Workshop Manual

6E–4
6VE1 3.5L ENGINE DRIVEABILITY AND EMISSIONS
DTC P1107 MAP Circuit Intermittent Low
Voltage 6E–386. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
DTC P1111 IAT Sensor Circuit Intermittent
High Voltage 6E–388. . . . . . . . . . . . . . . . . . . . . . . . . . .
DTC P1112 IAT Sensor Circuit Intermittent
Low Voltage 6E–391. . . . . . . . . . . . . . . . . . . . . . . . . . . .
DTC P1114 ECT Sensor Circuit Intermittent
Low Voltage 6E–393. . . . . . . . . . . . . . . . . . . . . . . . . . . .
DTC P1115 ECT Sensor Circuit Intermittent
High Voltage 6E–395. . . . . . . . . . . . . . . . . . . . . . . . . . .
Diagnostic Trouble Code(DTC)P1120-TPS 1
Throttle Position Sensor (TPS1) Output
Abnormal 6E–398. . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
DTC P1125 ETC (Electric Throttle Control)
Limit Performance Mode 6E–401. . . . . . . . . . . . . . . . .
DTC P1133 HO2S Insufficient Switching
Bank 1 Sensor 1 6E–404. . . . . . . . . . . . . . . . . . . . . . . .
DTC P1134 HO2S Transition Time Ratio
Bank 1 Sensor 1 6E–408. . . . . . . . . . . . . . . . . . . . . . . .
DTC P1153 HO2S Insufficient Switching
Bank 2 Sensor 1 6E–412. . . . . . . . . . . . . . . . . . . . . . . .
DTC P1154 HO2S Circuit Transition Time
Ratio Bank 2 Sensor 1 6E–416. . . . . . . . . . . . . . . . . .
DTC P1167 Fuel System Rich During Decel
Fuel Cut Off (Bank 1) 6E–420. . . . . . . . . . . . . . . . . . . .
DTC P1169 Fuel System Rich During Decel
Fuel Cut Off (Bank 2) 6E–422. . . . . . . . . . . . . . . . . . . .
DTC P1171 Fuel System Lean During
Acceleration 6E–424. . . . . . . . . . . . . . . . . . . . . . . . . . .
DTC P1220 Throttle Position Senser2
(TPS2) Circuit Fault 6E–427. . . . . . . . . . . . . . . . . . . . .
DTC P1221 TPS1 – TPS2 Correlation
(Circuit Performance) 6E–430. . . . . . . . . . . . . . . . . . .
DTC P1271 APS 1– 2 Correlation Error 6E–433. . .
DTC P1272 APS 2 – 3 Correlation Error 6E–436. . .
DTC P1273 APS 1 – 3 Correlation Error 6E–439. . . .
DTC P1275 APS 1 Output Fault 6E–442. . . . . . . . . . .
DTC P1280 APS 2 Output Fault 6E–444. . . . . . . . . . .
DTC P1285 APS 3 Output Fault 6E–446. . . . . . . . . . .
DTC P1290 ETC Forced Idle Mode 6E–448. . . . . . . .
DTC P1295 ETC Power Management Mode 6E–451
DTC P1299 ETC Forced Engine Shutdown
Mode 6E–455. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
DTC P1310 ION Sensing Module Diagnosis 6E–459
DTC P1311 ION Sensing Module SEC
Line 1 Circuit Fault 6E–462. . . . . . . . . . . . . . . . . . . . . .
DTC P1312 ION Sensing Module SEC
Line 2 Circuit Fault 6E–465. . . . . . . . . . . . . . . . . . . . . .
DTC P1326 ION Sensing Module Combustion
Quality Input Circuit Fault 6E–468. . . . . . . . . . . . . . . .
DTC P1340 ION Sensing Module Cylinder ID
Fault (Cylinder Synchronization Fail) 6E–471. . . . . .
DTC P1404 EGR Stuck Closed 6E–474. . . . . . . . . . .
DTC P1441 EVAP System Flow During
Non-Purge 6E–477. . . . . . . . . . . . . . . . . . . . . . . . . . . . .
DTC P1514 TPS - MAF Correlation Error 6E–480. . .
DTC P1515 Command - Actual TPS
Correlation Error 6E–484. . . . . . . . . . . . . . . . . . . . . . . .
DTC P1516 Command - Actual TPS
Correlation Error 6E–487. . . . . . . . . . . . . . . . . . . . . . . .
DTC P1523 Actuator Control Return
Performance 6E–490. . . . . . . . . . . . . . . . . . . . . . . . . . .
DTC P1571 Brake Switch No Operation 6E–493. . . .
DTC P1625 PCM Unexpected Reset 6E–495. . . . . . .
DTC P1635 Reference Voltage # 1 Circuit
Fault 6E–496. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
DTC P1639 Reference Voltage # 2 Circuit
Fault 6E–498. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
DTC P1640 Driver-1-Output Circuit Fault
(ODM) 6E–500. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
DTC P1650 Quad Driver Module “A” Fault 6E–503. .
Symptom Diagnosis 6E–506. . . . . . . . . . . . . . . . . . . . .
Default Matrix Table 6E–535. . . . . . . . . . . . . . . . . . . . .
On Vehicle Service
Crankshaft Position (CKP) Sensor 6E–538. . . . . . . . .
Engine Coolant Temperature (ECT) Sensor 6E–538.
Heated Oxygen Sensor (HO2S) 6E–539. . . . . . . . . . .
Intake Air Temperature (IAT) Sensor 6E–542. . . . . . .
ION Sensing Module 6E–542. . . . . . . . . . . . . . . . . . . . .
Mass Air Flow (MAF) Sensor 6E–543. . . . . . . . . . . . .
Manifold Absolute Pressure (MAP) Sensor 6E–544.
Malfunction Indicator Lamp (MIL) 6E–545. . . . . . . . . .
Reduced Power Lamp 6E–545. . . . . . . . . . . . . . . . . . .
Powertrain Control Module (PCM) 6E–545. . . . . . . . .
Service Precaution 6E–545. . . . . . . . . . . . . . . . . . . .
EEPROM 6E–547. . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Throttle Position (TP) Sensor 6E–547. . . . . . . . . . . . .
Vehicle Speed Sensor (VSS) 6E–548. . . . . . . . . . . . .
Air Cleaner/Air Filter 6E–549. . . . . . . . . . . . . . . . . . . . .
Common Chamber 6E–549. . . . . . . . . . . . . . . . . . . . . .
Accelerator Pedal Replacement 6E–550. . . . . . . . . . .
Accelerator Position Sensor Replacement 6E–551. .
Accelerator Position Sensor Adjustment 6E–551. . . .
Fuel Filler Cap 6E–552. . . . . . . . . . . . . . . . . . . . . . . . . .
Fuel Filter 6E–552. . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Fuel Gauge Unit 6E–553. . . . . . . . . . . . . . . . . . . . . . . .
Fuel Injectors 6E–554. . . . . . . . . . . . . . . . . . . . . . . . . . .
Fuel Metering System 6E–555. . . . . . . . . . . . . . . . . . . .
Fuel Pump Assembly 6E–555. . . . . . . . . . . . . . . . . . . .
Fuel Pump Relay 6E–556. . . . . . . . . . . . . . . . . . . . . . . .
Fuel Rail Assembly 6E–557. . . . . . . . . . . . . . . . . . . . . .
Fuel Tank 6E–558. . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Throttle Body (TB) 6E–558. . . . . . . . . . . . . . . . . . . . . . .
Electronic Ignition System 6E–560. . . . . . . . . . . . . . . .
Catalytic Converter 6E–561. . . . . . . . . . . . . . . . . . . . . .
Air Conditioning Thermo Relay 6E–561. . . . . . . . . . .
EVAP Canister Hoses 6E–561. . . . . . . . . . . . . . . . . . . .
EVAP Canister 6E–562. . . . . . . . . . . . . . . . . . . . . . . . . .
EVAP Canister Vent Solenoid 6E–562. . . . . . . . . . . . .