Installation Guide

INSTALLATION INSTRUCTIONS
for Swinging French and Patio Doors (JII105)
8
INSTALL SCREEN SYSTEM
COMPLETE INSTALLATION
8
9
Note! Some doors are shipped with a screen track pre-installed.
For those doors, follow these instructions to install the screen
system. If the screen track was not previously installed, follow the
instructions provided with the screen to install the screen track and the
screensystem.
For French Doors:
1. Position smaller
inactive screen on
the inner track at the
top and bottom.
2. Secure inactive
screen to the side
jamb with 2 of the
provided #8 x 3"
screws through the
pre-drilled screen
edge holes.
3. Position larger active
screen on the outer
track at the top
andbottom.
4. Using a #2 Phillips
screwdriver, adjust
outer screen rollers
at top and bottom
until screen slides
properly. Turning the screws counter clockwise retracts the rollers into
theframe.
5. Adjust the wheels at both the top and bottom in order to center the
screen between the head and the sill.
Note! Excessive tension may cause binding. Adjust so the top and
bottom are parallel with the head and sill.
For Patio Doors:
1. Position screen on
the screen track at
the top and bottom.
For Both Doors:
1. Trim bug ap on
screens to desired
length. Adjust the
upper and lower
adjustment screws
to ensure smooth
screenoperation.
2. Mark where active
screen securing
hardware should
be mounted and
apply strike plate.
Door frame must
be pre-drilled to
acceptscrews.
INSTALL DRIP CAP
1. Install drip cap above
the brickmould
headertrim.
2. Cut a piece of drip
cap the length of the
header trim + 1/8"
to allow for 1/16"
overlap on each end
of the trim.
3. Apply 1/4" bead of
sealant to header
trim as shown.
4. Nail drip cap in place as shown.
5. Apply sealant underneath the drip cap where it meets both ends of
the trim.
1. Apply sealant along
both sides and top
of the door unit
where the exterior
trim rests against
the outside of the
house and where the
brickmould meets
the jambs.
Inner
screen
track
Outer
screen
track
Screen track
Screen
Mark here
Frame
Finishing
-
-
Sealant
Interior sheeting
Sealant
Sealant
Brickmould
Wall exterior
Jamb
Sealant Locations
Shown From Top