SDS

Description of first aid measures
Eye Contact
If this product comes in contact with the eyes:
Wash out immediately with fresh running water.
Ensure complete irrigation of the eye by keeping eyelids apart and away from eye and moving the eyelids by occasionally lifting the upper
and lower lids.
Seek medical attention without delay; if pain persists or recurs seek medical attention.
Removal of contact lenses after an eye injury should only be undertaken by skilled personnel.
Skin Contact
If skin or hair contact occurs:
Quickly but gently, wipe material off skin with a dry, clean cloth.
Immediately remove all contaminated clothing, including footwear.
Wash skin and hair with running water. Continue flushing with water until advised to stop by the Poisons Information Centre.
Transport to hospital, or doctor.
For thermal burns:
Decontaminate area around burn.
Consider the use of cold packs and topical antibiotics.
For first-degree burns (affecting top layer of skin)
Hold burned skin under cool (not cold) running water or immerse in cool water until pain subsides.
Use compresses if running water is not available.
Cover with sterile non-adhesive bandage or clean cloth.
Do NOT apply butter or ointments; this may cause infection.
Give over-the counter pain relievers if pain increases or swelling, redness, fever occur.
For second-degree burns (affecting top two layers of skin)
Cool the burn by immerse in cold running water for 10-15 minutes.
Use compresses if running water is not available.
Do NOT apply ice as this may lower body temperature and cause further damage.
Do NOT break blisters or apply butter or ointments; this may cause infection.
Protect burn by cover loosely with sterile, nonstick bandage and secure in place with gauze or tape.
To prevent shock: (unless the person has a head, neck, or leg injury, or it would cause discomfort):
Lay the person flat.
Elevate feet about 12 inches.
Elevate burn area above heart level, if possible.
Cover the person with coat or blanket.
Seek medical assistance.
For third-degree burns
Seek immediate medical or emergency assistance.
In the mean time:
Protect burn area cover loosely with sterile, nonstick bandage or, for large areas, a sheet or other material that will not leave lint in wound.
Separate burned toes and fingers with dry, sterile dressings.
Do not soak burn in water or apply ointments or butter; this may cause infection.
To prevent shock see above.
For an airway burn, do not place pillow under the person's head when the person is lying down. This can close the airway.
Have a person with a facial burn sit up.
Check pulse and breathing to monitor for shock until emergency help arrives.
Inhalation
If fumes or combustion products are inhaled remove from contaminated area.
Lay patient down. Keep warm and rested.
Prostheses such as false teeth, which may block airway, should be removed, where possible, prior to initiating first aid procedures.
Apply artificial respiration if not breathing, preferably with a demand valve resuscitator, bag-valve mask device, or pocket mask as trained.
Perform CPR if necessary.
Transport to hospital, or doctor, without delay.
Following uptake by inhalation, move person to an area free from risk of further exposure. Oxygen or artificial respiration should be administered
as needed. Asthmatic-type symptoms may develop and may be immediate or delayed up to several hours. Treatment is essentially symptomatic.
A physician should be consulted.
Ingestion
IF SWALLOWED, REFER FOR MEDICAL ATTENTION, WHERE POSSIBLE, WITHOUT DELAY.
For advice, contact a Poisons Information Centre or a doctor.
Urgent hospital treatment is likely to be needed.
In the mean time, qualified first-aid personnel should treat the patient following observation and employing supportive measures as indicated
by the patient's condition.
If the services of a medical officer or medical doctor are readily available, the patient should be placed in his/her care and a copy of the SDS
should be provided. Further action will be the responsibility of the medical specialist.
If medical attention is not available on the worksite or surroundings send the patient to a hospital together with a copy of the SDS.
Where medical attention is not immediately available or where the patient is more than 15 minutes from a hospital or unless instructed
otherwise:
INDUCE
vomiting with fingers down the back of the throat,
ONLY IF CONSCIOUS
.
Lean patient forward or place on left side (head-down
position, if possible) to maintain open airway and prevent aspiration.
NOTE:
Wear a protective glove when inducing vomiting by mechanical means.
Most important symptoms and effects, both acute and delayed
See Section 11
Indication of any immediate medical attention and special treatment needed
Treat symptomatically.
For sub-chronic and chronic exposures to isocyanates:
This material may be a potent pulmonary sensitiser which causes bronchospasm even in patients without prior airway hyperreactivity.
Clinical symptoms of exposure involve mucosal irritation of respiratory and gastrointestinal tracts.
Conjunctival irritation, skin inflammation (erythema, pain vesiculation) and gastrointestinal disturbances occur soon after exposure.
Pulmonary symptoms include cough, burning, substernal pain and dyspnoea.
Some cross-sensitivity occurs between different isocyanates.
Noncardiogenic pulmonary oedema and bronchospasm are the most serious consequences of exposure. Markedly symptomatic patients should receive oxygen, ventilatory
support and an intravenous line.
Version No:
11.16
Page
3
of
14
PlasticBonder™ Syringe Black - Part A
Issue Date:
12/07/2023
Print Date:
12/07/2023
Continued...