Installation guide

ManualsBrandsKenmore Elite ManualsCooktopOfficial Kenmore Elite gas cooktop

iNSTALLATiON AND SERVICE MUST BE PERFORMED BY A QUALiFiED iNSTALLER.

iMPORTANT: SAVE FOR LOCAL ELECTRICAL iNSPECTOR'S USE.

READ AND SAVE THESE iNSTRUCTiONS FOR FUTURE REFERENCE.

If the information in this manual is not followed exactly, a fire or explosion may result

causing property damage, personal injury or death.

FOR YOUR SAFETY:

-- Do not store or use gasoline or other flammable vapors and liquids in

the vicinity of this or any other appliance.

WHAT TO DO IF YOU SMELL GAS:

Do not try to light any appliance.

Do not touch any electrical switch; do not use any phone in your building.

Immediately call your gas supplier from a neighbor's phone.

Follow the gas supplier's instructions.

If you cannot reach your gas supplier, call the fire department.

Installation and service must be performed by a qualified installer, service agency or

the gas supplier.

Gas Cooktop

Dimensions

21/2"

30" Min.

(76.2 cm) _la

Gas Cooktop (6.4 cm)

Cutout Dimensions , tt

Figure 1

i_!_iiii__i_i_i_!iii!_i_i_¸i_i_i!_!_!_i_i_i_i_i_i_!ii_!!!!!_i_i_i_i_i_i_i_i_i_i_i_i_i_!_!_!_!_!!!!_ii_

30" GasCooktop 30 (76.2) 213A(55.2) 4_A(10.8) 27(68.6) 19 (48.3)

36" GasCooktop 36 (91.4) 213A(55.2) 4_A(10.8) 33_/4(84.5) 19(48.3)

30" GasCooktop 27Y4(69.2) 273A(70.5) 19_/8(48.6) 19s/8(49.8) 8 (20.3)

36" GasCooktop 33_/4(84.5) 333A(85.7) 19_/8(48.6) 19s/8(49.8) 8 (20.3)

All dimensions are stated in inches and (cm).

Dimension H includes a 5" (12.7 cm) space underneath the cooktop for connection to gas supply line.

NOTE: Wiring diagrams for this cooktop are enclosed in this booklet

Printed in United States

318201470 (0606) Rev. A

English - pages 1-9

Espar_ol - p_qginas 10-18

Wiring Diagram 19-20

Summary of content (20 pages)

PAGE 1
iNSTALLATiON AND SERVICE MUST BE PERFORMED BY A QUALiFiED iNSTALLER. iMPORTANT: SAVE FOR LOCAL ELECTRICAL iNSPECTOR'S USE. READ AND SAVE THESE iNSTRUCTiONS FOR FUTURE REFERENCE. If the information causing property damage, in this manual personal is not followed exactly, a fire or explosion may result injury or death. FOR YOUR SAFETY: -- Do not store or use gasoline or other flammable vapors and liquids in the vicinity of this or any other appliance.
PAGE 2
Important Notes to the Installer I. Read all instructions contained in these installation instructions before installing the cooktop. 2. Remove all packing material before connecting the electrical supply to the cooktop. 3. Observe all governing codes and ordinances. 4. Be sure to leave these instructions with the consumer. 5. Note: For operation at 2000 ft. elevations above see level, appliance rating shall be reduced by 4 percent for each additional 1000 ft.
PAGE 3
13" (33 cm) Max. Depth For Cabinet Installed Above Cooktop. I 18" Min, (45.7 cm) B 11/2" (3.8 cm)Minimum Distance Between Rear Edge of Cutout and Nearest Combustible Surface Above Countertop, Clearance 30" (76.2 cm) Min, Clearance Between the Top of the Cooking Platform and Unprotected Wood or Metal Cabinet k 24" \ cm) _To eliminate the risk of burns or fire from reaching over heated surfaces, cabinet storage space located above the cooktop should be avoided.
PAGE 4
Typical Gas Cooktop Installation Over an Electric Built-in Oven Installed Under the Counter I_---- 18" (45.7 cm) Max.-----_ 4" (10.2 cm) 61_2" Manifold Pi 5" ,(16.5 cm) Flare (12.7cm) Min.
PAGE 5
Typical Under Counter Installation of an Electric Built-in Oven with a Cooktop Mounted Above Junction box must be located approx. 3" to the left of the built-in oven cutout, Side filler panels are necessary to isolate the unit from adjoining cabinets. Panel height should allow for installation of approved cooktop models. See "Typical Gas Cooktop Installation Over an Electric Built-in Oven Installed Under the Counter" on previous page.
PAGE 6
Wall Outlet Location To clamp down, insert an angle bracket into the slot on each side of the unit as shown.Run thumb screw up through the bracket, up against the bottom of the counter. Tighten until the unit draws down and is secure. 12"_ Provide an Adequate Gas Supply This cooktop is designed to operate on natural gas at 4" of manifold pressure only. 10" Recommended 12OV grounded on rear wall. _..
PAGE 7
Important: Remove allpackingmaterialand literaturefromcooktopbeforeconnecting gasand electrical supplyto cooktop. Install Pressure Regulator Install the pressure regulator with the arrow on the regulator pointing up toward the unit in a position where you can reach the access cap. The supply line must be equipped with an approved manual shutoff valve. This valve should be located in the same room as the cooktop and should be in a location that allows ease of opening and closing.
PAGE 8
120 volt, 60 Hertz, properly grounded branch circuit protected by a 15 amp circuit breaker or time delay fuse. Do not use an extension cord with this cooktop. C. Place a burner cap on each burner head, matching the cap size to the head size. Each burner cap has an inner locating ring which centers the cap correctly on the burner head. Grounding D. Be sure that all the burner caps and burner heads are correctly placed BEFOREusing your cooktop.
PAGE 9
4.Adjustthe "low" setting for regular surface burner valves(Figureg) a. Push in and turn control to LITE until burner ignites. b. Quickly turn knob to LOWEST POSITION. c. If burner goes out, reset control to OFF. d. Remove the surface burner control knob. e. Insert a thin-bladed screwdriver into the hollow valve stem and engage the slotted screw inside. Flame size can be increased or decreased with the turn of the screw. Turn counterclockwise to increase flame size. Turn clockwise to decrease flame size.
PAGE 10
LA INSTALACION Y EL SERVICIO DEBEN SER REAUZADOS POR UN INSTALADOR CALiFICADO. IMPORTANTE: GUARDE ESTAS INSTRUCCIONES PARA USO DEL iNSPECTOR ELECTRICO LOCAL. LEA Y GUARDE ESTAS INSTRUCCIONES PARA FUTURAS REFERENCIAS [F_ ocurrir Si todas las instrucciones de este manual no son observadas a la letra, se puede incendios o explosiones que pueden causar da_os materiales, lesiones o la muerte.
PAGE 11
,,Aseg_rese que la plancha de cocinar sea instalada y puesta a tierra correctamente pot un instalador o t&cnico calificado. Notas importantes para el instalador: I. Lea todas las instrucciones de instalaci6n antes de realizar la instalaciOn de la plancha de cocinar. 2. Retire todos los articulos de embalaje antes de realizar las conexiones el_ctricas a la plancha de cocinar. 3. Observe todos los cOdigos o reglamentos estatales 4. Asegt_rese que el consumidor tenga estas instrucciones. 5.
PAGE 12
Max,profundidad degabinetes instalados por encimadela plancha de empotar es13" (33cm). 18"Min. (45.7cm) 1Y2"(3.8cm)MinimoDistancia entreelhordeposterior del huecoy la mascercasuperficie combustible porencimadel mostrador. ¢ Espacio 30" (76.2 cm) Minimo de espacio entre la parte superio de la plataforma de la plancha de cocinar y el fondo de una madera non protegida o armario metalico. No es posible utilisar cajones con esta parrilla de cocinar porqu_ la caja de empalme se extiende de 3s/32" (8.
PAGE 13
Instalaci6n tipica de la plancha homo el6ctrico empotrado de cocinar a gas pot encima de un instalado debajo del mostrador # 4" (10.2cm) 61/2 '' Tubo mOIti 5" (13.5 cm) (12.7cm) Min.
PAGE 14
Tipica instalaci6n de un horno el6ctrico empotrado plancha de cocinar por encima Todas las fijaciones de montaje deben de estar utilizadas para sujetar el homo empotrado a los armarios. Refiere alas instrucciones de instalacion del homo empotrado. con una Entrepar_os Ilenador de lados son necesarios para aislar el aparato de los armarios adyacentes. La altura de panel debe de permitir la instalacion de modelos de planchas de cocinar aprobantes.
PAGE 15
Ubicaci6n de la toma de corriente Para ajustar el aparato, inserte la consola de escuadra, con el lado desviado,en las ranuras en cada lado del aparato. El tornillo de orejas debe entonces de pasar a tray,s del soporte y hasta la parte de abajo del mostrador. Apri_telo de la pared 1 2 It hasta que el aparato se quede ajustado. Provea un adecuado suministro de gas Esta plancha de cocinar esta diseflada para utilizar gas natural de 4" de presiOn m01tiple solamente.
PAGE 16
Instalad6n deJ regulador de presi6n Instale el regulador de presiOn con la flecha del regulador apuntando hacia la unidad en una posiciOn que permita alcanzar la tapa de entrada. No ajuste demasiado la conexiOn. El regular esta fundida a presiOn. AI ajustar demasiado se puede romper el regulador causando una fuga de gas y un posible incendio o explosion. Valvula de FLUJO_DELGAS cierre Uni6n Uni6n manual Abier_ I _ (On) _.
PAGE 17
Requerimientos eJectricos Anillo de localizaci6n Un circuito derivado conectado correctamente a tierra de 120 voltios, 60 Herz protegido por un interruptor automatico de 15 amp o un fusible de retardo. No utilice un cable flexible de extensi6n en esta plancha de cocinar. Instrucciones para la puesta \ Tapa del quemadore a tierra IMPORTANTE Pot favor, lea atentamente. Como medida de seguridad personal, debe conectarse a tierra correctamente.
PAGE 18
4.Ajuste bajo ("LO") ara la v_lvula de los quemadores de superficie (Figura 9) a. Presione y gire el control hasta la posici6n LITEpara prender los quemadores. b. Gire r,_pidamente gire la perilla a la POSICIONMAS BAJA. En sentido de las manecillas del t_ En sentido opuesto _ a las manecillas reloj del reloj c. Si el quemador se apaga, reajuste el control a OFF. d. Retire la perilla del quemador de superficie. e.
PAGE 19
TOP Bb_NER LGN I TER OPT [ ONAL OLJEMADOR DE E'\OEND DO SUPERIOR DPC I ONAL _:)UG I E D' ALLb,_AGE BRL_ EUR CAUTION: iL] LABEL ALL WIRES PRIOR TO DISCONNECTION WHEN SERVICING CONTROLS _IRIM] E_OR CAN CAbbiE [_R{_ER A_ DANGEWOb<_ OPTRATION VERIFY PROPER ORERA_]_ AFTER DERVICIKG AVISO: ETIOL_TE TOP BUF;I_:ER iGNITER OPT / ONAI OUEMAF>OR DE ENCENOIDU BUrR/OR OPCIO_ B0bO I E D" ALLUHADE-Bia_t.
PAGE 20
C;_ [3LJ_N R ]ON ER Ob_',IDS_ OF NC [XU]DO UPROR I_JGiE rl'R[ L LJ_AGE E_RtJl EUR CAUT I,q_" ION; A ,,, N( _,1 El _11 Oi £N _ROPEI ,/ R[: Of [ I<(_N (At3 Hi IAT [ON _[ (F_ '}(1_ _ND 'IN ):NG _F/v lOtS (IN O1 ( R_ NI[!( % (N AVISO: E r J(} OP 8LRN V: ](} ER 0 JE'_ADC ':_, D£ EN(}_NI}I}O BOtJQ J E D' £L -U'_AGE 8LJL SUPE ER ] G\ S_,, ' ]NT NC TR%S OERECI i() QqT ] NTE_ R IA_U_ AL OI R/[ RO ET LI R4 }E%F J IO{;ETER SU©E I!iLJR [ N( _ I AN[ LN EL E LO _; D D