c a n w s - 1 9 3
WS-194 COMPONENTS (M02 ~ M22) COMPONENT LOCATION
COMPONENT LOCATION COMPONENTS (M23 ~ M32) WS-195
WS-196 COMPONENTS (M33 ~ M43) COMPONENT LOCATION
COMPONENT LOCATION COMPONENTS (M44 ~ M53) WS-197
WS-198 COMPONENTS (M54 ~ M68) COMPONENT LOCATION
COMPONENT LOCATION COMPONENTS (M70 ~ M80) WS-199
WS-200 COMPONENTS (M81 ~ M95) COMPONENT LOCATION
COMPONENT LOCATION COMPONENTS (MC01 ~ MR02) WS-201
WS-202 COMPONENTS (R01 ~ R15) COMPONENT LOCATION
COMPONENT LOCATION COMPONENTS (G01 ~ G08) WS-203
WS-204 COMPONENTS (G09 ~ G12) COMPONENT LOCATION
INTRODUCTION WS-205 HARNESS LAYOUTS Harness layouts show the routing of the major wiring harnesses and the in-line connectors between the major harnesses. These layouts will make electrical troubleshooting easier. An example of Harness Layouts-Engine Harness COMPONENT LOCATIONS Component Locations give easy access to find the schematic components on the vehicle shown in the Component Location Index.
HARNESS LAYOUT WS-206 HARNESS LAYOUT ENGINE HARNESS (1) E56 E40 E01-1 E01-2 E01-3 E04 E05 E06 E07 E08 E08-1 E09 E11 E12 E13 E14 E16 E18 E19 E20 E23 Joint connector (IGN) Joint connector (TAIL, LH) Joint connector (TAIL, RH) Radiator fan control relay Condenser fan relay Head lamp relay Radiator fan relay Air conditioning relay Horn relay Cruise control actuator Kick down switch (A/T) Oil temperature sensor (A/T) Pulse generator (A/T) Brake fluid sensor Wiper motor Horn (RH) Thermo sensor (U.S.
HARNESS LAYOUT ENGINE HARNESS (2) E02-1 TCM E02-2 TCM E02-3 TCM EM01 Connection with MAIN wiring harness EM02 Connection with MAIN wiring harness EM03 Connection with MAIN wiring harness EM04 Connection with MAIN wiring harness (A/T) EM05 Connection with MAIN wiring harness (A/T, Cruise) EM06 Connection with MAIN wiring harness (M/T, Cruise) EM07-1 Connection with ABS wiring harness EM07-2 Connection with ABS wiring harness Connection with CRASH PAD wiring harness El01 WS-207
HARNESS LAYOUT WS-208 CONTROL HARNESS C03 C04 C05 C06 C07 C08 C09 C11 C12-1 C12-2 C12-3 C12-4 C13 Purge solenoid Ignition timing adjuster Fuel pump checker Dual pressure switch (A/C) Relay with diode A/C compressor Crankshaft position sensor Noise filter Injector #1 Injector #2 Injector #3 Injector #4 Power transistor C14 C15 C17 C18 C19 C20 C21 C22 C25 C28 C30 Ignition coil ISC motor Throttle position sensor Starter solenoid extension Coolant temp gauge Coolant temp sensor Front oxygen sensor Volume
HARNESS LAYOUT CONTROL HARNESS C01-1 C01-2 C01-3 C02 MC01 ECM ECM ECM Control relay Connection with MAIN wiring harness WS-209
WS-210 MAIN HARNESS (1) HARNESS LAYOUT
HARNESS LAYOUT WS-211 MAIN HARNESS (2) M35 M36 M37 M38 M41 M45 M46 M47 M48 M49 M50 M52 M53 M54 M55 M56 M57 A/T & key lock control unit Parking brake switch Seat belt switch TACM ECT switch Door switch (FRT, RH) Door switch (RR, RH) Door switch (FRT, LH) Passive s/belt module Fuel pump Fuel sender Door switch (RR, LH) Rear heated glass (+) Speaker (RR, RH) Trunk room lamp High mounted stop lamp Speaker (RR, LH) Power antenna Over drive (O/D) switch M60 P/Position switch M64 AK Solenoid M65 AK Illuminati
HARNESS LAYOUT WS-212 CRASH PAD HARNESS I01 I07 I08 I09 I10 I11 I12 I13-1 I13-2 I13-3 I13-4 Ml01 Ml02 El01 Rheostat Cruise switch Rear defogger switch Hazard switch A/C switch Digital clock Thermo switch Cluster Cluster Cluster Reed switch Connection with Main harness Connection with Main harness Connection with Engine harness
HARNESS LAYOUT REAR/TRUNK LID HARNESS Rear wiring harness R01 Combination lamp (LH) R02 Trunk room lamp switch R03 Combination lamp (RH) MR01 Connection with MAIN harness Trunk R12 R13 R15 MR02 lid wiring harness License lamp (LH) License lamp (RH) Trunk lid opener Connection with MAIN harness WS-213
HARNESS LAYOUT WS-214 ROOF HARNESS M34 M71 M72 M73 M76 M77 M78 M80 Connection with MAIN wiring harness Map lamp Sunroof extension wiring harness Room lamp (W/O sunroof) Sunroof relay (LH) Sunroof relay (RH) Over head console lamp (W/Sunroof) Sunroof motor
HARNESS LAYOUT FRONT DOOR HARNESS D01 (D11) D02 (D12) D03 (D13) D04 D05 (D15) D06 (D16) D17 D18 D19 D10 (D20) D21 MD01 MD02 MD03 MD05 MD06 Outside mirror Speaker (FRT, LH) Power window switch Power window switch Power window motor Central door locking actuator Door latch switch (FRT, RH) Shoulder retractor (FRT, RH) Lap retractor (FRT, RH) Door lamp Trunk lid switch Connection with MAIN wiring harness Connection with MAIN wiring harness Connection with MAIN wiring harness Connection with MAIN wiring harn
WS-216 HARNESS LAYOUT REAR DOOR HARNESS D31 (D41) Power window switch D32 (D42) Power window motor D33 (D43) Central door locking actuator MD08 (MD09) Connection with MAIN wiring harness MD10 (md11) Connection with MAIN wiring harness
