Product Manual

ManualsBrandsKohler Engines ManualsEnginesKohler Command Pro OHV Horizontal Engine — 999CC, 35 HP, 25 Amp

62 590 15 Rev. --

KohlerEngines.com

CV940-CV1000

Owner's Manual

CH940-CH1000

ESS

FRC

IMPORTANT: Read all safety precautions and instructions carefully before

operating equipment. Refer to operating instruction of

equipment that this engine powers.

Ensure engine is stopped and level before performing any

maintenance or service.

Warranty coverage as outlined in the warranty card and on

KohlerEngines.com. Please review carefully as it provides you

speciﬁ c rights and obligations.

To maintain compliance with applicable emission regulations,

exhaust system backpressure may not exceed limits which can

be found on KohlerEngines.com. Search by Model No., select

Summary of content (8 pages)

PAGE 1
EN ESS FRC CH940-CH1000 CV940-CV1000 Owner's Manual IMPORTANT: Read all safety precautions and instructions carefully before operating equipment. Refer to operating instruction of equipment that this engine powers. Ensure engine is stopped and level before performing any maintenance or service. Warranty coverage as outlined in the warranty card and on KohlerEngines.com. Please review carefully as it provides you specific rights and obligations.
PAGE 2
Safety Precautions WARNING: A hazard that could result in death, serious injury, or substantial property damage. CAUTION: A hazard that could result in minor personal injury or property damage. NOTE: is used to notify people of important installation, operation, or maintenance information. WARNING Explosive Fuel can cause fires and severe burns. Do not fill fuel tank while engine is hot or running. Gasoline is extremely flammable and its vapors can explode if ignited.
PAGE 3
EN F K A J E I B B H A G D C S T U N P O L V Q M S R A Low-Profile Air Cleaner B Cylinder Shroud C Debris Screen D Oil Drain Plug E Oil Fill F Dipstick G Air Cleaner Base H Paper Element I Precleaner J Air Cleaner Cover K Air Cleaner Knob L End Cap M Air Cleaner Housing N Element O Inner Element P Retaining Clip Q Inlet Screen R Ejector Area S Heavy-Duty Air Cleaner T Oil Fill/Dipstick U Oil Filter V Filter Minder Pre-Start Checklist 1.
PAGE 4
Starting Cold Weather Starting Hints 1. Use proper oil for temperature expected. 2. Disengage all possible external loads. WARNING Carbon Monoxide can cause severe nausea, fainting or death. Avoid inhaling exhaust fumes. Engine exhaust gases contain poisonous carbon monoxide. Carbon monoxide is odorless, colorless, and can cause death if inhaled. 3. Use fresh winter grade fuel. Winter grade fuel has higher volatility to improve starting. Stopping 1.
PAGE 5
EN Maintenance Instructions WARNING Before working on engine or equipment, disable engine as follows: 1) Disconnect spark plug lead(s). 2) Disconnect negative (–) battery cable from battery. Accidental Starts can cause severe injury or death. Disconnect and ground spark plug lead(s) before servicing.
PAGE 6
3. If oil is low on indicator, add oil up to top of indicator mark. Fuel Recommendations 4. Reinstall and secure dipstick. WARNING Change Oil and Filter Change oil while engine is warm. Explosive Fuel can cause fires and severe burns. 1. Clean area around oil fill cap/dipstick and drain plug. Remove drain plug and oil fill cap/ dipstick. Allow oil to drain completely. Do not fill fuel tank while engine is hot or running. 2. Clean area around oil filter; remove filter; wipe off mounting surface.
PAGE 7
Spark Plugs EN Breather Tube Ensure both ends of breather tube are properly connected. CAUTION Electrical Shock can cause injury. Do not touch wires while engine is running. Clean out spark plug recess. Remove plug and replace. 1. Check gap using wire feeler gauge. Adjust gap, see specification table for adjustment. 2. Install plug into cylinder head. 3. Torque plug to 20 ft. lb. (27 N·m). Oil Cooler NOTE: Oil cooler is mounted under cylinder shroud.
PAGE 8
Troubleshooting Do not attempt to service or replace major engine components, or any items that require special timing or adjustment procedures. This work should be performed by a Kohler authorized dealer.