www.CookWithKenyon.
Contents IMPORTANT SAFETY INSTRUCTIONS 3 Product Specifications 5 Before Using the Grill Quick Start Tips Stuffed French Toast 6 7 Operation Control Knobs Power On Power On Indicator Power Level Power Level Graphic Temperature Setting Guide Grill Parts Lid Removal Handle Lock 9 9 9 9 9 10 11 12 12 Installation Unpacking the Grill Check Electrical Supply Requirements Countertop Preparation Drain Connection Final Preparations Prior to Use 13 13 14 15 15 Warranty 16 Please read & save these instruc
IMPORTANT SAFETY INSTRUCTIONS Read this section BEFORE operating the grill. The following information applies to all KENYON Grills. THIS GRILL, LIKE ALL APPLIANCES, HAS THE POTENTIAL TO CREATE SAFETY PROBLEMS THROUGH CARELESS AND IMPROPER USE. PLEASE OBSERVE ALL OF THE FOLLOWING SAFETY PRECAUTIONS. Read ALL instructions prior to using product. Do not let cord hang over edge of table or counter, or touch hot surfaces. CAUTION Do not touch hot surfaces. Use handles or knobs.
IMPORTANT SAFETY INSTRUCTIONS Do not place on or near a hot gas or electric burner, or in a heated oven. Do not use appliance for other than intended use. Extreme caution must be used when moving an appliance containing hot oil or other hot liquids. Do not replace or attempt to repair any part of the grill, unless otherwise noted in this manual. All other service is to be performed by a factory authorized technician.
Product Specifications Texan Grill with Knob Control BURNER DATA - Model B704XX (240V) VOLTAGE 240V AC AMPS 13 OUTPUT IN WATTS 3000 PRODUCT DIMENSIONS WIDTH 29 1/2” DEPTH 21” 753mm 533mm HEIGHT 5 1/2” (12 1/2” with lid) 139.7mm (317.5mm with lid) CUTOUT DIMENSIONS WIDTH 28” 711mm DEPTH 18 1/2” 470mm RADIUS 1/4” 6mm 7.25in 184mm A 20.10in 511mm 3.90in [99mm] 5.43in [138mm] WITH DRAIN FITTING 12.00in [304mm] DRAIN FITTING B 25.85in 657mm C 21.00in 533mm D 29.50in 749mm 28.
Before Using the Grill 6 1 Remove the cooking grates and drip trays from the grill. Wash the grill with warm soapy water using a non-abrasive cloth. USE ONLY HIGH TEMP PLASTIC UTENSILS WHEN GRILLING. Visit our web site to purchase a set of high quality stainless steel/high temp plastic grill utensils, www.cookwithkenyon.com.
Before Using the Grill 13 14 Wipe the stainless steel surfaces with a damp cloth to remove any residue from previous grilling sessions. Your Kenyon grill came with a sample bottle of stainless steel cleaner. Use this cleaner once a month to keep your grill looking like new.
Operation DO NOT USE WATER ON GREASE FIRES Smother fire or flame or use dry chemical or foam-type extinguisher. CLEAN GRILL AFTER EACH USE This appliance is equipped with removable, disposable drip trays. The drip trays MUST be removed and cleaned after each and EVERY use. Do not allow grease to accumulate between cooking. The drip trays and baffle tray MUST be used when cooking on the grill. Excessive grease may spill over into the interior of the grill and posing a fire hazard.
Operation Control Knobs The burners are controlled independently. To operate the left burner, use the top control knob. To operate the right burner use the bottom control knob. Power On To turn on the power you must push the knob down and rotate either clockwise (highest) or counter-clockwise (lowest) to activate the heat setting. POWER ON INDICATORS Power On Indicators When the left red LED is illuminated, the left burner is on. When the right red LED is illuminated, the right burner is on.
Operation Temperature Setting Guide TEMPERATURE SETTING #1 The following is meant to be a guideline. Individual results may vary depending on conditions. Factors such as wind, and outside temperatures, food temperature when placed on grill can affect cooking times. The grill is designed and engineered for optimal cooking performance with the lid down or closed.
Operation Grill Parts GRATES Heating Elements The heating elements are designed to pivot as shown to remove/replace the baffle tray and drip trays. They will stay in the up position. To put down apply slight downward pressure. CROSS BAR Baffle Tray The baffle tray supports the drip trays, heating elements and grates and must always be used when operating the grill. The cross bar must also be installed to support the elements and grates.
Operation Lid Removal Handle Lock The grill lids are removable for cleaning. To remove the lids, open it so the bearing is aligned with the notch in the lidstay. Pull the lidstay toward the center of the grill, over the bearing, releasing the lid from the lidstay mechanism. Then slide the quick release pin out of the middle hinge. The handle lock allows the user to lock both lids together for ease of opening and accessing the entire grilling surface.
Installation Unpacking the Grill 1 PARTS INCLUDED Carefully unpack the grill from its shipping container. Verify and identify the package contents. The following items should be included in the carton. If any components are missing or damaged, call KENYON immediately.
Operation Countertop Preparation D - 30 inches minimum clearance between the top of the cooking surface and the bottom of an unprotected wood or metal cabinet or 24 inch minimum clearance when the bottom of the wood or metal cabinet is protected by not less than 1/4-inch-thick flame retardant millboard covered with not less than No. 28 MSG sheet steel, 0.015-inch-think stainless steel, 0.024-inch-thick aluminum or 0.020-inch-thickcopper.
Operation Plumber’s Putty is a very inexpensive material that is sold in small plastic tubs. It is always shaped by hand before it is applied. Follow the basic instructions on the container of the Plumber’s Putty. If your countertop is made of granite, marble, quartz, sandstone or Corian use a stain-free Plumber’s Putty to prevent staining of the countertop. WARNING! To eliminate the risk of burns by reaching over heated surface units, cabinet storage space located above surface units should be avoided.
KENYON Statement of Warranty Kenyon International, Inc (the “Company”) warrants its products in normal usage to be free of defects in materials and workmanship subject to the conditions and limitations below. Any part, which proves to be defective in normal usage during the warranty period will be repaired or replaced by the Company. In order for product to be covered under this warranty it must be returned to the Company for evaluation. Please contact kenyonservice@cookwithkenyon.
