Aqua Smarte Plus™ Mineral Dispensing System Model 7700 For Pools up to 25,000 Gallons WAT ER MANAGEMENT SYSTEM with Aqua Smarte Plus Mineral System* System Includes the Aqua Smarte Plus Mineral Activator™ Patented Mineral Disinfectant Customer Service 800-222-0169 www.kingtechnology.
TABLE OF CONTENTS Aqua Smarte Plus Introduction 3 Swimming Pool Tips 4 Start-up and Operation 5-6 Replacing Aqua Smarte Plus Mineral Activator 7 Using Aqua Smarte Plus Shine, Optimize, MizerMax Pac 8 Using Aqua Smarte Plus CANNONBALL! 9 Troubleshooting 10 Parts List 11 Replacing Control Dial O-Rings 12 Replacing Cap O-Rings and Knobs 12 Winterizing 13 Above Ground Filter Installation 14 Above Ground Base Installation 15 Warranty 16 For information on King Technology’s entire prod
Aqua Smarte Plus™ Part 1 Aqua Smarte Plus Docking Station™ Welcome to easier pool care courtesy of Aqua Smarte Plus. With Aqua Smarte Plus, your pool water will look and feel better without a lot of work or a lot of chlorine. This system+ controls bacteria using a combination of minerals and reduced chlorine levels – Chlorine lasts 2X longer with Aqua Smarte Plus Mineral System.
Swimming Pool Tips Start-up and Yearly Maintenance 1. 3. Make sure the pool has adequate circulation. The pool water must completely circulate through the pump and filter at least 1 to 2 times per day. This usually requires 8 to 12 hours. Check with your dealer for the proper circulation time for your pool. If your fill water is high in metals, use a sequestering agent or metal out product at start-up only before using the Aqua Smarte Plus Mineral Activator.
Start-up and Operation - Aqua Smarte Plus Mineral Activator now with 25% greater clarifying power for easier start up. Add a stabilizer or conditioner to the pool at the beginning of the season if the stabilizer level is below 20 ppm. This will prevent chlorine burn off. Follow manufacturer’s directions carefully. 5. For a 90-day algae protection guarantee, insert Aqua Smarte Plus CANNONBALL! into the Aqua Smarte Plus Mineral Activator in the Aqua Smarte Plus Docking Station. (See page 9 for directions.
Start-up and Operation control dial by matching up the parameters of your pool on the chart below. THIS IS A STARTING POINT ONLY and may 7. Set need to be adjusted to fit your individual pool needs. See #8 below for directions. IMPORTANT: Pump run times less than 8 hours could result in under chlorination due to inadequate flow through the System.
Replacing an Aqua Smarte Plus Mineral Activator™ (Aqua Smarte Plus Mineral Activator MUST be Replaced Every Season) 1. 4. Turn off pump and turn dial to Setting 0. This reduces the flow of water into the unit when the cap is open. Check the top of the box and back label of product to make sure you have the correct Aqua Smarte Plus Mineral Activator to fit your Aqua Smarte Plus Docking Station.
Replacing Aqua Smarte Plus Shine™, Aqua Smarte Plus Optimize™ or Aqua Smarte Plus MizerMax™ Pac WARNING Avoid sparks, open flame or smoking when handling Aqua Smarte Plus Shine, Aqua Smarte Plus Optimize or Aqua Smarte MizerMax Pac. Aqua Smarte Plus Shine 1. Aqua Smarte Plus Optimize Aqua Smarte Plus MizerMax Pac Aqua Smarte Plus Shine is a one time start-up product used to rid the water of all contaminants.
Using Aqua Smarte Plus CANNONBALL! for an 90-Day Algae Protection Guarantee If you are not using a Aqua Smarte Plus CANNONBALL! proceed to inserting Aqua Smarte Plus MizerMax Pac. See Aqua Smarte Plus CANNONBALL! product labeling for complete directions for use (EPA Reg. No. 53735-9). For a preventive dose add: ! *NOTE: Wait 24 hours after shocking before using this product.
Troubleshooting For more in-depth troubleshooting, go to www.kingtechnology.com Problem 1. What do I do if the water looks cloudy? Remedy 1. Make sure your filtration system is working properly (i.e. clean filter, skimmer and pump basket). 2. Make sure circulation time is adequate – increase pump time if not. 3. Make sure the pool is properly balanced (see page 4). 5. Make sure pool has a free chlorine reading of 0.5 to 1.0 ppm. 4. Shock the water to eliminate build up of any organic matter. 6.
Parts List Model 7700 Included with Aqua Smarte Plus Docking Station 7700 REF. # DESCRIPTION QTY. INCLUDED Replacement parts for Aqua Smarte Plus Docking Station 7700 REF. # PART NO.
Aqua Smarte Plus Docking Station Maintenance Replacing the Control Dial O-Rings Replacing Cap O-Ring Hold cap in front of you upside down with the o-ring groove facing up. Place one end of o-ring into cap groove at the point closest to you. Hold o-ring down with the thumb and index finger of one hand. Take hold of the far end of the o-ring with the thumb and index finger of the other hand. Roll o-ring slightly back towards you as you stretch the o-ring into the remainder of the cap groove.
Winterizing 1. 4. If Aqua Smarte Plus MizerMax Pac still contains chlorine, wrap in plastic bag and store in shed or cool well-ventilated location away from children, pets, cars, motorcycles or anything metal that can rust, pit, etc. Make sure Aqua Smarte Plus MizerMax Pac is away from open flame. 5. Remove the Aqua Smarte Plus Mineral Activator and discard in trash. Even if you hear spent minerals inside, it is no longer effective. Turn pump off and turn dial to Setting 0. 2. Remove cap.
TOOLS NEEDED Above Ground, Filter Installation Screwdriver Pipe Wrench INCLUDED WITH Aqua Smarte Plus Docking Station pipe thread tape or 1. Apply sealant to each threaded one end of nipple 3. 2. Screw into the filter return. end of nipple. Tighten turning 1 to 2 revolutions with wrench. DO NOT OVER TIGHTEN. Pipe Thread Tape or Sealant One Hose Adapter 1 1/2” X 1 1/2” X 1 1/4” Screw adapter into the other side of the Aqua Smarte Plus Docking Station. Hand tighten.
TOOLS NEEDED Above Ground, Base Installation Screwdriver WARNING Pipe Wrench before the heater. that is installed with Aqua Smarte Plus must be installed after Aqua Smarte Plus (never before) on the return line to the pool. Materials Needed Pipe Thread Tape or Sealant The Aqua Smarte Plus Docking Station should always be installed between the filter and pool (or between heater and pool if applicable).
Aqua Smarte Plus™ Docking Station™ Two-Year Limited Warranty King Technology, Inc. warrants to the original purchaser this unit will be free from any defects in workmanship and/or material, for a period of two (2) years from the date of original purchase. This warranty covers body, cap and control dial, but specifically excludes o-rings. King Technology at its option may replace any defective parts or the entire unit without charge after it is determined what is needed to correct any deficiency.
