Product Manual

14 15
THIS PRODUCT IS NOT INTENDED FOR LIFTING / HOISTING
Symptom Possible Causes Corrective Action
Motor will not
operate or runs in
one direction only
Motor runs
extremely hot
Motor runs but with
insufficient power or
line speed
Motor runs but drum
does not turn
Winch runs backwards
1. Broken wires or bad battery
connection
2. Switch inoperative
3. Damaged winch
4. Damaged solenoid
5. Circuit breaker malfunction
1. Long period of operation
2. Damaged during operation
1. Weak/Low battery
2. Battery to Winch wire too long
3. Poor battery connection
4. Poor ground
5. Damaged motor
Clutch not engaged
1. Battery wires reversed
2. Switch wires reversed
3. Switch installed incorrectly
1. Check for poor connection(s) and that all wiring is tight
and clean
2. Check that switch wires are connected properly to
the solenoid
3. Replace or repair
4. Replace solenoid
5. Replace circuit breaker
1. Allow to cool
2. Replace or repair
1. Recharge or replace battery. Check charging system.
2. Use only supplied wires. If increase in length is needed,
drop down wire size to 2 or 3 AWG.
3. Check battery terminals for corrosion. Clean as required.
4. Check and clean connections
5. Replace or repair
Engage clutch
1. Recheck wiring
2. Recheck wiring
3. Check switch installation
LIMITED LIFETIME WARRANTY: Hampton Products International Corporation Warrants product according to provisions below:
Mechanical components are warranted for lifetime of the winch to be free from defects of material and workmanship. Electrical
components are warranted for 1 year to be free from defects of material or workmanship. If a defect in material or workmanship
occurs, call 800-533-7372 for instructions on how to have the Product repaired or replaced. This Warranty applies only to the
original Purchaser/Consumer of the Products from the date of purchase of the Product. Defective Products returned become
property of the manufacturer. Limitations on the Warranty: The following limitations apply to the Warranty: (a) The Warranty applies
only to Products which are defective in material or workmanship. This Warranty does not cover normal wear and tear. The Warranty
does not cover service or labor charges which are incurred in removing or replacing any Product. (b) The Warranty does not cover
the winch nish or wire rope. Accordingly, the manufacturer will not replace, repair or renish any Products if the nish on the
Product is worn in any manner. (c) The Warranty does not extend to Products which are damaged or which fail as a result of the
Product being abused, neglected, or misused in any manner, or as a result of any accident, or which are misapplied, overloaded,
improperly installed, or altered in any manner by anyone other than the manufacturer its agents or representatives.
Obligations of Purchaser/Consumer. To obtain the benets of the Warranty, The Purchaser/Consumer must return the defective
Product(s), freight prepaid together with proof of purchase within the warranty period from the date of purchase to Hampton
Products or an authorized service center.
Legal Rights and Limitations of Purchaser/Consumer. THIS WARRANTY GIVES YOU SPECIFIC LEGAL RIGHTS AND YOU ALSO MAY
HAVE OTHER RIGHTS WHICH VARY FROM STATE TO STATE. ANY IMPLIED WARRANTY OF MERCHANTABILITY OR FITNESS FOR
A PARTICULAR PURPOSE ON ANY PRODUCT SHALL BE LIMITED TO TERMS OF WARRANTY FROM THE DATE OF PURCHASE AT
RETAIL TO THE ORIGINAL PURCHASER. SOME STATES DO NOT ALLOW LIMITATIONS.
Hampton Products International Corp.
50 Icon
Foothill Ranch, CA 92610 USA
800-533-7372
www.keeperwinches.com or [e-mail]
If a problem arises, DO NOT RETURN TO RETAILER call Keeper ® Winch Customer Service at 800-533-7372 or
e-mail [e-mail].
Troubleshooting
Instrucciones de ensamblaje y operación
KW7.5RM
Cabrestante eléctrico de 3,402 kg (7,500 lbs.) 12 VCD
Hampton Products International Corp.
50 Icon
Foothill Ranch, CA 92610 USA
800-533-7372
www.keeperwinches.com o [e-mail]
¡PRECAUCIÓN!
LEA Y COMPRENDA ESTE MANUAL ANTES DE INSTALAR
Y OPERAR ESTE PRODUCTO.
NO DEVUELVA ESTE PRODUCTO AL VENDEDOR.
LLAME A CABRESTANTE KEEPER AL 800-533-7372
PARA OBTENER AYUDA
! !
CABRESTANTES
™