User Guide

Published in U.S.A. www.johnsoncontrols.com
M9102-AGA-3S and M9104-xGA-3S Series Electric Non-Spring Return Actuators Installation Instructions6
Metasys® is a registered trademark of Johnson Controls, Inc.
All other marks herein are the marks of their respective owners.
© 2008 Johnson Controls, Inc.
Controls Group
507 E. Michigan Street
Milwaukee, WI 53202
Repair Information
If the M9102 or M9104 Series Electric Non-Spring Return Actuator fails to operate within its specifications, replace
the unit. For a replacement electric actuator, contact the nearest Johnson Controls representative.
Technical Specifications
M9102-AGA-3S and M9104-xGA-3S Series Electric Non-Spring Return Actuators
Power Requirements M910x-AGA-3S AC 24 V +25%/-20% at 50/60 Hz, 2.1 VA, Class 2, Safety Extra-Low Voltage
(SELV)
M9104-IGA-3S AC 24 V +25%/-20% at 50/60 Hz, 3.0 VA, Class 2, SELV
M9104-GGA-3S AC 24 V +25%/-20% at 50/60 Hz, 3.6 VA, Class 2, SELV
Control Type M910x-AGA-3S Floating Control without Timeout
M9104-IGA-3S Floating or On/Off Control with Timeout
M9104-GGA-3S Proportional Control
Input Signal M9102-AGA-3S AC 24 V +25%/-20% at 50/60 Hz, Class 2, SELV
M9104-AGA-3S AC 24 V +25%/-20% at 50/60 Hz, Class 2, SELV without Timeout
M9104-IGA-3S AC 24 V +25%/-20% at 50/60 Hz, Class 2, SELV with Timeout
M9104-GGA-3S DC 0 (2) to 10 V or 0 (4) to 20 mA with field furnished 500 ohm resistor
Motor Input Impedance 200 ohms Nominal
Running Torque M9102 Series 18 lb·in (2 N·m)
M9104 Series 35 lb·in (4 N·m)
Travel Time M9102 Series 30 seconds at 60 Hz (36 seconds at 50 Hz) for 90° of rotation
M9104 Series 60 seconds at 60 Hz (72 seconds at 50 Hz) for 90° of rotation
Rotation Range 93° ±3°, CW or CCW
Cycles 100,000 Full Stroke Cycles;
2,500,000 Repositions at Rated Running Torque
Audible Noise Rating 35 dBA Nominal at 39-13/32 in. (1 m)
Electrical Connections M3 Screw Terminals
Mechanical
Connections
Up to 1/2 in. (13 mm) Diameter Round Damper Shaft or 3/8 in. (10 mm)
Square Damper Shaft
Enclosure NEMA 1, IP40
Ambient Conditions Operating -4 to 140°F (-20 to 60°C); 90% RH Maximum, Noncondensing
Storage -20 to 150°F (-29 to 66°C); 90 RH Maximum, Noncondensing
Compliance North America UL Listed, File E27734, CCN XAPX (United States) and XAPX7 (Canada)
Actuator housing is Plenum Rated per CSA C22.2 No. 236/UL 1995, Heating
and Cooling Equipment
European Union CE Mark, EMC Directive 89/336/EEC
Australia and
New Zealand
C-Tick Mark, Australia/NZ Emissions Compliant
Shipping Weight 1.0 lb (0.5 kg)
The performance specifications are nominal and conform to acceptable industry standards. For application at conditions beyond these
specifications, consult the local Johnson Controls office. Johnson Controls, Inc. shall not be liable for damages resulting from misapplication or
misuse of its products.