Owner manual

INDEX
INDEX - 4
3/20/97
L
Lap Valves
. . . . . . . . . . . . . . . . . . . . . . . . . .3 - 36
Lift Linkage Repair
. . . . . . . . . . . . . . . . . . . . .8 - 7
. . . . . . . . . . . . . . . . . . . . . . . . . . . .8 - 8
. . . . . . . . . . . . . . . . . . . . . . . . . . . .8 - 9
. . . . . . . . . . . . . . . . . . . . . . . . . . . .8 - 10
Lubricant Storage
. . . . . . . . . . . . . . . . . . . . .2 - 20
M
Measure Camshaft End Play
. . . . . . . . . . . . .3 - 38
Measure Piston Ring End Gap
. . . . . . . . . . .3 - 44
Metric Fastener Torque Grade 7
. . . . . . . . . .2 - 7
Metric Fastener Torque Values
. . . . . . . . . . .2 - 6
Mixing Of Lubricants
. . . . . . . . . . . . . . . . . . .2 - 20
Mower Decks
. . . . . . . . . . . . . . . . . . . . . . . .8 - 11
Mower Deck Drive Belt
. . . . . . . . . . . . . . . . .8 - 20
Mower Deck Specifications
. . . . . . . . . . . . . .2 - 4
. . . . . . . . . . . . . . . . . . . . . . . . . . . .2 - 5
O
Oil
4-Cycle Gasoline
Europe
. . . . . . . . . . . . . . . . . . . . . . .2 - 15
North America
. . . . . . . . . . . . . . . . .2 - 14
Hydrostatic Transmission
Europe
. . . . . . . . . . . . . . . . . . . . . . .2 - 19
North America
. . . . . . . . . . . . . . . . .2 - 18
Oil Filters
. . . . . . . . . . . . . . . . . . . . . . . . . . .2 - 20
O-ring Boss Fittings
. . . . . . . . . . . . . . . . . . .2 - 11
O-ring Face Seal Fittings
. . . . . . . . . . . . . . . .2 - 11
P
Power Train
. . . . . . . . . . . . . . . . . . . . . . . . .2 - 3
PTO And Headlights Circuits Operation
. . . . .4 - 56
PTO Circuit Test Points
. . . . . . . . . . . . . . . . .4 - 58
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .4 - 59
PTO Clutch Test
. . . . . . . . . . . . . . . . . . . . . .4 - 71
PTO Switch Tests
. . . . . . . . . . . . . . . . . . . . .4 - 71
Push Rod Repair Specifications
. . . . . . . . . . .3 - 4
R
Reading Electrical Schematics
. . . . . . . . . . .4 - 5
Rebore Cylinder Block
. . . . . . . . . . . . . . . . .3 - 52
Reciprocating Balancer Shaft Repair
Specifications
. . . . . . . . . . . . . . . . . .3 - 6
Recondition Valve Seats
. . . . . . . . . . . . . . . .3 - 35
Regulated Votage Output Test
. . . . . . . . . . .4 - 65
Remove & Install Carburetor
. . . . . . . . . . . . .3 - 29
Remove & Install Fuel Tank And
Dash Panel Assembly
. . . . . . . . . . . .3 - 26
Remove And Install Balancer Shaft
. . . . . . . .3 - 39
Remove And Install Camshaft
. . . . . . . . . . . .3 - 37
Remove And Install Crankcase Oil Seal
. . . . .3 - 49
Remove And Install Crankshaft
. . . . . . . . . . .3 - 47
Remove And Install Cylinder Block
. . . . . . . .3 - 51
Remove And Install Cylinder Head
. . . . . . . . .3 - 32
Remove And Install Engine
. . . . . . . . . . . . . .3 - 31
Remove And Install Flywheel
. . . . . . . . . . . . 3 - 36
Remove And Install Governor
. . . . . . . . . . . . 3 - 40
Remove And Install Hydraulic
Valve Lifters
. . . . . . . . . . . . . . . . . . 3 - 38
Remove And Install Key Switch And
PTO Switch
. . . . . . . . . . . . . . . . . . . 4 - 74
Remove And Install Oil Pan
. . . . . . . . . . . . . 3 - 48
Remove And Install Oil Pan Seal
. . . . . . . . . 3 - 49
Remove And Install Rocker Arms
. . . . . . . . . 3 - 32
Remove and Install Seat Switch
. . . . . . . . . . 4 - 74
Remove And Install Starter
. . . . . . . . . . . . . . 4 - 77
Remove And Install Starter Solenoid
. . . . . . . 4 - 75
Remove And Install Stator And
Ignition Module
. . . . . . . . . . . . . . . . 4 - 75
Remove And Install Valves And Springs
. . . . 3 - 33
Remove Piston Assembly
. . . . . . . . . . . . . . 3 - 41
Repair Starter And Replace Brushes
. . . . . . . 4 - 77
Replace Bendix Drive
. . . . . . . . . . . . . . . . . 4 - 77
Replace Fuel Filter
. . . . . . . . . . . . . . . . . . . 3 - 28
S
Seat Removal And Installation
. . . . . . . . . . . 8 - 22
Seat Switch Test
. . . . . . . . . . . . . . . . . . . . . 4 - 68
Serial Number Locations
. . . . . . . . . . . . . . . 2 - 24
Service Recommendations
O-ring Boss Fittings
. . . . . . . . . . . . . . . . 2 - 11
O-ring Face Seal Fittings
. . . . . . . . . . . . 2 - 11
Slow Idle Speed Adjustment
. . . . . . . . . . . . . 3 - 20
. . . . . . . . . . . . . . . . . . . . . . . . . . . 3 - 21
Spark Plug Specifications
. . . . . . . . . . . . . . . 4 - 3
Start Solenoid Test
. . . . . . . . . . . . . . . . . . . 4 - 66
Starter Amp Draw Test
. . . . . . . . . . . . . . . . . 4 - 66
Starter Specifications
. . . . . . . . . . . . . . . . . . 4 - 3
Stator Specifications
. . . . . . . . . . . . . . . . . . 4 - 3
Steering Column Bushings Replacement
. . . 7 - 6
Steering Gear Assembly Removal
. . . . . . . . 7 - 5
Steering Repair
. . . . . . . . . . . . . . . . . . . . . . 7 - 5
Steering Service Equipment & Tools
. . . . . . . 7 - 3
Steering Specifications
. . . . . . . . . . . . . . . . . 2 - 5
Synthetic Lubricants
. . . . . . . . . . . . . . . . . . 2 - 20
T
Theory Of Operation Information
. . . . . . . . . 4 - 4
Throttle Cable Adjustment
. . . . . . . . . . . . . . 3 - 18
Tires
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 2 - 5
Torque Values
Face Seal Fittings with
Inch Stud Ends
. . . . . . . . . . . . . 2 - 9
Face Seal Fittings with
Metric Stud Ends
. . . . . . . . . . . . 2 - 10
Inch Fastener
. . . . . . . . . . . . . . . . . . . . 2 - 8
Metric Fastener
. . . . . . . . . . . . . . . . . . . 2 - 6
Metric Fastener Grade 7
. . . . . . . . . . . . 2 - 7
Traction Drive Belt
. . . . . . . . . . . . . . . . . . . . 2 - 4
Tractor Identification Number
. . . . . . . . . . . . 2 - 24
U
Unregulated Voltage Output Test
. . . . . . . . . 4 - 65