Brochure

ManualsBrandsJohnson Controls ManualsDampersVA9203 24V On/Off Electric Spring Return Valve Actuator (27 lb-in)

Table Of Contents

VA9203-xxx-xx Series Electric Spring Return Valve Actuators Product Bulletin 1

Refer to the QuickLIT Web site for the most up-to-date version of this document.

The VA9203-xxx-xx Series Electric Spring Return

Valve Actuators are direct-mount valve actuators.

These bidirectional actuators are used to provide

accurate positioning on Johnson Controls® VG1000

Series 1/2, 3/4, and 1 in. (DN15, DN20, and DN25) ball

valves in Heating, Ventilating, and Air Conditioning

(HVAC) applications. A mechanical spring return

system provides rated torque with or without power

applied to the actuator. The series includes the

following control options:

• On/Off, 24 V, or 85 to 264 VAC power

• On/Off and Floating Point, 24 V power

• Proportional, 24 V power, for 0(2) to 10 VDC or

0(4) to 20 mA Control Signal

An accessory crankarm and remote mounting kit are

available for applications where the actuator cannot be

direct-coupled to the damper shaft. An optional line

voltage auxiliary switch indicates an end-stop position

or performs switching functions within the selected

rotation range.

Figure 1: VA9203 Spring Return Electric Valve

Actuator

Table 1: Features and Benefits (Part 1 of 2)

Features Benefits

Direct Mounting with a Single Screw Reduces installation time and cost.

Electronic Stall Detection Protects from overload at all angles of rotation. Power consumption is

reduced holding mode. The actuator may be stalled anywhere in its

rotation range without the need for mechanical end switches.

Double-Insulated Construction Eliminates need for electrical ground connection for regulatory agency

compliance.

Microprocessor-Controlled Brushless DC

Motor (-AGx and -GGx Models)

Provides constant runtime independent of torque and ensures long life.

External Mode Selection Switch

(-AGx and -GGx Models)

Permits control logic reversal for Floating Control (-AGx Models). Permits

calibration input signal range selection, and control logic reversal for

Proportional Control (-GGx Models).

Integral Cables with Colored and Numbered

Conductors

Simplify installation and field wiring.

Integral 1/2 in. (13 mm) Threaded Conduit

Connector(s)

Simplify installation and field wiring.

Optional Integrated Auxiliary Switch Provides adjustable switch point with line voltage capability.

Plenum Rated Models Enable use in other environmental air spaces (plenums) in accordance

with section 300.22(C) of the National Electric Code.

Optional Thermal Barrier Provides for 284°F (140°C) hot water or 15 psi saturated steam

applications.

VA9203-xxx-xx Series Electric Spring Return Valve

Actuators

Product Bulletin

VA9203-GGx-2Z, VA9203-AGx-2Z, VA9203-Bxx-2

Code No. LIT-12011702

Issued July 6, 2011

Summary of content (13 pages)

PAGE 1
VA9203-xxx-xx Series Electric Spring Return Valve Actuators Code No. LIT-12011702 Product Bulletin Issued July 6, 2011 VA9203-GGx-2Z, VA9203-AGx-2Z, VA9203-Bxx-2 Refer to the QuickLIT Web site for the most up-to-date version of this document. The VA9203-xxx-xx Series Electric Spring Return Valve Actuators are direct-mount valve actuators. These bidirectional actuators are used to provide accurate positioning on Johnson Controls® VG1000 Series 1/2, 3/4, and 1 in.
PAGE 2
Table 1: Features and Benefits (Part 2 of 2) Features Benefits Available Weather Shield for Field Mounting Provides NEMA 3R protection for the actuator. Override Control (Proportional Models Only) Supports manual control system override application through field wiring. Underwriters Laboratories Inc.® (UL), CE Mark, and C-Tick Compliance Provides internationally recognized regulatory agency appovals.
PAGE 3
VA9203-Bxx-2 Series On/Off Actuators The VA9203-Bxx-2 Series Actuators provide on/off control of VG1000 1/2, 3/4, and 1 inch ball valves in HVAC systems. On/off control can be provided from a manual switch, controller, auxiliary switch from a fan motor contactor, or similar device. Operation VA9203-xxx-xx Series Actuators provide 95º of rotation. A graduated scale from 0% to 100% and a position indicator provide visual indication of stroke.
PAGE 4
Wiring Diagrams VA9203-GGx-2Z Series Proportional Actuators DC 0(2)...10 V Control 0(4)...20 mA Control with External Resistor BLK RED GRY ORN 1 3 4 2 BLK RED GRY ORN 3 4 1 2 Override to MIN position Override to MAX position BLK RED GRY ORN 3 4 1 2 BLK RED GRY ORN 3 4 1 2 AC 24 V + + ~ B A AC 24 V DC 0(2)...10 V AC/DC 24 V ~(+) DC 0(2)...10 V + AC/DC 24 V Y ~(+) + DC 0(2)...10 V 500Ω / 0.25 W U Y U COM COM A Open = MIN Position A Closed = Normal Operation + DC 0(2)...
PAGE 5
VA9203-Bxx-2 Series On/Off Actuators VA9203-AGx-2Z Series On/Off and Floating Point Actuators On/Off Control, Two Wire RA RA DA DA BLK RED GRY ORN 3 4 2 1 BLK RED 2 1 - ~ AC 24 V 50/60 + DC 24 V N L1 AC 85...
PAGE 6
Ordering Information Table 2 shows the VA9203-xxx-xx Series Electric Spring Return Valve Actuator models. VA9203-AGB-2Z 90 <25 X 6 5.1 (2.8) – VA9203-BGA-2 <75 <25 X 6 5.0 (2.5) – X X VA9203-BGB-2 <75 <25 X VA9203-BUA-2 <75 <25 VA9203-BUB-2 <75 <25 VA9203-GGA-2Z 90 <25 X VA9203-GGB-2Z 90 <25 X X 6 5.0 (2.5) – X X – – 0.06 (0.02) X X X – – 0.06 (0.02) X 6 5.1 (2.8) – X X 6 5.1 (2.8) – X X X 1/2 in. (13 mm) Conduit Connectors X 120 in. (3.
PAGE 7
Dimensions See Figure 7, Table 4, and Table 5 for valve actuator dimensions. 3-1/2 (89) Clearance Required 2-7/8 (73) 3-1/4 (82) A FIG:VA9203X_dims Port Marking Locations D Figure 7: Spring Return VA9203 Actuated VG1241, VG1245, VG1841, and VG1845 Series Ball Valve Dimensions, in. (mm) Table 4: VA9203 Actuated VG1241, VG1245, VG1841, and VG1845 Series NPT Ball Valve Dimensions, in. (mm) Valve Size in. (DN)1 A B 1/2 (DN15) 4-5/8 (117.
PAGE 8
See Figure 8 and Table 6 for valve actuator dimensions with optional M9000-561 Thermal Barrier installed. 3-1/2 (89) Clearance Required 2-7/8 (73) 3-1/4 (82) A FIG:VA9203X_dimsthbr Port Marking Locations D Figure 8: Spring Return VA9203 Actuated VG1241, VG1245, VG1841, and VG1845 Series Ball Valve with Optional M9000-561 Thermal Barrier Installed Dimensions, in.
PAGE 9
Technical Specifications VA9203-GGx-2Z Series Proportional Electric Spring Return Actuator (Part 1 of 2) Power Requirements AC 24 V (AC 19.2 V to 28.8 V) at 50/60 Hz: Class 2 (North America) or Safety Extra-Low Voltage (SELV) (Europe), 4.7 VA Running, 2.7 VA Holding Position DC 24 V (DC 21.6 V to 28.8 V): Class 2 (North America) or SELV (Europe) 1.
PAGE 10
VA9203-GGx-2Z Series Proportional Electric Spring Return Actuator (Part 2 of 2) Fluid Temperature Limits Ambient Conditions VG12x1 and VG18x1 Series 23 to 203°F (-5 to 95°C), Not Rated for Steam Service VG12x5 and VG18x5 Series -22 to 212°F (-30 to 100°C), Not Rated for Steam Service VG12x5 and VG18x5 Series with M9000-561 Thermal Barrier Installed -22 to 284°F (-30 to 140°C) water; 15 psig (103 kPa) at 250°F (121°C) Saturated Steam Standard Operating -22 to 140°F (-30 to 60°C); 90% RH Maximum, Non
PAGE 11
VA9203-AGx-2Z Series On/Off and Floating Point Electric Spring Return Actuators (Part 2 of 2) Rotation Time for 90 Degrees of Travel Power On (Running) 90 Seconds Constant for 0 to 27 lb·in. (3 N·m) Load, at all Operating Conditions Power Off (Spring Returning) 12 to 17 Seconds for 0 to 27 lb·in. (3 N·m) Load, at Room Temperature 16 Seconds Nominal at Full Rated Load 22 Seconds Maximum with 27 lb·in.
PAGE 12
VA9203-Bxx-x Series On/Off Electric Spring Return Actuator (Part 1 of 2) Power Requirements Auxiliary Switch Rating -BGx-2 Models AC 24 V (AC 19.2 V to 28.8 V) at 50/60 Hz: Class 2 (North America) or Safety Extra-Low Voltage (SELV) (Europe), 5 VA Running, 1.6 VA Holding Position DC 24 V (DC 21.6 V to 28.8 V): Class 2 (North America) or SELV (Europe) 2.8 W Running, 0.8 W Holding Position Minimum Transformer Size: 6 VA per Actuator -BUx-2 Models AC 100 V to 240 V (AC 85 V to 264 V) at 50/60 Hz: 0.
PAGE 13
VA9203-Bxx-x Series On/Off Electric Spring Return Actuator (Part 2 of 2) Enclosure Rating Compliance Shipping Weight NEMA 2 (IP54) for all Mounting Directions United States UL Listed, CCN XAPX, File E27734; to UL 60730-1A: 2003-08, Ed. 3.1, Automatic Electrical Controls for Household and Similar Use; and UL 60730-2-14: 2002-02, Ed. 1, Part 2 Particular Requirements for Electric Actuators Canada UL Listed, CCN XAPX7, File E27734; to UL 60730-1:02-CAN/CSA: July 2002, 3rd Ed.