Installation Guide

Raise the glass.
Lower the glass.
Bottom Track
Guide
Center of the Bottom Track
Guide
Bottom Track
Doors
Bottom Track
Guide
Bottom Track
Guide
Self-Tapping Screws
Spacers
Door Panel
Towel Bar
5/64"
1/4"-20 Screw
x2
Outside of the Shower
Bath Interior
Lift the inside panel onto the inside track. The
label faces the outside of the shower.
Lift the outside panel onto the outside track. The
label faces the outside of the shower.
If either panel needs adjustment, remove the
door and position the rollers in new holes to
raise or lower the glass.
Measure and mark the center of the bottom
track. Center the guide on the bottom track and
align the door panels with the guide.
On the inside of the shower, hold the guide
against the bottom track and slide the doors
from wall to wall. If the doors bind, refer to step
13 for the adjustment procedure.
Hold the guide in place and secure with the two
self-tapping screws. Do not overtighten!
Assemble both towel bars with a spacer on each
side of the door panel. Use a hex wrench to
tighten the screws. Do not overtighten!
Outside the shower, use silicone sealant to seal
along the entire length of the wall jambs and the
bottom track.
Inside the shower, use silicone sealant to seal
along the entire length of the wall jambs and
where the wall jambs meet the bottom track.
Troubleshooting
Symptom: Alignment Recommended Action
1. The top of the door panel is tilted away from
the wall.
A. Remove the door panel from the top track and lower the roller that is closest to the wall. See step 13.
2. The bottom of the door panel is tilted away
from the wall.
A. Remove the door panel from the top track and raise the roller that is closest to the wall. See step 13.
3. The door panel does not touch the bumper. A. Determine whether the door panel top or bottom is closer to the wall, and then adjust the roller closest to the wall.
4. The bottom track is miscut or skewed. A. The notched wall jamb fits over the bottom track to cover any miscut or skewed cuts. Seal as directed to ensure
proper watertight seal. See step 19.
Symptom: Water Leaks Recommended Action
1. Water leaks between panels. A. When showering, make sure the inside panel is against the showerhead wall.
2. Water leaks between the wall jamb and the
door panel.
A. Adjust the door panel to line up with the wall jamb.
3. Water leaks under the bottom track. A. Check for proper silicone sealant application. See steps 18 and 19. Apply more silicone sealant in the leak location.
Symptom: Operation (open/close) Recommended Action
1. The outside panel is difficult to move. A. Ensure a gap exists between the bottom track and the door panel. If no gap exists, lower the rollers to the next hole.
B. Ensure the inside center guide is properly secured with the self-tapping screws. See step 16.
C. Clean any debris in the top track groove.
2. The inside panel is difficult to move.
A. Ensure a gap exists between the bottom track and the door panel. If no gap exists, lower the rollers to the next
hole.
B. Ensure the inside center guide is properly secured with the self-tapping screws. See step 16.
C. Clean any debris in the top track groove.
21241256-2-A ©2014 Kohler Co.
11 12
17
13
1816
14
19
15
Warranty
ONE-YEAR LIMITED WARRANTY
KOHLER plumbing products are warranted to be free of defects in material and workmanship for one year from
date of installation.
Kohler Co. will, at its election, repair, replace or make appropriate adjustment where Kohler Co. inspection discloses
any such defects occurring in normal usage within one (1) year after installation. Kohler Co. is not responsible for
removal or installation costs. Use of in-tank toilet cleaners will void the warranty.
To obtain warranty service contact Kohler Co. either through your Dealer, Plumbing Contractor, Home Center or
E-tailer, or by writing Kohler Co., Attn.: Customer Care Center, 444 Highland Drive, Kohler, WI 53044, USA, or
by calling 1-800-4-KOHLER (1-800-456-4537) from within the USA and Canada, and 001-800-456-4537 from within
Mexico, or visit www.kohler.com within the USA, www.ca.kohler.com from within Canada, or www.mx.kohler.
com in Mexico.
IMPLIED WARRANTIES INCLUDING THAT OF MERCHANTABILITY
AND FITNESS FOR A PARTICULAR PURPOSE ARE EXPRESSLY LIMITED IN DURATION
TO THE DURATION OF THIS WARRANTY. KOHLER CO. AND/OR SELLER DISCLAIM
ANY LIABILITY FOR SPECIAL, INCIDENTAL OR CONSEQUENTIAL DAMAGES. Some states/provinces do
not allow limitations on how long an implied warranty lasts, or the exclusion or limitation of special, incidental or
consequential damages, so these limitations and exclusions may not apply to you. This warranty gives you specific
legal rights. You may also have other rights which vary from state/province to state/province.
This is Kohler Co.’s exclusive written warranty..