Operator's Manual ® SUN SHADE Model No. 486.24227 STOP DO NOT RETURN TO STORE For Missing Parts or Assembly Questions Call 1-866-576-8388 CAUTION: Before using this product, read this manual and follow all Safety Rules and Operating Instructions. Sears, Roebuck and Co., Hoffman Estates, IL 60179 U.S.A. www.sears.com/craftsman PRINTED IN U.S.A. FORM NO. 49950 (REV.
TABLE OF CONTENTS SAFETY........................................................................... 2 WARRANTY.................................................................... 2 CARTON CONTENTS..................................................... 3 HARDWARE CHART....................................................... 4 BEFORE YOU BEGIN..................................................... 5 ASSEMBLY INSTRUCTIONS FOR TRACTORS WITH SINGLE SUSPENSION BRACKET.......................
CARTON CONTENTS 3 24 25 1 21 2 18 7 20 4 19 5 6 26 REF. NO. PART NO. 1 2 3 4 5 6 7 49242 25014 25013 25012 25015 48660 25793 QTY. DESCRIPTION 1 2 2 1 3 1 1 Base Top Tube Upright Tube Top Tube U-Tube Support Rod Vinyl Canopy Base Bracket Call 1-866-576-8388 for missing parts or assembly help DO NOT RETURN TO STORE REF. NO. PART NO. QTY.
HARDWARE CHART SHOWN FULL SIZE NOT SHOWN FULL SIZE 9 12 16 15 13 17 22 10 8 11 14 23 REF. NO. PART NO. 8 9 10 11 12 13 14 43720 46594 43081 43648 47189 48661 43063 QTY. DESCRIPTION 2 4 4 4 5 4 2 Plastic Knob Carriage Bolt, 5/16-18 x 2-3/4" Flat Washer, 5/16" Hex Bolt, 1/4-20 x 1-1/2" Nylock Nut, 1/4-20 Adhesive Pad Hex Bolt, 5/16-18 x 1" REF. NO. PART NO. QTY.
BEFORE YOU BEGIN TOOLS YOU WILL NEED FOR ASSEMBLY (2) (2) (1) 7/16" Wrenches 1/2" Wrench 1/2" or 9/16" Socket Wrench DETERMINE IF THERE IS A SINGLE OR DUAL MOWER DECK SUSPENSION BRACKET(S) UNDER THE FRONT OF YOUR TRACTOR Look under the front of your tractor. If there is a single mower deck suspension bracket located underneath the middle of the front axle as shown in figure 1A, continue on to page 6.
ASSEMBLY INSTRUCTIONS FOR TRACTORS WITH SINGLE MOWER DECK SUSPENSION BRACKET NOTE: Right hand (RH) and left hand (LH) are determined from the operator's position while seated on the tractor. 5/16" NYLOCK NUT THIS HOLE IS HIGHER STEP 1: (Figure 2) Place the base bracket on a flat surface. Identify the highest hole on each side of the bracket. STEP 2: (Figure 2) Attach the base bracket as shown to the first and second holes from the end of the flattened base leg tube. Make only finger tight.
ASSEMBLY INSTRUCTIONS FOR TRACTORS WITH SINGLE MOWER DECK SUSPENSION BRACKET STEP 6: (Figure 6) Insert the ends of the base leg tubes into the upper base tube. UPPER BASE TUBE BASE TUBE LEGS STEP 7: (Figure 7) Raise the tractor seat and remove the seat springs and the four bolts from the rear fender using a 1/2" socket. STEP 8: If the seat springs were mounted to the rear holes go to step 9. If the seat springs were mounted to the front holes go to step 10.
ASSEMBLY INSTRUCTIONS FOR TRACTORS WITH DUAL MOWER DECK SUSPENSION BRACKETS STEP 1: (Figure 8) Identify and position the right base bracket as shown in figure 6. Attach the right base bracket to the front holes of a round base leg tube. Make only finger tight. Repeat for the left base bracket.
CANOPY INSTALLATION STEP 1: (Figure 12) UPRIGHT TUBES Assemble the upright tubes to the base assembly. NOTE: If holes are difficult to align, loosen bolts attaching base tubes to mounting bracket(s). If hole alignment is still difficult, loosen bolts attaching mounting bracket to rear fender. Retighten all bolts when finished. PLASTIC KNOB 5/16" x 2" CARRIAGE BOLT 5/16" FLAT WASHER FIGURE 12 STEP 2: (Figure 13) Assemble the top tubes to the upright tubes. Do not tighten yet.
OPERATION Read this owner's manual and safety rules before operating your tractor with the sun shade. CAUTION: This sun shade does not provide protection against exhaust fumes, collision, rollover or other accidents. CAUTION: Watch out for low tree limbs and other overhead objects which may interfere with the sun shade. Check the area of operation thoroughly before using the tractor with the sun shade. The added height of the sun shade and a reduced field of vision require extra caution during operation.
REPAIR PARTS FOR MODEL 71-24227 SUN SHADE 6 11 3 5 3 4 12 12 15 11 23 21 12 17 17 24 15 14 26 2 2 10 12 22 20 7 17 13 19 17 1 2 3 4 5 6 7 8 9 10 11 12 13 14 49242 25014 25013 25012 25015 48660 25793 43720 46594 43081 43648 47189 48661 43063 15 16 25 PART NO. 1 9 9 REF. NO. 25 16 QTY.
Get it fixed, at your home or ours! Your Home For repair – in your home – of all major brand appliances, lawn and garden equipment, or heating and cooling systems, no matter who made it, no matter who sold it! For the replacement parts, accessories and owner’s manuals that you need to do-it-yourself. For Sears professional installation of home appliances and items like garage door openers and water heaters. 1-800-4-MY-HOME® (1-800-469-4663) Call anytime, day or night (U.S.A. and Canada) www.sears.