Free Standing Gas Cooker Instructions for installation and use KD6G25X KDP60G
Contents PAGE Introduction 3 For Your Safety 4 Clock and Minute Minder Operation 6 Hotplate 8 Grill 10 Main Oven 12 Main Oven Cooking Charts 14 Top Oven 16 Top Oven Cooking Charts 18 Care and Cleaning 20 Something Wrong with your cooker? 22 Installation Instructions 24 If it still Won’t Work 31 Service Information 2 Back Cover
Introduction To help you make the best use of your cooker, PLEASE READ THIS BOOKLET CAREFULLY. Your new cooker is guaranteed and will give lasting service. The guarantee is only applicable if the cooker has been installed in accordance with the Installation Instructions. The cooker is designed specifically for domestic use and responsibility will not be accepted for use in any other installation. When first using the cooker ensure that the room is well ventilated (e.g.
For your Safety Please read the precautions below before using your cooker. ALWAYS . . . ALWAYS make sure you understand the controls before using the cooker. ALWAYS check that all controls on the cooker are turned off after use. ALWAYS stand back when opening an oven door to allow heat to disperse. ALWAYS use dry, good quality oven gloves when removing items from the ovens. ALWAYS take care when removing items from the top oven/grill when the main oven is on, as the contents may be hot.
For your Safety NEVER . . . NEVER leave children unsupervised where the cooker is installed as all surfaces will get hot during and after use. NEVER allow anyone to sit or stand on any part of the cooker. NEVER store items that children may attempt to reach above the cooker. NEVER heat up unopened food containers as pressure can build up causing the container to burst. NEVER store chemicals, food stuffs, pressurised containers in or on the cooker, or in cabinets immediately above or next to the cooker.
Clock and Minute Minder CLOCK OPERATION To Set Time of Day 00.00 Step 1 Check that the electricity supply to the cooker is turned on. Step 2 When switched on the display will show 0.00 flashing intermittently. Step 3 Press the “ “ button and then press either the “+” or “-” buttons to set the correct time of day. ❍❍❍ 12.00 ❍❍❍ Note: If the electricity supply has been off, the “+” button must be pressed once before the “-” button, if it is required to reduce the time of day.
Clock and Minute Minder MINUTE MINDER OPERATION 00.20 To Set the Minute Minder Step 1 ❍❍❍ Press the “+” button until the required time is set. A “Bell” symbol will light up. During setting the time adjusts in 10 second intervals up to a maximum of 99mins 50secs. It can also be adjusted by pressing the “-” button. At the end of the set time, a bleeping sound will be heard and the “Bell” will disappear. 13.23 ❍❍❍ The bleeper can be cancelled by pressing the “+” button.
Hotplate The hotplate lid is fitted with a safety device which cuts off the gas supply to the hotplate burners unless the lid is fully open. Do not use the safety device as a means of controlling the hotplate burners. The hotplate has one high speed burner, two normal simmering burners and one small simmering burner which will accommodate pans between 120mm (5”) and 260mm (10”) diameter. Locate the pan support trivet above one of the simmering burners if a very small pan is being used.
Hotplate SAFETY REQUIREMENTS FOR DEEP FAT FRYING 1. Never fill chip pans more than one third full with oil or fat. 2. Never leave oil or fat unattended during the heating or cooling period. 3. Never heat fat or fry with a lid on the pan. 4. Always dry food thoroughly before frying, and lower it slowly into the hot oil or fat. Frozen foods in particular will cause frothing and spitting if added too quickly. 5. Always keep the outside of the pan clean and free from streaks of oil or fat.
Grill CAUTION – ACCESSIBLE PARTS MAY BECOME HOT WHEN THE GRILL IS USED. YOUNG CHILDREN SHOULD BE KEPT AWAY. The grill is fitted with a safety device that will cut off the gas supply to the burner if the flame is extinguished for any reason. Each time the grill is used, the safety device has to be activated by pushing and holding in the control knob for 3 seconds after the gas has lit. A gentle flow of air will be blown from underneath the control panel when the grill or top oven is in use.
Grill TO 1. 2. 3. 4. USE THE GRILL Open the top oven/grill door and remove the grill pan. Remove the heat shield from the rear of the shelf for maximum grilling area. Place the shelf in the appropriate position. Press the ignition button and then push in and turn the control knob clockwise to the large flame symbol. Continue to push in the control knob for a further 3 seconds after the gas has lit, to allow time for the safety device to operate.
Main Oven The main oven is fitted with a safety device that will cut off the gas supply to the burner if the flame has been extinguished for any reason. Each time the main oven is used, the safety device has to be activated by pushing and holding in the control knob for 3 seconds after the gas has lit. The oven has different heat zones – the thermostat settings refer to the temperature on the middle shelf position; above this shelf it is hotter and below it is cooler.
Main Oven COLD START COOKING Anything requiring long slow cooking such as casseroles and rich fruit cakes can be put into a cold oven. Satisfactory results can also be obtained with creamed mixture, rich pastries or yeast mixtures, but for perfection we recommend preheating the oven for about 15 minutes at the gas mark you require for cooking. ROASTING OF LARGE POULTRY The maximum weight of poultry that can be accommodated is 11.5kg (25 lbs) of suitable shape.
Main Oven Cooking Chart The following times and setting are for guidance only. You may wish to alter the setting to give a result more to your satisfaction. When a different setting to that shown below is given in a recipe, the recipe instructions should be followed. Allow 15 minutes preheat for best results. Always turn the thermostat knob to Mark 9 first, before turning back to the required Gas Mark. Shelf position 1 is the highest.
Main Oven Cooking Chart Gas Mark Food Shelf Positions Approx. Cooking Time and Comments CAKES, PASTRIES AND BISCUITS Small cakes - 2 trays 5 1&3 17 - 25 mins - 1 tray 5 2 or 3 only " 25 - 35 mins Victoria sandwich 2x8" (205mm) 4 1&3 Fatless sponge 2x7" (180mm) 3 egg mix 5 2 20 - 25 mins. 2 tins side by side Christmas cake 2 3 or 4 4 - 61/2 hrs depending on recipe Madeira cake 7" (180mm) 4 3 11/4 - 11/2 hrs Rich Fruit cake 9" (230mm) 2 3 3 - 31/2 hrs.
Top Oven The top oven can be used to cook small quantities of food or used in conjunction with the main oven to provide additional cooking space. The top oven is fitted with a safety device that will cut off the gas supply to the burner if the flame is extinguished for any reason. Each time the top oven is used, the safety device has to be activated by pushing and holding in the control knob for 3 seconds after the gas has lit.
Top Oven TO 1. 2. 3. USE THE TOP OVEN Check that the heat shield is fitted to the shelf. Place the top oven shelf in the appropriate position (refer to cooking chart). Press in the ignition button and then push in and turn the control knob fully anti-clockwise. Continue to push in the control knob for a further 3 seconds after the gas has lit to allow time for the safety device to operate.
Top Oven Cooking Chart The following times and setting are for guidance only. You may wish to alter the setting to give a result more to your satisfaction. When a different setting to that shown below is given in a recipe, the recipe instructions should be followed. Allow 15 minutes preheat for best results. Always turn the thermostat knob to Mark 8 first, before turning back to the required Gas Mark. Shelf position 1 is the highest. Gas Mark Shelf Position 5 2 20-30 mins.
Top Oven Cooking Chart Gas Mark Food Shelf Positions Approx. Cooking Time and Comments CAKES, PASTRIES AND BiSCUITS Small Cakes (16 per tray) 5 2 20 - 25 mins. Victoria sandwich (2 x 180mm / 7”) 4 2 25 - 30 mins. Swiss Roll (3 egg quantity) 6 2 10 - 12 mins. Christmas cake (1 x 205mm / 8”) 2 2 or 3 Madeira cake (1 x 180mm / 7”) 4 2 Rich Fruit cake (1 x 180mm / 7”) 2 2 or 3 21/4 - 21/2 hrs. Gingerbread 3 2 11/2 - 13/4 hrs. Scones - 16 per tray 7 2 12 - 15 mins.
Care and Cleaning Switch off the electricity supply and allow to cool before cleaning the cooker. Clean the cooker regularly and wipe up spills soon after they occur to prevent them from becoming burnt on. Never use biological washing powder, caustic cleaners, harsh abrasives, scouring pads, steam cleaners, aerosol cleaners or oven chemical cleaners of any kind. If it is necessary to remove the cooker for cleaning, ensure that it is cool and beware that it is heavy (approximately 70 kg 155 lbs).
Care and Cleaning COOKER FINISH CLEANING METHOD Vitreous Enamel Door inner panels, pan supports, burner caps, roasting dish, grill pan, main oven base, inside of grill compartment. Cloth wrung out in warm soapy water. Stubborn stains can be removed with a cream paste, liquid cleaner or by rubbing with fine steel wool soap pads. Check that the cleaning agent is approved by the Vitreous Enamel Association. Paint Side panels. Wash with a cloth wrung out in warm soapy water only. DO NOT USE ABRASIVES.
Something Wrong with your Cooker Before contacting your Service Centre or Installer, check the problem guide below, there may be nothing wrong with your cooker. PROBLEM CHECK Burner will not light: If all burners fail to ignite: Check that sparks appear at the burners; a clicking noise should be heard. If not; Grill burner: Check that the electricity supply is turned on. If the electricity supply has failed, all burners can be lit by a match.
Something Wrong with your Cooker PROBLEM Slight odour or small amount of smoke when grill / oven used first time. CHECK This is normal and should cease after a short period. Oven cooks too fast or too slow. Check that the gas mark and shelf positions are as recommended in the Oven Cooking Charts. However, it may be necessary to increase or decrease the recommended setting slightly to suit your taste. Oven lamp does not work. The oven lamp is not covered by the guarantee.
Installation Prior to installation, ensure that the local distribution conditions (nature of the gas and gas pressure) and the adjustment conditions are compatible. The adjustment conditions for this appliance are stated on the data badge which is fitted on the back panel. This appliance is not designed to be connected to a combustion products evacuation device. It must be installed and connected in accordance with current installation regulations.
Installation TECHNICAL DATA Gas connection Pressure test point Gas rate adjustment Aeration adjustment Rp 1/2 (1/2" BSP female) Front left hotplate injector None None Electrical connection Flexible cord fitted with a 3 pin 13 amp plug 230/240V a.c. 50Hz. 13A fuse. G20 at 20mbar G30 at 28-30mbar G31 at 37mbar HEAT INPUT INJECTOR HEAT INPUT INJECTOR BURNER HOTPLATE Front left 3.0 kW 116 3.0 kW (220g/h) 86 HOTPLATE Rear left and rear right 2.0 kW 103 2.0 kW (145g/h) 70 HOTPLATE Front right 1.
Installation SPACE FOR FIXING The cooker can be close fitted below hotplate level. This requires a minimum distance of 600mm between cupboard units of hotplate height. When installing next to a tall cupboard, partition or wall, for a minimum distance of 400mm above hotplate level, allow a side clearance of at least 65mm. The diagram below illustrates the minimum clearance between the cooker and adjacent walls, cupboards etc.
Installation UNPACKING THE COOKER Unpack the components from inside the grill and oven. Check that the following parts are present: Grill pan and grid Top oven/grill shelf heat shield Pan supports Main oven shelves (2) Enamelled burner caps (4) Top oven/grill shelf (1) Aluminium burner bodies(4) Literature LEVELLING Four skid feet are fitted which can be adjusted up or down to level the cooker.
Installation STABILITY CHAIN A hole in the gas inlet valve bracket can be used to engage a stability chain. 300 670 CONNECTING TO GAS SUPPLY Connection to the cooker should be made with an approved appliance flexible connection to BS 669. A length of 0.9 to 1.25m is recommended. The length of hose chosen should be such that when the cooker is in situ, the hose does not touch the floor.
Electrical Connection WARNING – THIS APPLIANCE MUST BE EARTHED. CONNECT TO A 230-240V A.C. SUPPLY ONLY. Connection to the electricity supply should be made via a properly earthed, readily accessible wall socket which is adjacent to but not directly above, and not more than 1.25m away from the appliance and capable of electrical isolation. The mains lead should be routed such that it cannot touch hot parts of the cooker i.e. the back panel above a height of 650mm from the floor.
Installation INSTALLATION AND OPERATIONAL CHECKS After installation, check for gas soundness. The supply pressure can be checked at the front left hotplate burner injector. Fit the hotplate burner bodies and caps, pan supports and shelf shield(s). Referring to the instructions for use where necessary, 1. Check that the hotplate burners ignite and cross-light to all ports. Check for a steady flame on the low setting. 2.
If it Still Won’t Work Contact the Service Office (UK: 08709 066 066) If something is still wrong with your appliance after you have been through the ‘Something Wrong’ list: 1. Switch off and unplug the appliance from the mains. 2. Call your nearest Service Office or local importer. When you contact us we will want to know the following: 1. Your name, address and postcode. 2. Your telephone number. 3. Clear and concise details of the fault. 4. The Model number and the Serial number of your appliance. 5.
Key Contacts After Sales Service Over 1100 trained specialists, directly employed by us, ensure that you can have complete confidence in both the appliances and services we offer. Repair Service and Information Help Desk UK: 08709 066 066 Monday to Friday, 8am to 7.30pm Saturday, 8.30am to 5.30pm Sunday, 9.30am to 3.30pm www.indesitservice.co.
