Service Manual Owner's manual
Table Of Contents
- Section 1. Specifications
- Section 2. General
- Section 3. Chassis & Turntable
- 3.1 Tires & Wheels
- 3.2 Wheel Drive Assembly, 2WD
- 3.3 Drive Motor - 2WD (Prior to S/N 83331)
- 3.4 Drive Motor (S/N 83331 to Present)
- 3.5 Torque Hub
- 3.6 Wheel Drive Assembly, 4WD
- 3.7 Torque Hub (4WD Machines W/ Integral Brake)
- Roll, Leak and Brake Testing
- Tightening and Torquing Bolts
- Main Disassembly
- Input Carrier Disassembly
- Output Carrier Disassembly
- Housing-Spindle Disassembly
- Spindle-Brake Disassembly
- Input Carrier Sub-Assembly
- Output Carrier Sub-Assembly
- Spindle-Brake Sub-Assembly
- Housing-Spindle Sub-Assembly
- DW2B Integral Brake Check
- Main Assembly
- 3.8 Drive Brake, 2WD - Mico (Prior to S/N 83331)
- 3.9 Re-Aligning torque hub input coupling
- 3.10 Oscillating Axle Bleeding Procedure and Lockout Test
- 3.11 Swing Drive Hub
- 3.12 Swing Brake - Mico (Prior to S/N 66417)
- 3.13 Swing Motor (Prior to S/N 66417)
- 3.14 Swing Motor (S/N 66417 to Present)
- 3.15 Procedure For Setting Gear Backlash
- 3.16 Swing Bearing
- 3.17 Rotary Coupling
- 3.18 Generator
- 3.19 Ford EFI Engine
- 3.20 Deutz EMR 2 (S/N 85332 to Present)
- 3.21 GM Engine General Maintenance
- 3.22 GM Engine Dual Fuel System
- Fuel Filter
- Electric Lock Off
- EPR Assembly
- Low Pressure Regulator (LPR)
- Air Fuel Mixer
- Electronic Throttle Control (ETC)
- Engine Control Module
- Heated Exhaust Gas Oxygen Sensor
- Gasoline Multi Point Fuel Injection System (MPFI)
- Gasoline Fuel Pump
- Gasoline Pressure And Temperature Sensor Manifold
- Fuel Filter
- Fuel Injector Rail
- Fuel Injector
- 3.23 GM Engine Fuel System Repair
- Propane Fuel System Pressure Relief
- Propane Fuel System Leak Test
- Propane Fuel Filter Replacement
- Electronic Pressure Regulator (EPR) Assembly Replacement
- Temperature Manifold Absolute Pressure (TMAP) Sensor
- Electronic Throttle Control Replacement
- Mixer Replacement
- Coolant Hose Replacement
- Vapor Hose Replacement
- Engine Control Module Replacement
- Heated Exhaust Gas Oxygen Sensor Replacement
- 3.24 GM Engine LPG Fuel System Diagnosis
- Section 4. Boom & Platform
- Section 5. Hydraulics
- Section 6. JLG Control System
- Section 7. Basic Electrical information & schematics
SECTION 3 - CHASSIS & TURNTABLE
3-168 – JLG Lift – 3121139
562 System Voltage Low 168 17
563 System Voltage High 168 15
601 Flash Checksum Invalid 628 13
604 RAM Failure 630 12
606 COP Failure 629 31
642 External 5V Reference Low 1079 4
643 External 5V Reference High 1079 3
685 Power Relay Open 1485 5
686 Power Relay Shorted 1485 4
687 Power Relay Short to Power 1485 3
1111 Fuel Rev Limit 515 16
1112 Spark Rev Limit 515 0
1151 Closed Loop Multiplier High LPG 520206 0
1152 Closed Loop Multiplier Low LPG 520206 1
1155 Closed Loop Multiplier High Gasoline 520204 0
1156 Closed Loop Multiplier Low Gasoline 520204 1
1161 Adaptive Learn High LPG 520202 0
1162 Adaptive Learn Low LPG 520202 1
1165 LPG Cat Monitor 520213 10
1171 LPG Pressure Higher Than Expected 520260 0
1172 LPG Pressure Lower Than Expected 520260 1
1173 EPR Comm Lost 520260 31
1174 EPR Voltage Supply High 520260 3
1175 EPR Voltage Supply Low 520260 4
1176 EPR Internal Actuator Fault 520260 12
1177 EPR Internal Circuitry Fault 520260 12
1178 EPR Internal Comm Fault 520260 12
1612 RTI 1 loss 629 31
1613 RTI 2 Loss 629 31
1614 RTI 3 Loss 629 31
1615 A/D Loss 629 31
1616 Invalid Interrupt 629 31
1625 Shutdown Request 1384 31
1626 CAN Tx Failure 639 12
1627 CAN Rx Failure 639 12
1628 CAN Address Conflict Failure 639 13
1629 Loss of TSC 1 639 31
2111 Unable to Reach Lower TPS 51 7
2112 Unable to Reach Higher TPS 51
2135 TPS 1/2 Simultaneous Voltages 51 31
2229 BP Pressure High 108 0
Table 3-14. DTC to SPN/FMI Cross Reference Chart
DTC Description SPN Code FMI Code