Electric built in Double Oven Instructions for installation and use FDE20
Contents Introduction 4 Safety Information 5 Features 7 Controls 8 Oven Timer Operation 9 Grill Pan and Handle 15 Operation when using Top Oven for Grilling 16 Conventional Grilling 17 Using the Top Oven as a Convection Oven 18 Operation when using the Top Oven as a Convection Oven 19 Using the Main Oven for Fan Cooking 20 Using the Main Oven for Other Functions 21 Temperature Conversion Chart 23 Oven Temperature Charts 24 Cooking Results Not Satisfactory? 26 Care and Cleaning
Introduction Your new appliance is guaranteed* and will give lasting service. This guarantee is only applicable if the appliance has been installed in accordance with the installation instructions detailed in this booklet. To help make best use of your cooking equipment, please read this booklet carefully. The cooker is designed specifically for domestic use and responsibility will not be accepted for use in any other installation.
Safety Information When used properly your appliance is completely safe but as with any electrical product there are certain precautions that must be observed. PLEASE READ THE PRECAUTIONS BELOW BEFORE USING YOUR APPLIANCE. Always ● Always make sure you remove all packaging and literature from inside the oven and grill compartments before switching on for the first time. ● Always make sure you understand the controls prior to using the appliance.
Safety Information Never ● Never leave children unsupervised where a cooking appliance is installed as all cooking surfaces will be hot during and after use. ● Never allow anyone to sit or stand on any part of the appliance. ● Never store items above the appliance that children may attempt to reach. ● Never remove the oven shelves whilst the oven is hot. ● Never heat up unopened food containers as pressure can build up causing the container to burst.
Features MAIN OVEN TOP OVEN TEMPERATURE TEMPERATURE & GRILL SELECTION & FUNCTION CONTROL CONTROL TOP OVEN PILOT LIGHT CLOCK & OVEN TIMER MAIN OVEN PILOT LIGHT GRILL SETTING CONTROL GRILL ELEMENT CATALYTIC SIDE LINERS GRILL PAN INNER DOOR GLASS TOP OVEN DOOR OVEN LIGHT CATALYTIC SIDE LINERS OVEN SHELF OVEN FAN MEAT PAN MAIN OVEN DOOR INNER DOOR GLASS RATING PLATE 7
Controls A GRILL SETTING CONTROL C MAIN OVEN TEMPERATURE AND FUNCTION CONTROL B TOP OVEN TEMPERATURE AND GRILL SELECTION CONTROL TIMER Control Markings Control Knob A B Description Grill Setting Control Top Oven Temperature & Grill Selection Control Function Selects the heat at which the grill will cook the food. 1 – max Grill Settings Control: 1 = Low, max = High Note: To grill you must first select a grill function using control (B).
Oven Timer Operation The oven timer offers you the following features: 1. 2. 3. Time of Day Automatic Cooking Minute Minder Automatic Cooking The Main Oven (only) can be controlled by the automatic timer. Never operate the grill or top oven when the main oven is set to cook automatically because the oven cavity can become warm and this may cause bacterial growth in food. Hints on Automatic Cooking 1. Select foods which will take the same time to cook and require approximately the same temperature. 2.
Know Your Timer CLOCKFACE The timer incorporates a 24 hour clock. Ensure the correct time of day is always set, before using your cooker. SYMBOLS A ‘bell’ symbol will light up when you select a Minute Minder Period and will remain lit for the period set. At the end of the Minute Minder Period, the timer will emit an audible tone and the ‘bell’ symbol will disappear. The ‘cookpot’ symbol will light up either:– – When the timer is in manual mode, or – During the actual Cook Period.
Electronic Clock and Automatic Oven Timer Operation SETTING THE TIME OF DAY Step 1 Make sure all oven controls are turned Off. Step 2 Check the electricity supply to the cooker is turned on. Step 3 When switched on the display will show 0.00 and the Auto symbol, flashing intermittently. Step 4 Press & hold in both the Cook Period & End Time buttons together. Step 5 With the Cook Period & End Time buttons still held in, press either the “+” or “–” buttons to set the correct time of day.
Electronic Clock and Automatic Oven Timer Operation AUTO COOKING PROGRAMMES There are two Auto Cooking programmes that can be selected using your timer:– (a) To set the timer to switch the oven(s) On and Off Automatically (b) To set timer to switch on immediately and OFF automatically after a set cook period. a) TO SET THE TIMER TO SWITCH THE OVEN(S) ON AND OFF AUTOMATICALLY This allows you to cook at a specified time for a chosen period before the oven switches off Automatically.
Electronic Clock and Automatic Oven Timer Operation Note 1 When cooking automatically the Cook Period can be checked at any time by simply pressing the Cook Period button. Note 2 When cooking automatically the End Time can be checked at any time by simply pressing the End Time button. b) TO SET TIMER TO SWITCH ON IMMEDIATELY AND OFF AUTOMATICALLY AFTER A SET COOK PERIOD Step 1 Step 2 Step 3 Check that the correct time of day is set, if not follow instructions for setting the time of day.
Electronic Clock and Automatic Oven Timer Operation TO CANCEL AN AUTO COOKING PROGRAMME BEFORE THE COOK PERIOD HAS FINISHED. Step 1 Turn the oven control(s) to the OFF position. Step 2 Press the Manual button to return the oven(s) to “Manual” operation. The ‘Auto’ symbol will go out. Note 1 When cooking automatically the Cook Period can be checked at any time by simply pressing the Cook Period button. OTHER NOTES ON TIMER OPERATION 1.
Grill Pan and Handle The grill pan handle is detachable from the pan, to facilitate cleaning and storage. The grill pan handle can be fixed as follows: (d) (a) (c) (b) Step 1 Step 2 Step 1 Step 2 Step 3 Step 4 Step 3 Step 4 Remove the screw and washers from the grill pan bracket (a). Tilt the handle over the recess (b). Slide it towards the centre of the pan (c). Locate the handle over the bracket (d). For a fixed handle, replace the screw and washers and ensure they are fully tightened up.
Operation when using the Top Oven for Grilling A GRILL SETTING CONTROL B TOP OVEN TEMPERATURE AND GRILL SELECTION CONTROL TIMER Step 1 Ensure that the timer is set to manual. Step 2 Place the grill pan runner/support in the correct position (see Grilling Guide). Locate the grill pan in the runner/support, position centrally under the grill element. Leave the door fully open. Step 3 Turn knob (B) clockwise to select grill function setting: Set to: For Half Grill (Left hand side only). For Full Grill.
Conventional Grilling CAUTION - ACCESSIBLE PARTS MAY BECOME HOT WHEN THE GRILL IS IN USE. CHILDREN SHOULD BE KEPT AWAY. GRILLING SHOULD NEVER BE UNDERTAKEN WITH THE GRILL/TOP OVEN DOOR CLOSED. The grill control is designed to provide variable heat control of either the twin grill elements on together or the single left hand grill element only, depending upon which direction the control knob is rotated.
Using the Top Oven as a Convection Oven The top oven should be used to cook small quantities of food. The oven is designed so that the grill element operates at a reduced heat output, this is combined with a heating element situated underneath the floor of the oven. To ensure even cooking of the food it is important that cooking utensils are positioned correctly on the oven shelf so that the element is directly above. As a guide, the front of the utensil should be approx.
Operation when using the Top Oven as a Convection Oven B TOP OVEN TEMPERATURE & GRILL SELECTION CONTROL A GRILL SETTING CONTROL C MAIN OVEN TEMPERATURE AND FUNCTION CONTROL TOP OVEN PILOT LIGHT TIMER Step 1 Ensure that the timer is set to manual. Step 2 Place the shelf in the correct position (see Oven Temperature Charts). Step 3 Select the required cooking temperature (100–220oC) using control (B) (see Top Oven Temperature Charts).
Using the Main Oven for Fan Cooking Since a circulaire fan oven heats up more quickly and generally cooks food at a lower temperature than a conventional oven, pre-heating is often unnecessary. Note: Charts are a guide only, to suit personal taste and requirements, it may be necessary to increase or decrease temperatures by 10oC. It may also be necessary to increase or decrease cooking times.
Using the Main Oven for Other Functions Fan Only Setting Defrosting frozen meat and poultry Joints of meat and whole birds should be defrosted slowly, preferably in a refrigerator (allowing 5-6 hours per lb.) or at room temperature (allowing 2-3 hours per lb.). Frozen meat or poultry must be completely defrosted before cooking in the oven. However, to decrease the amount of time required to defrost food items, a nonheating fan only setting may be selected for the main oven only.
Using the Main Oven for Other Functions 90 “SLOW” Setting This is used for slow cooking, keeping food warm and warming plates for short periods. Extra care should be taken when warming bone china, as it may be damaged in a hot oven. DO NOT place food or plates directly on the oven floor as this could damage both the oven lining and the plates which are being warmed. Advantages of “SLOW” cooking are: The oven stays cleaner because there is less splashing.
Temperature Conversion Chart Gas Mark ˚F Main Conventional Oven Top Convection Oven Main Fan Oven /2 250 120 110 100 1 275 140 130 120 2 300 150 140 130 3 325 160 150 140 4 350 180 170 160 5 375 190 180 170 6 400 200 190 180 7 425 220 210 200 8 450 – 220 210 9 475 – – 220 1 23
Yes Yes Pork (Slow Roasting) Pork (Foil Covered) Veal (Slow Roasting) Veal (Foil Covered) Poultry/Game (Slow Roasting) Poultry/Game (Foil Covered) 25 mins per 450g (1lb) + 25 mins extra 25 mins per 450g (1lb) + 25 mins extra 25-30 mins per 450g (1lb) + 25 mins extra 18-20 mins per 450g (1lb) + 20 mins extra 13-15 mins per 450g (1lb) eg. 5kg (11lb) = 143-165 mins 12 mins per 450g (1lb) eg.
Yes Sponge Sandwich (fatless) 15-20 mins 12-15 mins 170/190 180/200 No Yes Yes No No No No Yes Victoria Sandwich Sponge Sandwich (fatless) Swiss Roll Semi-rich Fruit Cake Rich Fruit Cakes Shortcrust Pastry Puff Pastry Yorkshire Pudding 35-45 mins 20-30 mins 3 - 4 hours 140/150 200/210 90 No Yes No Baked Custard Bread Meringues Meringues 150-180 mins 100 Yes Shelf 2 Shelf 1 30-45 mins 200/210 Yes Bread Shelf 1 40-50 mins 150/160 Yes Baked Custard Shelf 2 Shelf 2 S
Cooking Results Not Satisfactory GRILL Uneven cooking front to back Ensure that the grill pan is positioned centrally below the grill element. Fat splattering Ensure that the grill pan is not lined with foil. Ensure that the grill setting control (A) is not set too high. BAKING GENERAL Uneven rising of cakes Ensure that the oven shelves are level. Sinking of cakes The following may cause cakes to sink: 1. Pre-heating of fan ovens – not always necessary. 2.
Care and Cleaning Warning: Before cleaning, please ensure that the electricity supply to the appliance is switched off and the appliance is fully cold. 1. CATALYTIC OVEN LINERS TOP OVEN SIDE LINERS The surfaces of the oven liners are treated with a special vitreous enamel which absorbs cooking soils. At temperatures of 220°C (425°F) or above, the special surface enables these soils to be slowly destroyed. The higher the temperature the more effective it is. Cleaning.
Care and Cleaning 2. CLEANING GRILL, TOP OVEN AND MAIN OVEN (a) Base & Rear of Top Oven and Base of Main Oven. Wipe out the oven with a damp soapy cloth. For more stubborn stains on the base of the oven use a well soaped fine steel wool soap pad. GRILL PAN BASE & REAR OVEN SHELVES MAIN OVEN BASE MEAT PAN (b) Grill Pan, Meat Pans & Oven Shelves. To prevent stains from being burnt on to the grill pan, food support and rod shelf, always wash immediately after use in warm soapy water.
Care and Cleaning 3. OVEN DOORS CONTROL PANEL (a) Control Panel Regularly wipe with a clean, damp cloth and polish with a clean, dry cloth. (b) Trims OVEN DOORS It is advisable to clean the trims regularly to prevent any build up of soiling which may detract from the appearance of the cooker. The recommended method of cleaning is to wipe over the trims with a clean, soft cloth wrung out in warm water, or mild non abrasive cleaner.
Care and Cleaning Take particular care not to damage the inner surface of the door inner glass that is coated with a heat reflective layer. Do not use scouring pads, or abrasive powder, which will scratch the glass. Ensure that the glass panel is not subjected to any sharp mechanical blows. Stubborn stains can be removed by using a fine steel wool pad. For slight soiling the inner glass panel may be cleaned, while still warm, without removing it from the door.
Installation Electrical Requirements For your own safety, we recommend that your cooker is installed by a competent person such as one who is registered with NICEIC (National Inspection Council for Electrical Installation Contracting). The cooker should be installed in accordance with the latest edition of the IEE Regulations. Warning: This appliance must be earthed. Electrical Connections The installer must check that the voltage shown at the rating plate corresponds with the house electricity supply.
Installation Important It is essential that the lower cupboard is constructed in the manner illustrated i.e. having side, back, and roof panels so joined as to provide no apertures which could permit access to the oven unit when installed. 1. General The appliance is designed for mounting at a safe level into an oven housing which must be secured to the backing wall. 2. Ventilation a. The oven housing unit cabinet dimensions must comply with fig. 4. b.
Tall Cabinet Ventilation Fig. 1 Ventilation Slot required here if cabinet does not fit to ceiling -51mm x 457mm min. area 50mm Air Gap Ventilation Slot required here if the cabinet does fit to the ceiling 51mm x 457mm min. area 50mm Air Gap Ventilation Slot required here 51mm x 457mm min.
560mm Viewed down through cabinet 577mm le d exc. hans knob 560m m Cabinet 887mm No. 6 x 15mm screw (4 supplied) 875mm Fig. 3 Oven Door 597 mm mm 550 Fig. 2 887mm 878mm if cooker trim is to overlap top edge of shelf 560574m m Connector Box mm 550 * min Fig.
Something Wrong? Before calling a Service Engineer, please check through the following lists. THERE MAY BE NOTHING WRONG. Problem Check Slight odour or small amount of smoke when grill / oven used first time This is normal and should cease after a short period. Nothing works. If you find that the timer display is blank, then it is likely that there is no electricity supply to your oven.
Problem Check Grilling is uneven Ensure that Grill pan has been positioned as stated in the Grilling section of this book. Oven does not cook evenly Check: (a) Temperature and shelf positions are as recommended in the Oven Temperature Charts. (b) Oven utensils being used allow sufficient air flow around them. Oven temperatures too high or low Check temperature and shelf positions are as recommended in the Oven Temperature Charts.
Notes 37
Notes 38
If It Still Won’t Work... Contact the Service Office (0870 6070805) If something is still wrong with your appliance after you have been through the ‘Something Wrong’ list: 1. Switch off and unplug the appliance from the mains. 2. Call your nearest Service Office or local importer. When you contact us we will want to know the following: 1. Your name, address and postcode. 2. Your telephone number. 3. Clear and concise details of the fault. 4. The Model number and the Serial number of your appliance. 5.
Key Contacts Repair Service and Information Desk UK: 0870 6070805 ( Open 8am to 5.30pm Mon - Fri 9am to 5pm Sat and 10am to 4pm Sun Closed Bank Holidays) Note: Our operators will require the following information:Model Number: Serial Number: Extended Warranty To join: UK 0870 442 7661 (Open 8 to 8 Mon-Sun) Genuine Parts & Accessories Mail Order Hotline To join: UK 0870 558 5850 (Open 8.30 to 5 Mon-Fri and 8.30 to 12 Sat).
