Parts Manual Instruction Manual

2-36 1250AJP 3121172
SECTION 2 TURNTABLE
208 4 Injector Pump Options:
Ref. Note: Series Letter is shown on label at base of Injector
Pump.
Prior to S/N 0300127699
7027237 A/R “A” Series
7027614 A/R “B” Series
7027615 A/R “C” Series
7027616 A/R “D” Series
S/N 0300127699 to Present
70001128 A/R “A” Series
70001129 A/R “B” Series
70001130 A/R “C” Series
70001131 A/R “D” Series
7020447 Gasket (1 per Injector)
209 Use 8320270 1 Filter, Fuel (was p/n 7016328)
210 70000916 1 Pump Fuel Supply (was p/n 7027238)
70001435 1 Repair Kit
70000917 1 O-Seal Between Fuel Pump & Engine Block (was p/n
7020411 - Not Shown)
70000918 1 Sealing Ring (Not Shown)
70000919 1 Pump, Hand (Not Shown)
211 7027239 1 Solenoid, Start (Not Shown - Located near Throttle)
212 7020414 1 V-Belt
213 7020471 4 Gasket, Exhaust Manifold to Engine Block (Not Shown)
7020486 1 Gasket, Exhaust Manifold to Exhaust Pipe (Not Shown)
214 7027240 1 Turbocharger (Not Shown)
70001857 1 Flange, Turbocharger (Not Shown)
70001135 1 Gasket (Not Shown)
215 1 Alternator Options:
7000872 Prior to S/N 0300127699
7020464 Regulator, Voltage (Not Shown)
70001867 S/N 0300127699 to Present
70001868 Regulator, Voltage (Not Shown)
216 7020479 1 Starter (Not Shown - Located on Right Side of Engine)
7026608 1 Relay, Start (Not Shown)
217 1 Sensor, Oil Pressure Options:
7020461 2000199 Engine
7027790 2000275, 2000340 & 1001098601 Engines
218 1 Sensor, Temperature Options (Not Shown):
7027241 2000199 Engine
7027791 2000275, 2000340 & 1001098601 Engines
219 7024565 1 Sensor, Speed
220 1 Actuator, Throttle Options:
7020458 2000199 Engine
7027792 2000275, 2000340 & 1001098601 Engines
7027276 2 Spring
221 1600443 1 Module, EMR2 Controller (S/N 0300085575 to Present)
222 1 Seal, Rear Main Options (Not Shown):
Not Available 2000199, 2000275 & 2000340 Engines
70002718 1001098601 Engines
FIGURE 2-6. DEUTZ TIER II & TIER III ENGINE INSTALLATION (CONTINUED)
ITEM # PART NUMBER QTY. DESCRIPTION REV.