Service Manual Instruction Manual
Table Of Contents
- Section A. Introduction - Maintenance Safety Precautions
- Section 1. Specifications
- Section 2. General
- Section 3. Chassis & Turntable
- 3.1 Tires And Wheels
- 3.2 Torque Hub
- Oil Information
- Roll and Leak Testing
- Tightening and Torquing Bolts
- Main Disassembly
- Output Carrier Disassembly
- Input Carrier Disassembly
- Hub-Spindle Disassembly
- Spindle-Brake Disassembly
- Cover Disassembly
- Cover Assembly
- Input Carrier Sub-Assembly
- Output Planet Gear Sub-Assembly
- Spindle - Brake Sub-Assembly
- Hub-Spindle Sub-Assembly
- Cover Sub-Assembly
- Main Assembly
- Integral Brake Check
- 3.3 Free Wheeling Option
- 3.4 Drive Motor
- 3.5 Oscillating Axle Bleeding Procedure and Lockout Test
- 3.6 Steer Adjustments
- 3.7 Swing Drive
- 3.8 Swing Bearing
- 3.9 Swing Brake - Mico
- 3.10 Rotary Coupling
- 3.11 Generator
- 3.12 Deutz D2.9 L4 Engine
- 3.13 Deutz D2011 Engine
- 3.14 Spark Arrester Cleaning Instructions
- 3.15 Glow Plugs
- 3.16 Deutz EMR 2
- 3.17 Bio Fuel in Deutz Engines
- 3.18 GM Engine General Maintenance
- 3.19 GM Engine Dual Fuel System
- Fuel Filter
- Direct Electronic Pressure Regulator (DEPR)
- Air Fuel Mixer
- Electronic Throttle Control (ETC)
- Electric Lock Off
- Engine Control Module (ECM)
- Heated Exhaust Gas Oxygen Sensor
- Gasoline Multi Point Fuel Injection System (MPFI)
- Gasoline Fuel Pump
- Gasoline Pressure And Temperature Sensor Manifold
- Fuel Filter
- Fuel Injector Rail
- Fuel Injector
- 3.20 GM Engine Fuel System Repair
- Propane Fuel System Pressure Relief
- Propane Fuel System Leak Test
- Propane Fuel Filter Replacement
- Direct Electronic Pressure Regulator (DEPR) Maintenance And Inspection
- Check/Drain Oil Build-Up In 2-Stage Vaporizer
- Air Fuel Mixer/Throttle Control Device Maintenance And Inspection
- Exhaust System And Catalytic Converter Inspection And Maintenance
- Temperature Manifold Absolute Pressure (TMAP) Sensor
- Throttle Body (ETC) Replacement
- Mixer Replacement
- Electronic Pressure Regulator (EPR) Replacement
- Regulator Replacement
- Coolant Hose Replacement
- Vapor Hose Replacement
- Engine Control Module Replacement
- Heated Exhaust Gas Oxygen Sensor Replacement
- 3.21 GM Engine LPG Fuel System Diagnosis
- Section 4. Boom & Platform
- Section 5. Hydraulics
- 5.1 O-Ring Lubrication
- 5.2 Cylinders - Theory of Operation
- 5.3 Cylinder Checking Procedure
- 5.4 Cylinder Removal and Installation
- Cylinder Locations
- Main Boom Telescope Cylinder Removal
- Main Boom Telescope Cylinder Installation
- Main Boom Lift Cylinder Removal
- Main Boom Lift Cylinder Installation
- Upright Level Cylinder Removal
- Upright Level Cylinder Installation
- Tower Boom Lift Cylinder Removal
- Tower Lift Cylinder Installation
- Tower Telescope Cylinder Removal
- Tower Telescope Cylinder Installation
- 5.5 Hydraulic Cylinder repair
- Tower Boom Lift Cylinder
- Cleaning and Inspection
- Assembly
- Upright Level Cylinder
- Cleaning and Inspection
- Assembly
- Master Cylinder
- Cleaning and Inspection
- Assembly
- Main Boom Lift Cylinder
- Cleaning and Inspection
- Assembly
- Main Boom Telescope Cylinder
- Cleaning and Inspection
- Assembly
- Tower Boom Telescope Cylinder
- Cleaning and Inspection
- Assembly
- Platform Level (Slave) Cylinder
- Cleaning and Inspection
- Assembly
- Jib Lift Cylinder (AJ Only)
- Cleaning and Inspection
- Assembly
- Steer Cylinder
- Cleaning and Inspection
- Assembly
- Axle Lockout Cylinder
- 5.6 Hydraulic Pump (Gear)
- 5.7 Variable Pump
- 5.8 Hydraulic Component Start-Up
- 5.9 Pressure Setting Procedures
- Section 6. JLG Control System
- Section 7. Basic Electrical Information & Schematics

SECTION 3 - CHASSIS & TURNTABLE
3-102 – JLG Lift – 3121616
Table 3-12. DTC to SPN/FMI Cross Reference Chart
DTC Description SPN Code FMI Code
16 Crank Never Synced at Start 636 8
91 Fuel Pump Low Voltage 94 4
92 Fuel Pump High Voltage 94 3
107 MAP Low Voltage 106 4
108 MAP High Pressure 106 16
111 IAT Higher Than Expected 1 105 15
112 IAT Low Voltage 105 4
113 IAT High Voltage 105 3
116 ECT Higher Than Expected 1 110 15
117 ECT Low Voltage 110 4
118 ECT High Voltage 110 3
121 TPS 1 Lower Than TPS 2 51 1
122 TPS 1 Signal Voltage Low 51 4
123 TPS 1 Signal Voltage High 51 3
127 IAT Higher Than Expected 2 105 0
129 BP Low Pressure 108 1
134 EGO 1 Open/Inactive 724 10
154 EGO 2 Open/Inactive 520208 10
171 Adaptive Learn High Gasoline 520200 0
172 Adaptive Learn Low Gasoline 520200 1
182 Fuel Tem p G aso lin e Low Vo lt ag e 174 4
183 Fuel Tem p G asol in e H ig h Vo lt ag e 174 3
187 Fuel Temp LPG Low Voltage 520240 4
188 Fuel Temp LPG High Voltage 520240 3
217 ECT Higher Than Expected 2 110 0
219 Max Govern Speed Override 515 15
221 TPS 2 Signal Voltage Low 51 0
222 TPS 2 Signal Low Voltage 520251 4
223 TPS 2 Signal High Voltage 520251 3
261 Injector Driver 1 Open 651 5
262 Injector Driver 1 Shorted 651 6
264 Injector Driver 2 Open 652 5
265 Injector Driver 2 Shorted 652 6
267 Injector Driver 3 Open 653 5
268 Injector Driver 3 Shorted 653 6
270 Injector Driver 4 Open 654 5
271 Injector Driver 4 Shorted 654 6
336 Crank Sync Noise 636 2
337 Crank Loss 636 4
341 Cam Sync Noise 723 2
342 Cam Sensor Loss 723 4
420 Gasoline Cat Monitor 520211 10
524 Oil Pressure Low 100 1