Service Manual

SECTION 1 - SPECIFICATIONS
1-2 – JLG Lift – 3121201
Table 1-4. Deutz F4M2011 Specifications
Fuel Diesel
Oil Capacity
Cool in g S ys te m
Crankcase w/Filter
Total Capacity
5 Quarts (4.5 L)
11 Quarts (10.5 L)
16 Quarts (15 L)
Idle RPM 1000
Low RPM 1800
High RPM 2800
Alternator 60 Amp, belt drive
Battery 1000 Cold Cranking Amps,
210 Minutes Reserve Capacity,
12 VDC
Fuel Consumption
Lo w RP M
High RP M
1.90 GPH (7.19 lph)
2.50 GPH (9.46 lph)
Horsepower 65 @ 3000 RPM, full load
Table 1-5. Deutz D2011L04 Specifications
Fuel Diesel
Oil Capacity
Coolin g S ys te m
Cran kc as e
Total Capacity
5 Quarts (4.5 L)
11 Quarts (10.5 L) w/Filter
16 Quarts (15 L)
Idle RPM 1000
Low RPM 1800
High RPM 2500
Alternator 60 Amp, belt drive
Battery 950 Cold Cranking Amps, 205
Minutes Reserve Capacity, 12 VDC
Fuel Consumption
L ow RPM
High RP M
1.90 GPH (7.19 lph)
2.50 GPH (9.46 lph)
Horsepower 49 @ 2500 RPM, full load
Table 1-6. Caterpillar 3044C Specifications
Type Four Stroke Cycle
Cylinders 4 in-line
Bore 3.70 inch (94 mm)
Stroke 4.72 inch (120 mm)
Aspiration turbocharged
Compression ratio 19:1
Displacement
203 in
3
(3.33 L)
Firing Order 1-3-4-2
Rotation (viewed from flywheel) Counterclockwise
Oil Capacity (w/filter) 10.6 quarts (10 L)
Cooling System (Engine Only) 5.8 quarts (5.5 L)
Idle RPM 1000
Low RPM 1800
High RPM 2800
Alternator 60 Amp, belt drive
Battery 930 Cold Cranking Amps, 205
Minutes Reserve Capacity, 12
VDC
Table 1-7. GM 3.0L
Fuel Gasoline or Gasoline/LP Gas
No. of Cylinders 4
BHP
Ga soline
LP
83 hp @ 3000 rpm
75 hp @ 3000 rpm
Bore 4.0 in. (101.6 mm)
Stroke 3.6 in. (91.44 mm)
Displacement 181 cu.in. (3.0 L, 2966 cc)
Oil Capacity w/filter 4.5 qts. (4.25 L)
Minimum Oil Pressure
at id le
Ho t
6 psi (0.4 Bar) @ 1000 rpm
18 psi (1.2 Bar) @ 2000 rpm
Compression Ratio 9.2:1
Firing Order 1-3-4-2
Max. RPM 2800