Install and Operating Manual Instruction Manual

Mini-Therm JV
Page 21
Figure 14A. Wiring Diagram, JVH
(220V OPT) TRANSFORMER 24V 115V
R
CURVE
WWSD
DHW CALL HEAT CALL
POWER
12 34
BOILER SENSOR
120 VAC L
SWITCHED 120 VAC TO PUMP
0.4
2.0
3.6
OFF ON
FIELD WIRING
INDUCER FAN
BK
BL
BOX
R
R
PILOT
HSI
BOILER SENSOR
HI
LIMIT
FAN
PROVING
FLAME
ROLL
OUT
DIVIDER
W
BK
(Fourni Lors De Boiler Pump 5A Max (Field Supplied) Pompe À Chaleur L'Installation)
R
W
FUSE
O BK
24
3 1
BR
BL
INDUCED DRAFT
MODEL JVH
Y
GAS VALVE/ CONTROLLER SV9501, SV9601
FAN
Y
R
HOT CHAUD 115/60HZ (220V50Hz OPTIONAL) POWER SUPPLY NEUTRAL NEUTRE GROUNDING CONDUCTOR CABLE DE MISE A LA TERRE
W
Y
P
G-VERT
G-GREEN
P-MAUVE
P-PURPLE BK-BLACK
BK-NOIR
W-WHITE
W-BLANC
R-RED
R-ROUGE
Y-YELLOW
Y-JAUNE
BL-BLUE
BL-BLEU
BR-BROWN
BR-BRUN
O-ORANGE
O-ORANGE
THE BOILER WILL NOT OPERATE
WITHOUT THE AUTOMATIC VENT
DAMPER. THE VENT DAMPER WIRE HARNESS MUST BE INSERTED INTO THE VENT DAMPER RECEPTACLE. IN CANADA:
SOME UNITS ARE
SUPPLIED WITH VENT DAMPER
JUMPER PLUG. DO NOT REMOVE
JUMPER UNLESS VENT DAMPER
IS TO BE INSTALLED.
LA CHAUDIÈRE NE FONCTIONNERA PAS SANS LE VOLET MOTORISÉ AUTOMATIQUE. LE F AISCEAU DE CÂBLES DU VOLET MOTORISÉ DOIT ÊTRE INSÉRÉ DANS LA PRISE DU VOLET MOTORISÉ AU CANADA: CERTAINS APPAREILS SONT MUNIS D’UN CAVAL IER DE
VOLET MOTORISÉ. NE PAS RETIR ER LE CAVALLIER À MOINS Q UE LE
VOLET MOTORISÉ NE SOIT INST ALLÉ
NOTE: 1. 4-PIN MOLEX AS VIEWED FROM REAR OF BOARD.
INTENDED SIZE:
D
C
B
A
B
C
D
1
2
3
4
4
3
2
1
SOFTWARE
DWG. NO:
B
SHEET 1 OF 1
REV.
BY LAARS HEATING SYSTEMS CO.
PM 5-23-12
12-032N-01
A
PURPOSE EXCEPT AS SPECIFICALLY AUTHORIZED IN WRITING
MOUNTED 4-PIN MOLEX
CHECK
DRAFT
ECN
ENGR APPR
APPR
CHANGE:
REV.
REVISIONS
CJ 5-23-12
AE23446
ADDED NOTES AND UPDATED WIRES TO BOARD
HOT SURFACE IGN. NAT/LP
DISCLOSED TO OTHERS FOR MANUFACTURING OR ANY OTHER
WIRE DIAGRAM JVH
1/8"
TITLE:
FRACTIONS
REPRODUCED, TRANSFERRED TO OTHER DOCUMENTS, USED OR
1
.010 DECIMALS .XXX
.03DECIMALS .XX
.1
S
PM 9-20-11
N/A N/A
FINISH
MATERIAL:
TOLERANCES ARE:
DECIMALS .X
DIMENSIONS ARE IN INCHES.
UNLESS OTHERWISE SPECIFIED:
APPR
ENGR
DRAFT
APPROVALS
THIS DOCUMENT AND THE INFORMATION CONTAINED HEREIN ARE
PROPRIETARY TO LAARS HEATING SYSTEMS CO.AND SHALL NOT BE
ANGLES
DO NOT SCALE DRAWING.
THIRD ANGLE PROJECTION.
SCALE: NONE
SYS
COM
OUT
HEAT CALL
COM CALL
DHW CALL