Service Manual Owner's manual
Table Of Contents
- Section 1. Specifications
- Section 2. General
- Section 3. Chassis & Turntable
- 3.1 Tires & Wheels
- 3.2 Wheel Drive Assembly, 2WD
- 3.3 Drive Motor - 2WD (Prior to S/N 83331)
- 3.4 Drive Motor (S/N 83331 to Present)
- 3.5 Torque Hub
- 3.6 Wheel Drive Assembly, 4WD
- 3.7 Torque Hub (4WD Machines W/ Integral Brake)
- Roll, Leak and Brake Testing
- Tightening and Torquing Bolts
- Main Disassembly
- Input Carrier Disassembly
- Output Carrier Disassembly
- Housing-Spindle Disassembly
- Spindle-Brake Disassembly
- Input Carrier Sub-Assembly
- Output Carrier Sub-Assembly
- Spindle-Brake Sub-Assembly
- Housing-Spindle Sub-Assembly
- DW2B Integral Brake Check
- Main Assembly
- 3.8 Drive Brake, 2WD - Mico (Prior to S/N 83331)
- 3.9 Re-Aligning torque hub input coupling
- 3.10 Oscillating Axle Bleeding Procedure and Lockout Test
- 3.11 Swing Drive Hub
- 3.12 Swing Brake - Mico (Prior to S/N 66417)
- 3.13 Swing Motor (Prior to S/N 66417)
- 3.14 Swing Motor (S/N 66417 to Present)
- 3.15 Procedure For Setting Gear Backlash
- 3.16 Swing Bearing
- 3.17 Rotary Coupling
- 3.18 Generator
- 3.19 Ford EFI Engine
- 3.20 Deutz EMR 2 (S/N 85332 to Present)
- 3.21 GM Engine General Maintenance
- 3.22 GM Engine Dual Fuel System
- Fuel Filter
- Electric Lock Off
- EPR Assembly
- Low Pressure Regulator (LPR)
- Air Fuel Mixer
- Electronic Throttle Control (ETC)
- Engine Control Module
- Heated Exhaust Gas Oxygen Sensor
- Gasoline Multi Point Fuel Injection System (MPFI)
- Gasoline Fuel Pump
- Gasoline Pressure And Temperature Sensor Manifold
- Fuel Filter
- Fuel Injector Rail
- Fuel Injector
- 3.23 GM Engine Fuel System Repair
- Propane Fuel System Pressure Relief
- Propane Fuel System Leak Test
- Propane Fuel Filter Replacement
- Electronic Pressure Regulator (EPR) Assembly Replacement
- Temperature Manifold Absolute Pressure (TMAP) Sensor
- Electronic Throttle Control Replacement
- Mixer Replacement
- Coolant Hose Replacement
- Vapor Hose Replacement
- Engine Control Module Replacement
- Heated Exhaust Gas Oxygen Sensor Replacement
- 3.24 GM Engine LPG Fuel System Diagnosis
- Section 4. Boom & Platform
- Section 5. Hydraulics
- Section 6. JLG Control System
- Section 7. Basic Electrical information & schematics
SECTION 6 - JLG CONTROL SYSTEM
3121139 – JLG Lift – 6-53
PM BATTERY … Displays battery voltage at platform module
TEMP... Displays ground module temperature
ELEV. CUTOUT … Displays elevation cutout switch status
FUNC. CUTOUT … Displays function cutout switch status
CREEP… Displays creep switch status
TILT … Displays measured vehicle tilt
AUX POWER … Displays status of auxiliary power switch
HORN … Displays status of horn switch
R FILTER … Displays status of return filter switch
C FILTER … Displays status of charge pump filter
LOAD LENGTH … Displays length switch status
ANGLE … Displays angle switch status
LOAD … Displays load sensor value
NOTE: Not displayed if load = 0.
DATALOG
ON … Displays total controller on (EMS) time
ENGINE … Displays engine run time
DRIVE … Displays total controller drive operation time
LIFT … Displays total controller lift operation time
SWING … Displays total controller swing operation time
TELE … Displays total controller tele operation time
MAX.TEMP … Displays maximum measured heatsink temp.
MIN.TEMP … Displays minimum measured heatsink temp.
MAX.VOLTS … Displays maximum measured battery voltage
RENTAL … Displays total controller operation time
NOTE: can be reset
ERASE RENTAL Not available at password level 2
YES:ENTER, NO:ESC ENTER resets rental datalog time to zero
VERSIONS
GROUND … Displays ground module software version
PLATFORM … Displays platform module software version
ANALYSER … Displays Analyzer software version
Table 6-8. Diagnostic Menu Descriptions