iSpring WCB/WGB Series Premium Whole House Systems Version 2018-05 WCB / WGB SERIES USER MANUAL Ver.06/2018 Copyright ©2005-2018 ISPRING WATER SYSTEMS, LLC. All rights reserved.
iSpring WCB/WGB Series Premium Whole House Systems Version 2018-05 Table of Contents Product Operation and Specifications .................................................... 3 Component List ........................................................................................ 3 Tools Required.......................................................................................... 3 Parts Required (Not Included) .................................................................
iSpring WCB/WGB Series Premium Whole House Systems Version 2018-05 Product Operation and Specifications Model WGB Series WCB Series Flow Rate 3 - 15 GPM Peak Flow Rate 15 GPM 12 GPM Minimum Working Pressure 25 psi Maximum Working Pressure 80 psi Operating Temperatures 40-100 ºF (4 - 37 ºC) pH Range 6 - 11 Component List Part Description System bracket with caps Housing Cartridges Wrench Qty Metal bracket with 1'' NPT inlet / outlet Black caps Big blue housing Model # HB28B (WGB Big B
iSpring WCB/WGB Series Premium Whole House Systems Parts Required (Not Included) o o o o (2x) Shutoff valves (2x) Hex nipples or pipe nipples (2x) Pipe union pressure regulators (as needed) (1x) Ground jumper cable Installation Overview WGB32B series Page 4 Version 2018-05
iSpring WCB/WGB Series Premium Whole House Systems WGB21B/WGB22B series WCB32 series Page 5 Version 2018-05
iSpring WCB/WGB Series Premium Whole House Systems Version 2018-05 Pre-installation Notes ▪ ▪ ▪ ▪ ▪ ▪ ▪ This installation guide provides a step-by-step, start to finish procedure for installing your iSpring whole house water filter. All steps provided herein are for typical installations only. Your specific application may vary. This filter system should not be used with water that is microbiologically unsafe or of unknown quality without adequate disinfection before and/or after the system.
iSpring WCB/WGB Series Premium Whole House Systems ▪ Version 2018-05 The filter should be placed on the main water supply line near where it enters the house at any point past the main shutoff valve for the whole house, but before pipes branch off into multiple directions. However, you may choose to locate the filter after the line branches to the inside and outside plumbing depending on your filtration intent.
iSpring WCB/WGB Series Premium Whole House Systems Version 2018-05 2) Fit together pipe union and shutoff valve. Use Teflon tape on threaded fittings. 3) Simultaneously fit together shutoff valve and whole house filter using pipe nipple or hex nipple to draw them together on the FEED side of the filter. 4) Simultaneously fit together filter and the shutoff valve on the OUTLET side of the filter. Fit pipe union to shutoff valve on OUTLET side.
iSpring WCB/WGB Series Premium Whole House Systems Version 2018-05 and let the unit sit for a while, and then flush again. It is not unusual for the water to appear "cloudy" for a day or so following installation. This cloudiness is actually tiny air bubbles being purged from the filters. This is normal and will clear up in a day or two. NOTICE: After prolonged periods of nonuse (such as a vacation), it is recommended that the system be flushed thoroughly for at least 10 minutes before using the water.
iSpring WCB/WGB Series Premium Whole House Systems System Model# WCB Series PP sediment filter FP25 Granular Carbon Filter (GAC) Carbon Block Filter (CTO) FP25 WCB32 WCB32O Version 2018-05 Filter Pack# FC25 F3WCB32-O, F12WCB32-O This filter is the one included in the original system package. This filter can apply to this system, even though it is not included in the original package. Filter Change Instructions Part 1- Remove the old cartridge 1.1 Turn off the water supply to the system.
iSpring WCB/WGB Series Premium Whole House Systems Version 2018-05 Part 3- Install the New Cartridge 3.1 Remove the new filter packaging and insert the filter cartridges into the housings, making sure they slip over the standpipe in the bottom of the housing. 3.2 Align the bottom of the housing into the cap and hand tighten, then use the filter wrench (AWR3) to fit it snugly. Do not over-tighten. 3.3 Close any open valves. Turn on the water supply slowly to allow the system to fill with water.
iSpring WCB/WGB Series Premium Whole House Systems Version 2018-05 Frequently Asked Questions Q: With this whole house system, do I still need to install a water softener if my water is very hard? A: Yes, a water softener is needed if your source water has a high level of hardness, usually with TDS higher than 700 PPM. Hard water can reduce the lifespan of whole house water filter cartridges. The harder the water, the greater amount of scale buildup occurs, and the sooner the filters get clogged.
iSpring WCB/WGB Series Premium Whole House Systems Version 2018-05 Warranty Visit www.123filter.com to complete the warranty registration form online. iSpring Limited Lifetime Warranty This Limited Warranty extends to the original purchaser of the system only. This warranty only covers all Manufacturer-supplied items that prove to be defective in material, workmanship, or factory preparation.
iSpring WCB/WGB Series Premium Whole House Systems Version 2018-05 Warranty Registration Form Name __________________ Order# __________________ Email __________________ Phone ___________________ Address City Model#/ Serial Number _________________________________________________ _________ State _________ Zip Code _________ _________________________________________________ Send to: iSpring Water Systems, LLC 3020 Trotters PKWY Alpharetta, GA 30004 678-261-7611 Plumber's information (Optio
iSpring Whole House Systems Comparison Sheet Page 15 Lowers TDS Treats lead, iron, sulfur smell 45K gal at 3.0ppm for iron Y Y 15GPM Y 100K gal (1 Year) 4.5''X20'' WGB32B 150K gal at 100ppb for lead 10K gal at 3.0ppm for iron Y 5GPM 100K gal (1 Year) 4.5''X20'' WGB22B-PB Y 10GPM 100K gal (1 Year) 4.5''X20'' WGB22BM Y 15GPM 100K gal (1 Year) 4.5''X20'' WGB22B Y 15GPM 100K gal (1 Year) 4.5''X20'' WGB12B Y 12GPM Y 30K gal (6 months) 2.
iSpring WCB/WGB Series Premium Whole House Systems iSpring Water Systems, L.L.C. 3020 Trotters Pkwy, Alpharetta, GA 30004 (678) 261-7611 M-F 8:30-5:30 EST sales@ispringfilter.
