Operation Manual

BX25, RCK54(P)-23BX, RCK60B-23BX, LA240, BT601, WSM
G GENERAL
Checking Battery Condition (Continued)
• Battery
for storage
1. When storing the tractor for a long period, remove the battery
from tractor, adjust the electrolyte to the proper level and store in
a dry place out
of direct sunlight.
2. The battery self-discharges while it is stored.
Recharge it once every three months
in hot seasons and once
every six months
in cold seasons.
3. (For non-accessible maintenance-free type batteries.)
Maintenance-free, non-accessible batteries are designed to
eliminate the need to add water. Yet the volume
of electrolyte
above plates may eventually become depleted due to abnormal
conditions such as high heat
or improper regulator setting. Use
a voltmeter to check the state
of change. (See reference chart
below to determine
if charging is necessary.)
Battery voltage
Reference state
of charge
12.6
100 % (Full charge)
12.4
75%
12.2
50%
12.0
25%
11.8
0%
W1033625
Cleaning Air Cleaner Element
A CAUTION
• Be sure
to stop the engine and remove the key before
cleaning
air cleaner element.
1. Remove the air cleaner cover (2) and the element (1).
- Undo the hook.
- Turn the cover clockwise and detach it.
2. Clean the element:
- When dry dust adheres to the element, blow compressed air
from the inside, turning the element. Pressure
of compressed
air must be under 205 kPa
(2.1 kgf/cm
2
,
30 psi).
- When carbon or oil adheres to the element, soak the element
in detergent for 15 minutes then wash it several times in water,
rinse with clean water and dry it naturally. After element is fully
dried, inspect inside
of the element with a light and check if it is
damaged or not. (referring to the instructions on the label
attached to the case.)
3. Replace air cleaner element:
Once yearly
or after every sixth cleaning, whichever comes first.
• NOTE
• Check
to see if the evacuator valve is blocked with dust.
• IMPORTANT
• The
air cleaner uses a dry element, never apply oil.
• Do
not run the engine with filter element removed,
•
Align the arrow marks when reinstalling the cover. If the
cover is improperly fitted, dust passes by the baffle and
directly adheres to the element.
• Evacuator Valve
Open the evacuator valve once a week under ordinary conditions
or daily when used
in a dusty place to get rid of large particles of dust
and dirt.
(1) Element
(3) Evacuator Valve
(2) Cover
W1017166
G-18