MSDS

MSDS 1801
MATERIAL SAFETY DATA SHEET
08/12/08 ESSENTIALLY SIMILAR TO U.S. DEPARTMENT OF LABOR FORM OSHA-174
SECTION I-IDENTIFICATION
MANUFACTURERS NAME: SCOTCH CORPORATION
ADDRESS: 1255 VICEROY DR, DALLAS, TX 75247
EMERGENCY TELEPHONE NO: 214-943-4605
TRADE NAME: INSTANT POWER MAIN LINE CLEANER
PRODUCT CODE: 1801
SECTION II-HAZARDOUS INGREDIENTS TLV
SODIUM HYDROXIDE: CAS #1310-73-2 2MG/M3 RATING: H2 R1 F0
POTASSIUM HYDROXIDE: CAS #1310-58-3 2MG/M3 RATING: H2 R1 F0
H = HEALTH R = REACTIVITY 0-LEAST 1-SLIGHT
F = FIRE E = EQUIPMENT 2-MODERATE 3-HIGH 4-EXTREME
SECTION III-PHYSICAL DATA
BOILING RANGE: >200 DEGREES C
SPECIFIC GRAVITY (H
2
0=1): 1.257-1.32
VAPOR PRESSURE: N/A
PRODUCT PH: 7.5% SOLUTION HAS PH 14.0
VAPOR DENSITY (AIR=1): N/A
% OF VALATILES: APPROXIMATELY 80%
SOLUBILITY IN WATER: COMPLETE
APPEARANCE AND ODOR: CLEAR COLORLESS LIQUID WITH NO DISTINCT ODOR
SECTION IV-FIRE AND EXPLOSION HAZARD DATA
FLASH POINT: NOT APPLICABLE
FLAMMABLE LIMITS: NOT APPLICABLE
EXTINGUISHING MEDIA: THIS PRODUCT DOES NOT BURN OR SUPPORT COMBUSTION. USE EXTINGUISHING MEDIA SUITABLE FOR THE
SURROUNDING FIRE.
SPECIAL FIRE FIGHTING PROCEDURES: WEAR FULL PROTECTIVE CLOTHING AND A SELF-CONTAINED BREATHING APPARATUS WHEN
FIGHTING CHEMICAL FIRES.
UNUSUAL FIRE AND EXPLOSION HAZARDS: CONTACT WITH SOME METALS, PARTICULARLY MAGNESIUM, ALUMINUM, AND ZINC
(GALVANIZED), CAN GENERATE EXPLOSIVE GAS.
SECTION V-HEALTH HAZARD DATA
THRESHOLD LIMIT VALUE: NOT ESTABLISHED FOR MIXTURE
EFFECTS OF OVEREXPOSURE: EYES: CAN CAUSE SEVERE BURNS AND BLINDNESS. SKIN: CAN CAUSE SEVERE BURNS, DEEP
ULCERATION, AND SCARRING. PROLONGED CONTACT DESTROYS TISSUE. INHALATION: OF MISTS CAN DAMAGE UPPER RESPIRATORY
TRACT AND LUNG TISSUE DEPENDING ON EXTENT OF EXPOSURE. IT CAN ALSO CAUSE DIFFICULTY BREATHING, LOW BLOOD PRESSURE,
DIZZINESS, BLUISH SKIN COLOR, AND LUNG CONGESTION. INGESTION: CAN CAUSE VERY SERIOUS BURNS TO THE MOUTH, ESOPHAGUS,
STOMACH AND OTHER TISSUES WHICH MAY PROVE FATAL.
EMERGENCY AND FIRST AID PROCEDURES: EYE CONTACT: FLUSH WITH WATER IMMEDIATELY FOR AT LEAST 15 MINUTES. IF WEARING
CONTACT LENS, REMOVE FIRST. WASHNG EYES WITHIN SEVERAL SECONDS IS ESSENTIAL TO ACHIEVE MAXIMUM EFFECTIVENESS. CALL
PHYSICIAN IMMEDIATELY. SKIN CONTACT: IMMEDIATELY FLOOD WITH WATER AND WASH WITH VINEGAR. REMOVE CONTAMINATED
CLOTHING. CALL PHYSICIAN IMMEDIATELY. INHALATION: REMOVE TO FRESH AIR. IF BREATHING IS DIFFICULT, ADMINISTER OXYGEN.
CALL PHYSICIAN IMMEDIATELY. INGESTION: DO NOT INDUCE VOMITING. DRINK A COUPLE OF GLASSES OF WATER OR MILK. IF VOMITING
OCCURS, KEEP AIRWAY CLEAR. CALL PHYSICIAN IMMEDIATELY.
CARCINOGEN STATUS: OSHA: N NTP: N IARC: N
PAGE 1 OF 2