Manual

13. Replacement/Adjustment of Stainless Sheet
57
[3] Move the slider to check the tension of the stainless sheet over the entire stroke zone.
,I.H\&KHFN3RLQWV±DQGDUHQRWVDWLVILHGORRVHQWKHIL[LQJVFUHZVDJDLQand readjust the stainless
VKHHWSRVLWLRQDQGWHQVLRQIURPVWHS>@DERYH
1RWH ,IWKHUHDGMXVWPHQWRI.H\&KHFN3RLQW±FDQQRWEHSHUIRUPHGZHOOUHYHUVLQJWKHIURQWDQGUHDU
SRVLWLRQVRUIOLSSLQJWKHIURQWDQGEDFNVLGHVRIWKHVWDLQOHVVVKHHWPD\PDNHLWSRVVLEOHWR
readjust.
,IWKH\VWLOOIDLOUHSODFHZLWK a new stainless sheet.
[4] After the allocation of clearances and non-FRQWDFWZLWKWKHVOLGHU¶VPDLQERG\KDYHEHHQ
FRQILUPHGWLJKWHQWKHWZRVFUHZV on the loose side alternatively and finally clamp them with a
uniform torque. If the screws are tightened withDQRQXQLIRUPWRUTXHWKHVWDLQOHVVVKHHWPD\
zigzag or float.
>@ 5HPRYHWKHFOHDUDQFHFKHFNMLJDQGWKHQPRXQWWKHUHJXODUVOLGHUFRYHUDQGPRWRUFRYHU
Caution) Be careful not to lose the coil springs during this procedure.
.H\&KHFN3RLQW± 
&KHFNWKDWWKHFOHDUDQFHEHWZHHQWKHWRSVXUIDFHRIWKHVWDLQOess sheet and the top
surface of the slider is within the designated range over the entire stroke zone.
.H\&KHFN3RLQW±
Viewing through the outsideRSHQLQJVFKHFNWKDWWKH
edges of the stainless sheet GRQRWWRXFKWKHVOLGHU¶V
PDLQERG\&KHFNWKLVDWOHDVWIRUWKUHHURXQGWULSVWURNHV
over the entire stroke zone7KHVWDLQOHVVVKHHWPD\EH
GLVSODFHGGXULQJURXQGWULSPRYHPHQWVEXWLIWKHHGJHV
WRXFKWKHVOLGHU¶VPDLQERG\ZLWKRXWLQFUHDVLQJWKH
GLVSODFHPHQWDPRXQWUHDGMXVWE\UHSHDWLQJIURPVWHS>@
DERYH
Note that the stainless sheet itself is not completely
VWUDLJKWDQGKDVVRPH]LJ]DJVWKXVLWLVQRWSRVVLEOHWR
make the right and left clearances uniform. There is no
SUREOHPDVORQJDVWKHHGJHVof the stainless sheet and
WKHVOLGHU¶VPDLQERG\GRQRWWRXFKHDFKRWKHURYHUWKH
entire stroke zone.
Make the clearance of this
part the same as the one
on the opposite side.
7LJKWHQWKHVFUHZVRQERWKVLGHVLQRUGHUWRIDVWHQWKHVWDLQHVVVKHHW
7LJKWHQLQJWRUTXH1FPNJI cm)