Parts Manual Owner manual

2-20 400RTS 500RTS 3120697
SECTION 2 GROUND CONTROLS
145 1060360 1 Cable, Battery (Battery Neg to Ground)
146 0630370 2 Rod, Tie-Down
147 0400002 1 Tie-Down, Battery
2910479 2 Clips, Tie Down
148 3620027 1 Radiator
149 Not Used
150 1320020 1 U-Clamp 1 1/2"
151 1320026 1 U-Clamp 1 3/4"
0252808 Ref. PUMP COUPLING INSTALLATION (STANDARD PARTS) —
201 1660207 1 Coupling, Pump
202 0080163 1 Adapter, Pump Mounting
203 0700808 6 Bolt, Metric 8mm 1.25 x 16mm
204 4831900 6 Lockwasher, Metric 8mm
205 0641610 8 Bolt 3/8"-16NC x 1 1/4"
206 4761600 8 Lockwasher 3/8"
— — — — — — — — — —
3020021 A/R Grease, Coupling
Note: Coupling Spine must be greased with lithium soap
based grease prior to installation.
0250815 Ref. ENGINE HEATER INSTALLATION (OPTIONAL - NOT SHOWN) A
2580026 1 Heater, Engine Coolant (Located at Rear of Cylinder Head)
0701020 2 Bolt, Metric 10mm x 6mm
4564328 2 Spacer, Tube
Ref. SPARE COMPONENTS
301 7000892 1 Carburetor (Standard Gas)
1140009 1 Carburetor (LP Gas)
— — — — — — — — — —
Use 7019933 1 Carburetor Rebuild Kit (p/n was 7000878)
7023471 1 Assembly, Float (Not Shown)
70000163 1 Needle-Spring Load Fuel Valve
7012577 1 Fitting, Vacuum Line
7012578 1 Vacuum Line Assembly
7000884 1 Fuel Shut-Off
7024321 1 Gasket, Carburetor (Top)
7027607 1 Gasket, Carburetor (Bottom)
302 7012564 1 Wiring Harness
7014682 1 Tune-Up Kit (Includes Oil and Fuel Filters, Spark Plugs and
Wire Set) (“Push On” Spark Plug Wires)
7019998 1 Coil Pack (“Push On” Spark Plug Wires)
7023669 1 Plug Wire Set (“Push On” Spark Plug Wires)
7023668 1 Tune-Up Kit (Includes Oil and Fuel Filters, Spark Plugs and
Wire Set) (“Clip On” Spark Plug Wires)
7019939 1 Filter, Fuel (Not Shown)
7019949 1 Filter, Oil (Not Shown)
FIGURE 2-4. ENGINE INSTALLATION - FORD VSG-411 (CONTINUED)
ITEM # PART NUMBER QTY. DESCRIPTION REV.