50cm Free Standing Gas Cooker Instructions for installation and use KD3G2/G KD3G2S/IR KD3G21/G KD3G21S/IR
Contents Introduction 3 Installation Safety Information 4 10 Features 12 Control Panel Use of hotplates 13 14 Grilling 15 Oven Oven cooking charts 16 17 Care and Cleaning 18 Cooking Results Not Satisfactory? Something Wrong With Your Cooker? 19 20 If it Still Won’t Work... 21 Technical Characteristics Key Contacts 22 Back Cover You must read these instructions prior to using your appliance and retain them for future use.
Introduction Your new appliance is guaranteed* and will give lasting service. This guarantee is only applicable if the appliance has been installed in accordance with the installation instructions detailed in this booklet. To help make best use of your cooking equipment, please read this booklet carefully. The cooker is designed specifically for domestic use and responsibility will not be accepted for use in any other installation.
Installation The appliance must only be installed by a competent person. In the UK, CORGI registered installers undertake to work to safe and satisfactory standards. Before moving your cooker check that it is cool, and switch off at the cooker control unit. Movement of your cooker is most easily achieved by lifting the front as follows: Open the grill door sufficiently to allow a comfortable grip on the underside front edge of the oven roof, avoiding any grill elements.
Gas connection The cooker should be connected to the gas-supply by a corgi registered installer. During installation of this product it is essential to fit an approved gas tap to isolate the supply from the appliance for the convenience of any subsequent removal or servicing. Connection of the appliance to the gas mains or liquid gas must be carried out according to the prescribed regulation in force, and only after it is ascertained that it is adaptable to the type of gas to be used.
Electrial connection Power supply voltage and frequency: 230-240V a.c. 50 Hz. Note: the supply cable must be positioned so that it never reaches at any point a temperature 50°C higher than the room temperature. The cable must be routed away from the rear vents. Should you require it, you may use a longer cable, however, you must ensure that the cable supplied with the appliance is replaced by one of the same specifications in accordance with current standards and legislation.
Disposing of the appliance When disposing of the appliance please remove the plug by cutting the mains cable as close as possible to the plug body and dispose of it as described above. Adapting the cooker to different types of gas In order to adapt the cooker to a different type of gas with respect to the gas for which it was produced (indicated on the label attached to the lid), follow these steps: a) replace the hose holder mounted on the appliance with that supplied in the bag of “cooker accessories”.
• remove screw “V” and then the oven burner; • Unscrew the oven burner nozzle using the socket spanner for the nozzles “Z”, or a 7 mm socket spanner, and replace it with a nozzle suited to the new type of gas (see Table 1). Take particular care handling the spark plug wires and the thermocouple pipes. • Replace all the parts, following the steps described above in the reverse order.
Burner and Nozzle Specifications Table 1 Liquid Gas Burner Diameter (mm) Thermal Power kW (p.c.s.
Safety Information When used properly your appliance is completely safe but as with any electrical product there are certain precautions that must be observed. PLEASE READ THE PRECAUTIONS BELOW BEFORE USING YOUR APPLIANCE. Always l Remove all packing from inside the oven and grill compartments before switching on for the first time. l Understand the controls prior to using the appliance. l Keep children away from the appliance when grilling as the surfaces will get extremely hot during and after use.
Safety Information Never l Never line the interior of the oven with foil as this may cause the appliance to overheat. l Never leave children unsupervised where a cooking appliance is installed as all surfaces will be hot during and after its use. l Never allow anyone to sit or stand on any part of the appliance. l Never store items above the appliance that children may attempt to reach. l Never leave anything on the hob surface when unattended and not in use.
Features HOB VENTILATION SLOTS 1900W 1000W 1900W 3000W CONTROL PANEL GRILL/MEAT PAN WITH REMOVABLE HANDLE AND WIRE FOOD SUPPORT GRILL GRILL DOOR REMOVABLE INNER GLASS DOOR MAIN OVEN WIREWORK SHELF SUPPORTS MODEL & SERIAL NUMBER OVEN ROD SHELVES 12
Control Panel TIMER* ELECTRONIC* INIECTION BUTTON Control Knobs for the gas burners Electronic Ignition for the Gas Hob* MAIN OVEN GRILL LEFT FRONT BURNER LEFT REAR BURNER RIGHT REAR BURNER RIGHT FRONT BURNER The position of the gas burner controlled by each one of the knobs is shown by a solid ring •. To light one of the burners, hold a lighted match or lighter near the burner and, at the same time, press down and turn the corresponding knob counter clockwise to the maximum - setting.
Use of Hotplates Practical Advice on Using the Burners To use the burners as efficiently as possible, some basic guidelines should be followed: • Use cookware that is the right size for each burner (see table) in order to prevent the flame from spreading beyond the bottom of the cookware. • Only use cookware with flat bottoms. • As soon as the boiling point is reached, turn the knob to the lowest setting. • Always use lids with pots and pans.
Grilling GRILLING MUST BE DONE WITH THE GRILL DOOR OPEN. CONTROL KNOBS MAY BECOME HOT DURING GRILLING. CAUTION: ACCESSIBLE PARTS WILL BECOME HOT WHEN THE GRILL IS USED - CHILDREN SHOULD BE KEPT AWAY. To operate the grill proceed as follows: l Open the grill door and remove the grill pan. l Press the ignition button and then push in and turn the grill control knob anti-clockwise to the large flame symbol. Continue to press the ignition button until the spark lights the gas.
Oven The oven has different heat zones - the thermostat settings refer to the temperature on the middle shelf; above this shelf it is hotter and below it is cooler. Two shelves enable full use of the temperatures inside the oven. Each shelf has a safety stop to prevent if from being pulled out too far when attending to food. Shelves are removed from the oven by pulling them out to the stop and then lifting them at the front to withdraw. The grill pan without the handle can be used in the oven.
Oven Cooking Chart The following times and setting are for guidance only. You may wish to alter the setting to give a result more to your satisfaction. When a different setting to that shown below is given in a recipe, the recipe instructions should be followed. Allow 15 minutes preheat for best results. Always turn the thermostat knob to Mark 9 before selecting the appropriate gas Mark. Shelf position 1 is the highest. Food Gas Mark Shelf Position Approx.
Care and Cleaning Grill Remove the grill pan and the wire grid food support, it is best to wash these items immediately after use to prevent stains from being burnt on when used again. Wipe out the Grill compartment, use a fine steel wool soap pad to remove stubborn stains from the grill runners and the floor of the compartment. Wipe over the control panel with a damp cloth and polish with a dry cloth.
Cooking Results Not Satisfactory? Problem Check Grilling Uneven cooking front to Ensure that the grill pan is positioned centrally below the grill element. back Fat splattering Ensure that the grill is not set to too high a temperature. Oven Baking Uneven rising of cake Ensure that the oven shelves are level by using a spirit level on the rod shelf and adjusting, using suitable packing e.g. wood, under the feet of the appliance. This should be checked both left to right and front to back.
Something Wrong with your Cooker? Before contacting your nearest Service Centre/Installer, check the problem guide below; there may be nothing wrong with your cooker. Problem Ignition does not work Oven Cavity Oven Burner Check If all burners fail to ignite: Check that sparks appear at the burners; A clicking noise should be heard. If not Check that the plug is plugged in to a 13amp Electric socket and the supply is switched on.
If It Still Won’t Work... Contact the Service Office (0870 6070805) If something is still wrong with your appliance after you have been through the ‘Something Wrong’ list: 1. Switch off and unplug the appliance from the mains. 2. Call your nearest Service Office or local importer. When you contact us we will want to know the following: 1. Your name, address and postcode. 2. Your telephone number. 3. Clear and concise details of the fault. 4. The Model number and the Serial number of your appliance. 5.
Technical Characteristics Main Oven Dimensions (HxWxD): 34x39x31 cm Volume: 41 Litres Voltage and Frequency See data plate. Burners: Adaptable for use with all the types of gas indicated on the data plate.
Notes 23
Key Contacts Repair Service and Information Desk UK: 0870 6070805 (Open 8am to 5.30pm Mon - Fri 9am to 5pm Sat and 10am to 4pm Sun Closed Bank Holidays) Note: Our operators will require the following information:Model Number: Serial Number: Extended Warranty To join: UK 0870 442 7661 (Open 8 to 8 Mon-Sun) Genuine Parts & Accessories Mail Order Hotline To join: UK 0870 558 5850 (Open 8.30 to 5 Mon-Fri and 8.30 to 12 Sat). All Services are offered as an extra benefit and do not affect your statutory rights.
