Power Wheelchair Owner's Operator and Maintenance Manual

SECTION 8—SERVICE PROCEDURES
Part No 1114850 59 Recumbent Handcycle Series
Replacing Back Upholstery
 WARNING
Upholstery MUST be inspected before each use. Exposure to moisture (i.e. - wet
weather or puddles) will damage fastening straps/flaps/strips. DO NOT operate
handcycle if upholstery is wet or damaged, otherwise severe injury may occur.
Replacing Wide Back Upholstery
NOTE:Forthisprocedure,referto
FIGURE 8.12.
1. Unlatchthetwofasteningflapsthat
securethebottomofexistingback
upholsterytothebackcanes.
2. Unlatchthetopoftheexistingback
upholstery.
3. Liftupontheexistingbackupholstery
andremovefromthehandcycle.
4. Installthenewbackupholsteryonto
thehandcycle.
5. Securelylatchthefasteningflapsonthe
bottomofthenewbackupholsteryto
thebackcanes.
FIGURE 8.12 Replacing Wide Back
Upholstery
Replacing Narrow Back
Upholstery
NOTE:Forthisprocedure,referto
FIGURE 8.13.
NOTE:Pullthebackcushionofftheback
frame.
1. Alignthefasteningstripsontheback
framewiththefasteningstripsonthe
newbackcushion.
1. Pressthebackcushionfirmlyagainst
thebackframetosecure.
FIGURE 8.13 Replacing Narrow Back
Upholstery
Fastening
Flap
Back Upholstery
Fastening
Flap
Back Cane
Back Cushion
Back
Frame
Fastening
Strips
Fixed Seat
Narrow Back
Adjustable Seat
Narrow Back
Back
Frame
Fastening
Strips