Automobile User Manual

ManualsBrandsJaguar ManualsAutomobileSEMCON JLR XJ

101

102

103

104

105

106

107

108

109

110

CONTROL MODULE PIN OUT INFORMATION

AIR CONDITIONING CONTROL MODULE

77 Pin

Description

I CC28~1

COMPRESSOR CLUTCH STATUS

CC30~1

AIR CONDlTlONlNG ELECTRICAL LOAD SIGNAL

1 cc31-7

LOAD lNHlB,T

cc31-9

COMPRESSOR CLUTCH ON REOUEST

/ CC31~17

REFRIGERANT

4 WAY PRESSURE SWITCH

ENGINE CONTROL MODULE

7 Pin

Description

EM,&2

*:cml LOAD INHIBIT

I EM,O-3

A/KM ELECTRICAL LOAD SIGNAL

1 EM10-4

*/cm COMPRESSOR CLUTCH REOUEST

I EM,&1,

CRUISE CONTROL BRAKE CANCEL REOUEST

I EM,,-,

CRVISE CONTROL SET +,-

I EM,,-4

CRUISE CONTROL ON REOUEST

I EM,,-5

CRUISE CONTROL CANCEL, RESUME

/ EP.412.5

4 WAY REFRIGERANT SWlTCH HIGH PRESSURE

I EM12-6

4 WAY REFRIGERANT SWTCH HIGH PRESSURE

I EMi2-8

IGNITION MODULE

SWITCHING FEEDBACK

I Er.012.9

IGNITION MODULE I SWITCHING FEEDBACK

EM12~10

AIR

CONDITIONING COMPRESSOR RELAYACTlVATE

Active

B+ (ON,

Inactive

0”

COMPONENTS

Component

AIR CONDlTlONlNG COMPRESSOR CLUTCH

AIR

CONDlTlONlNG CONTROL MODULE

Connector / Type / Color

P136, VWAY SUMlTOP.40 90 A TYPE, BLACK

ENGINE COMPARTMENT/WC COMPRESSOR

Location / Access

RH SIDE OF TRANSMlSSlON TUNNEL, GLOVE BOX ASSEMBLY

B- 0”

CC28, ZB-WAY MULTILOCK 47, GREY

CCE! 16.WAY MULTILOCK 47, GREY

ccx, 12.WAY M”LTlLOCK 47, GREY

CC31,22-WAY MULTILOCK 47, GREY

0”

B+

Cl”12-30BARi

0”

B+ ,O”T OF ACTIVE RANGE,

BRAKE CANCEL SWITCHES

CRUISE CONTROL ON, OFF SWITCH

CRUISE CONTROL SWITCHES iSTEERiNG WHEELi

ENGINE CONTROL MODULE

CC40, 4.WAY MULTlLOCK 070 /WHITE

CCX, 10.WAY AMP MlCRO 0”AD LOCK 1 NATURAL

SW3,3~WAY EPC, BLACK, WHITE

ADJACENTTOTHE BRAKE PEDAL MOUNTING ASSEMBLY

CENTER CONSOLE ASSEMBLY

CENTER OF STEERING WHEEL

ENGINE COMPARTMENT:CONTROL MODULE ENCLOSURE

Active

GROUND

B+

GROUND IAPPLIED)

7 3 ” = RESUME, 8 8” = CANCEL B+

Inactive

GROUND

B+

FUEL INJECTOR - 1A

FUEL INJECTOR 1B

FUEL INJECTOR - *A

FUEL INJECTOR - 28

F”ELINJECT0R-U

FUEL INJECTOR - 38

FUEL INJECTOR -4A

FUEL INJECTOR - 48

FUEL PUMPS

FUSE BOX-TRUNK

IJ3,P-WAYAMPJUNIOR POWERTlMERiBLACK

IJ7, Z-WAY AMP .,“NlOR POWER TiMER, BLACK

IJ4,Pv’dAY AMP JUNIOR POWER TlMER, BLACK

I,8 i 2~WAY AMP JUNIOR POWER TIMER, BLACK

IJ5,NVAY AMP JUNIOR POWER TIMER, BLACK

IJ9,2~WAY AMP JUNIOR POWER TIMER, BLACK

IJS,Z-WAYAMPJUNlOR POWERTlMER,BLACK

IJ10,%WAY AMP JUNIOR POWER TIMER, BLACK

BT9, l-WAY SUMlTOMO DL90, NATURAL

BTIO, IO-WAY ” T A FUSE BOX, NATURAL

BTll , IO-WAY “.T A FUSE BOX i BLACK

BT,? , IO-WAY U.T.A. FUSE BOX, GREEN

BT10,10-WAY U.T.A. FUSE BOX,BL”E

BT64, EYELET

P118,2-WAY YMAKI 90, BLACK

PIZZ, ?-WAY YAZAKI 90, BLACK

Pl,B,2-WAYYAZAKl90,BLACK

Pm, Z-WAY YAZAKI 90, BLACK

P120,2-WAYYAZAKl90,BLACK

Pm, 2~WAY YAZAK, SO, BLACK

P121 , ?-WAY YAZAKI 90, BLACK

P125, ?-WAY YALAKl 90 , BLACK

EMZ,, 12.WAY IGNlTlON POWER MODULE, BLACK

EM29,12-WAY IGNlTlON POWER MODULE, BLACK

1530, Z-WAY AUGAT 1 5, BLACK

LS31 , B-WAY TRW, BLACK

CF, , P-WAY REINSHAGEN, BLACK

CE, l~!NAY REINSHAGEN, BLACK

LS26, G~WAY ECONOSEAL l/l LC, BLACK

ENGINE COMPARTMENT, INTAKE MANlFOLD

ENGlNE COMPARTMENT, INTAKE MANIFOLD

ENGINE COMPARTMENT:INTAKE MANIFOLD

ENGINE COMPARTMENT/INTAKE MANIFOLD

ENGINE COMPARTMENT, INTAKE MANIFOLD

ENGINE COMPARTMENT! INTAKE MANIFOLD

TOP OF F”ELTANK,TR”NKCARPET

TRUNK ELECTRlCAL CARRlER

B+

GROUND

B+

IGNITION COIL- 1.A

IGNITION COIL- 1B

IGNlilON COIL-N

IGNlTlON COIL-2B

IGNlTlON COIL-U

IGNITION COIL-3B

IGNlTlON COIL-W

IGNITION COIL-G

IGNlTlON MODULE - 1

IGNITION MODULE - 2

INTERCOOLER PVMP

RADIATOR FAN CONTROL RELAY MODULE

RADIATOR FAN - LH

RADIATOR FAN - RH

REFRIGERANT I-WAY PRESSURE SWITCH

ENGINE COMPARTMENT, CAMSHAFT COVER

ENGINE COMPARTMENT,CAMSHAFTCOVER

ENGlNE COMPARTMENT, CAMSHAFT COVER

ENGINE COMPARTMENT, CAMSHAFT COVER

ENGINE COMPARTMENT, CONTROL MODULE ENCLOSURE

ENGINE COMPARTMENT/ADJACENT10 RH CRUSHTUBE

ENGINE COMPARTMENT,ADJACENTTO LH CRVSHTUBE

ENGINE COMPARTMENT, BELOW LH FAN

ENGINE COMPARTMENT, BELOW RH FAN

ENGINE COMPARTMENT, ADJACENT TO LH SlDE OF RADIATOR

FUEL PUMP RELAY ACT,“ATE

CRUISE CONTROL ON STATUS LED

FUEL PUMP RELAYACTlVATE

INTERCOOLER PUMP RELAYACTlVATE

SERIES (LOW) SPEED FAN ACTIVATE

PARALLEL ,HIGHI SPEED FAN ACT,“ATE

IGNITION COIL RELAY ACTIVATE

IGNITION MODULE I SWITCHING

IGNITION MODULE 2 SfllTCHlNG

IGNITION MODULE 2 SWlTCHlNG

IGNiTlON MODULE 1 WATCHING

IGNITION MODULE 2 SWlTCHlNG

IGNlTlON MODULE 1 SWITCHING

lGNlilON MODVLE 1 SWlTCHlNG

IGNITION MODULE 1 SWlTCHlNG

INJECTOR ‘38’ ACTIVATE

INJECTOR ‘2B’ ACTIVATE

INJECTOR ‘4A’ ACTIVATE

INJECTOR ‘1W ACTIVATE

INJECTOR ‘48’ ACT,“ATE

INJECTOR ‘3A’ ACTlVATE

INJECTOR ‘2.4’ ACTlVATE

INJECTOR ‘1B’ ACT,“ATE

GROUND

5 Hz @ IDLE

5 HZ @ IDLE

5 Hz @ IDLE

5 HZ @ IDLE

5 Hz @ IDLE

5 HZ @ IDLE

5 Hz @ IDLE

GROUND

B+

RELAYS

Relay

Case Color Connector / Color

Location / Access

AIR

CONDITIONING COMPRESSOR CLUTCH

RELAY

BROWN

EM25, BROWN

CONTROL MODULE ENCLOSURE RELAYS, ENGINE COMPARTMENT

FUEL INJECTION RELAY

BROWN

EM%, BROWN

CONTROL MODVLE ENCLOSURE RELAYS, ENGINE COMPARTMENT

FUEL PUMP RELAY 2

BROWN BUS

RELAY#,,TR”NKF”SE BOX/TRUNK

FUEL PUMP RELAY 1

BROWN BUS

RELAYiM.TRUNK FUSE BOX/TRUNK

lGNlTlON COIL RELAY

BROWN EMX, BROWN

CONTROL MODULE ENCLOSURE RELAYS, ENGINE COMPARTMENT

INTERCOOLER PUMP RELAY

BLUE

EM.41, BLUE

CONTROL MODULE ENCLOSURE RELAYS, ENGINE COMPARTMENT

B+

B-

HARNESS-TO-HARNESS CONNECTORS

Connector Type I Color

BT4

54.WAY THROUGH PANEL, BLACK

EM1 12.WAY AUGAT 1 6, BLACK

EM3

14-WAY MULTILOCK 070, WHlTE

EM51 IZ-WAY AUGAT 1.6, GREY

EM53 PO-WAY MULTILOCK 070 /WHITE

FCI 54.WAY THROUGH PANEL CONNECTOR

IJ, B-WAY AUGAT 1 6, BLACK

IJ2 B-WAY AUGAT 1 6, BLACK

LS32

I-WAY YALAK,, GREY

PI1

57.WAY SUMlTOMO TS090, BLACK

PI2 IB~WAY ECONOSEAL 111 LC, BLACK

SC3 12.WAY MVLTlLOCK 070, GREY

SW, ,*-WAY MULTILOCK 040: BLACK

SW2 B-WAY JST , WHITE

Location / Access

BELOWPARCELSHELF,TR”NK/REAR B”LKHEAD,RHSIDE

ENGINE COMPARTMENT,ADJACENTTOABS PUMP

PASSENGER ‘X’ POST, LOWER ‘K POST FlNlSHER

ENGlNECOMPARTMENT,ADJACENTTOABS PUMP

PASSENGER ‘A’ POST, LOWER ‘K POST FINISHER

, BLACK

BELOW PASSENGER SIDE AIR VENT/GLOVE BOX ASSEMBLY

ENGENE, FORWARD OF INTAKE MANIFOLD

ENGlNE, FORWARD OF INTAKE MANIFOLD

FORWARD OF LH FRONTSUSPENSION ARM

ENGINE COMPARTMENT/BULKHEAD, REAR OF ENGINE

ENGINE COMPARTMENT, BRACKET ON TOP OF TRANSMlSSlON

ADJACENTTO STEERING COLUMN MOTOR

lNSlDE STEERING COLUMN COWL

CENTER OF STEERING WHEEL

GROUNDS

The following symbols are used to represent values for Control Module Pin Out data:

Input

D Serial and encoded communications

0 output

B+ Battery voltage

CAN (Network)

SG Signal Ground

V Voltage (DC)

S SCP Network

Hz Frequency

KHz Frequency x 1000

MS Milliseconds

MV Millivolts

Ground Location / Type

Ground

BT20 EYELET iSINGLE -TRUNK, 8H REAR GROUND STUD LSlOL

EM17 EYELET iSINGLE) - EMS BULKHEAD GROVND STVD LSlOR

EM17 EYELET (SINGLE, - EMS BULKHEAD GROUND STUD LS2OL

EMBR EYELET (PAIRI -EMS LH GROUND STUD

LSZIR

FC,?R

EYELET (PAIR, - EMS BULKHEAD GROUND STUD

CONTROL MODULE PIN OUT INFORMATION (FOLD OUT PAGE)

Location / Type

EYELET IPAIR) - LH FORWARD GROUND STUD

EYELET IPAIR) LH FORWARD GROUND STUD

EYELET (PAIR, - RH FORWARD GROUND STUD

EYELET iPAIR - RH FORWARD GROUND STUD

CAUTION: The information on this data page is furnished to aid the user in understanding circuit operation. THIS INFORMATION SHOULD BE USED FOR REFERENCE ONLY.

NOTE: The values listed are approximately those that can be expected at the control module connector pins with all circuit connections made and all

components connected and fitted.

“Active” means a load is applied or a switch is ON; “Inactive” means a load is not applied or a switch is OFF.

REFER TO THE FRONT OF THE BOOK FOR ILLUSTRATIONS DETAILING THE LOCATION ANQ IDENTIFICATION OF COMPONENTS, RELAYS,

CONNECTORS, HARNESSES, GROUNDS, VEHICLE CONTROL MODULES AND CONTROL MODULE PINS.

DATE

ISSUE:

SEPTEMBER

1997