OPERATOR'S MANUAL
Table Of Contents
- OPS - Excavator K008-3 (RA028-8222-2)
- List of Abbreviations
- General Symbols
- Foreword
- Safety First
- Contents Page
- Safe Operation
- Dealer Service
- Technical Data
- Description of Machine Parts
- Instrument Panel and Control Elements
- Before Start
- Operation of the Engine
- Excavator Operation
- Control Observations During Operation
- Running In of the New Excavator
- Starting
- Controls for Attachments
- Operation of the Boom
- Operation of the Arm
- Operation of Bucket
- Swivel (Unit Swing) Operation
- Boom Swing Operation
- Boom Swing Pedal
- Operation of Track Width Change and Dozer
- Driving
- Turns
- Up and Downhill Travelling
- Parking on a Slope
- Drive Speed Pedal
- Service Port Operation
- Important Information on Excavator Operation
- Operating Foldable ROPS
- Transporting the Excavator on a Truck
- Lifting of the Excavator
- Maintenance
- Regular Checks and Maintenance Work
- Other Adjustments and Replacements
- Troubleshooting
- Operation in Cold Weather Conditions
- Long Storage
- Recommended Oils
- Main Dimensions
- Lifting Capacity
41REGULAR CHECKS AND MAINTENANCE WORK
REGULAR CHECKS AND MAINTENANCE WORK
EVERY 50 SERVICE HOURS
BDraining the Water from the Fuel
Tank
Loosen the drain plug at the bottom of the fuel
tank to let sediments, impurities and water out of
the tank. Finally tighten up the plug.
BDraining of the Fuel Filter
To avoid personal injury:
A Before draining the fuel filter, be sure
to stop the engine.
A Do not smoke during inspection.
Check if water or impurities are in the fuel filter
cup, if so clean inside of cup with light oil. For
details see the chapter on "Fuel Filter Change".
BBattery Service
To avoid personal injury:
A Batteries contain sulphuric acid
which can cause severe burns. Avoid
all contact with skin, eyes or clothing.
Antidote - External: Rinse with plenty
of water. Internal: Drink large
quantities of water or milk.
Call a physician immediately. Eyes:
Rinse with plenty of water for 15
minutes and get prompt medical
attention. Keep batteries out of the
reach of children.
A Before inspection or dismounting the
battery, be sure to turn of the engine
and turn the starter switch to the
"OFF" position.
A When removing the battery, always
disconnect the negative ground cable
first. The reverse when installing a
battery, always connect the ground
cable last. This prevents a possible
explosion caused by sparks.
A Always wear eye protection when
working with the battery.
1. Check the battery fluid level and add distilled
water if necessary.
2. Should battery fluid be spilt, fill with sulphuric
acid solution of the same concentration.
3. Clean the battery caps (ventilation holes)
also.
(1) Drain plug
(1) Fuel filter cup