Maintenance Manual

MA-6
PERIODIC MAINTENANCE
Revision: 2004 October 2004 M45
PERIODIC MAINTENANCE PFP:00026
Introduction of Periodic Maintenance ALS00099
Two different maintenance schedules are provided, and should be used, depending upon the conditions in
which the vehicle is mainly operated. After 60,000 miles (96,000 km) or 48 months, continue the periodic
maintenance at the same mileage/time intervals.
Schedule 1 ALS0009A
EMISSION CONTROL SYSTEM MAINTENANCE
Abbreviations: R = Replace. I = Inspect. Correct or replace if necessary. [ ]: At the mileage intervals only
Schedule 1
Follow Periodic Maintenance Schedule 1 if the driving habits frequently include
one or more of the following driving conditions:
● Repeated short trips of less than 5 miles (8 km).
● Repeated short trips of less than 10 miles (16 km) with outside temperatures
remaining below freezing.
● Operating in hot weather in stop-and-go “rush hour” traffic.
● Extensive idling and/or low speed driving for long distances, such as police,
taxi or door-to-door delivery use.
● Driving in dusty conditions.
● Driving on rough, muddy, or salt spread roads.
● Towing a trailer, using a camper or a car-top carrier.
Emission Control Sys-
tem Maintenance
MA-6
Chassis and Body
Maintenance
MA-7
Schedule 2
Follow Periodic Maintenance Schedule 2 if none of driving conditions shown in
Schedule 1 apply to the driving habits.
Emission Control Sys-
tem Maintenance
MA-8
Chassis and Body
Maintenance
MA-9
MAINTENANCE OPERATION MAINTENANCE INTERVAL
Reference
Section -
Page or -
Content Title
Perform at number of miles,
kilometers or months, which-
ever comes first.
Miles x 1,000
(km x 1,000)
Months
3.75
(6)
3
7.50
(12)
6
11.25
(18)
9
15
(24)
12
18.75
(30)
15
22.5
(36)
18
26.25
(42)
21
30
(48)
24
Drive belts NOTE (1) MA-12
Air cleaner filter NOTE (2) [R] MA-14
EVAP vapor lines I* MA-18
Fuel lines I* MA-14
Fuel filter NOTE (3) -
Engine coolant NOTE (4) MA-12
Engine oil R RRRRRRR MA-15
Engine oil filter (Use part No.
15208-31U00 or equivalent.)
R R RRRRR R MA-16
Spark plugs (PLATINUM-
TIPPED type)
Replace every 105,000 miles (169,000 km). MA-16
Intake & exhaust valve clear-
ance*
NOTE (5) EM-55
MAINTENANCE OPERATION MAINTENANCE INTERVAL
Reference
Section -
Page or -
Content Title
Perform at number of miles,
kilometers or months, which-
ever comes first.
Miles x 1,000
(km x 1,000)
Months
33.75
(54)
27
37.5
(60)
30
41.25
(66)
33
45
(72)
36
48.75
(78)
39
52.5
(84)
42
56.25
(90)
45
60
(96)
48
Drive belts NOTE (1) I* MA-12
Air cleaner filter NOTE (2) [R] MA-14
EVAP vapor lines I* MA-18
Fuel lines I* MA-14
Fuel filter NOTE (3) -
Engine coolant NOTE (4) R* MA-12