Operating Instructions and Parts Manual Toe Jack Models JTJ-2ST, JTJ-5ST and JTJ-10ST (5-Ton model shown) JET 427 New Sanford Road LaVergne, Tennessee 37086 Ph.: 800-274-6848 www.jettools.com Part No.
Warranty and Service JET warrants every product it sells against manufacturers’ defects. If one of our tools needs service or repair, please contact Technical Service by calling 1-800-274-6846, 8AM to 5PM CST, Monday through Friday. Warranty Period The general warranty lasts for the time period specified in the literature included with your product or on the official JET branded website. • JET products carry a limited warranty which varies in duration based upon the product.
Warning 1. Read and understand the entire owner’s manual before attempting to operate the toe jack. 2. This toe jack was designed and intended for use by properly trained personnel only. If you are not familiar with the proper and safe use of a toe jack, do not use this jack until proper training and knowledge have been obtained. 3. Use the jack on hard, level surfaces only. Never use the jack on a slope or soft surfaces. 4. Never load the toe jack beyond its rated capacity. 5.
Turning the release valve too quickly will make the load fall rapidly, and may lead to loss of load or damage to the jack. Failure to comply may cause serious injury and/or property damage. Unpacking Open shipping carton, which should contain one toe jack and one 2-piece handle. Check for shipping damage. Report any damage immediately to your distributor and shipping agent. Do not discard any shipping material until the toe jack is set up and operating properly.
Troubleshooting Trouble Probable Cause Remedy Release stem is open. Close release stem completely. Dirt or crack in valve sealing section. Clean and repair or replace. Jack will not lift to full height. Not enough or too much hydraulic jack oil in reservoir. Fill reservoir with correct amount of hydraulic jack oil. Toe extends, but falls immediately. Air in the system. Press ram down to the lowest position and let air out by pushing fill plug sideways. External oil leak.
JTJ-2ST 6
Parts List for JTJ-2ST 2-Ton Toe Jack Index No. Part No. Description Size Qty 1 ................ JTJ2ST-01................. Rear Handle............................................................. ...................................... 1 2 ................ JTJ2ST-02................. Front Handle ............................................................ ...................................... 1 3 ................ JTJ2ST-03................. Sealing Bolt...................................................
JTJ-5ST and JTJ-10ST 8
Parts List for JTJ-5ST 5-Ton Toe Jack Index No. Part No. Description Size Qty 1 ................ JTJ5ST-01G .............. Body......................................................................... ...................................... 1 2 ................ JTJ5ST-02................. Safety Valve Screw.................................................. ...................................... 1 3 ................ JTJ10ST-03............... O-Ring ..........................................................
Parts List for JTJ-10ST 10-Ton Toe Jack Index No. Part No. Description Size Qty 1 ................ JTJ10ST-01G ............ Body......................................................................... ...................................... 1 2 ................ JTJ10ST-02............... Safety Valve Screw.................................................. ...................................... 1 3 ................ JTJ10ST-03............... O-Ring ..........................................................
427 New Sanford Road LaVergne, Tennessee 37086 Phone: 800-274-6848 www.jettools.
