Table of Contents All Purpose Seeder APS1548, APS1560, APS1572 & APS1586 APS1586 25982 24932 APS1548 313-354M Operator’s Manual ! Read the Operator’s manual entirely. When you see this symbol, the subsequent instructions and warnings are serious - follow without exception. Your life and the lives of others depend on it! © Copyright 2008 Printed 5/13/08 Cover photo may show optional equipment not supplied with standard unit.
Land Pride Table of Contents Table of Contents Important Safety Information . . . . . . . . . . .1 Section 3: Adjustments . . . . . . . . . . . . . .14 Safety at All Times . . . . . . . . . . . . . . . . . . . . . . . . . 1 Look For The Safety Alert Symbol . . . . . . . . . . . . . 1 Safety Labels . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 4 Front Roller Angle Adjustment . . . . . . . . . . . . . . . 14 Mud Scraper Adjustment (Optional) . . . . . . . . . . . 14 Front Mud Scrapers . . . .
Land Pride ▲ Table of Contents Important Safety Information Important Safety Information These are common practices that may or may not be applicable to the products described in this manual. Safety at All Times Look For The Safety Alert Symbol Thoroughly read and understand the instructions given in this manual before operation. Refer to the “Safety Label” section, read all instructions noted on them.
Table of Contents Land Pride Important Safety Information These are common practices that may or may not be applicable to the products described in this manual. 2 Use Safety Lights and Devices Transport Machinery Safely ▲ Slow moving tractors, selfpropelled equipment, and towed implements can create a hazard when driven on public roads. They are difficult to see, especially at night. ▲ Flashing warning lights and turn signals are recommended whenever driving on public roads.
Table of Contents Land Pride Important Safety Information These are common practices that may or may not be applicable to the products described in this manual. Prepare for Emergencies ▲ Be prepared if a fire starts. ▲ Keep a first aid kit and fire extinguisher handy. ▲ Keep emergency numbers for doctor, ambulance, hospital and fire department near phone. Wear Protective Equipment Avoid High Pressure Fluids Hazard ▲ Protective clothing and equipment should be worn.
Table of Contents Land Pride Important Safety Information Safety Labels Your All Purpose Seeder comes equipped with all safety labels in place. They were designed to help you safely operate your implement. Read and follow their directions. 1. 2. 3. Keep all safety labels clean and legible. Replace all damaged or missing labels. To order new labels go to your nearest Land Pride dealer or visit our dealer locator at landpride.com.
Land Pride Table of Contents Important Safety Information 24934 838-111C DANGER: Keep away, Moving Parts 818-543C 24938 DANGER: Guard Missing (Beneath Guard) 24934 KEEP AWAY 818-254C DANGER: Rotating Roller Hazard 25512 5/13/08 APS1548, APS1560, APS1572 & APS1586 All Purpose Seeder 313-354M 5
Table of Contents Land Pride Introduction Introduction Land Pride welcomes you to the growing family of new product owners. This All Purpose Seeder has been designed with care and built by skilled workers using quality materials. Proper assembly, maintenance and safe operating practices will help you get years of satisfactory use from the machine.
Table of Contents Land Pride Section 1: Assembly & Set-up Section 1: Assembly & Set-up Tractor Requirements Dealer Preparations Tractor horse power and hitch category should be within the range noted below. Tractors outside the horsepower range must not be used. This All Purpose Seeder has been assembled at the factory. Some preparation will be necessary to attach the seeder to the customer’s tractor. Make sure the intended tractor conforms to “Tractor Requirements”.
Table of Contents Land Pride Section 1: Assembly & Set-up Mud Scraper Installation (Optional) Optional mud scrapers are available from your local Land Pride dealer. A scraper bundle consists of one rear roller scraper and two front roller scrapers and are identified by the rear roller type and seeder planting width. Land Pride Mud Scrapers Part No. Part Description APS1548 313-431A 313-432A SPIKE SCRAPER BUNDLE . . . S/N 567003+ PACKER SCRAPER BUNDLE .
Table of Contents Land Pride Section 1: Assembly & Set-up 24977 Attach a vice grip tightly to the spring rod at this location. Spring Rod 5 Spring Rod Guide Bar Special Instructions For Packer Roller 6 Refer to Figure 1-6: 1 3 2 4 7. Reinstall roller arm assembly (#1) to the seeder side plate with existing 3/4"-10 hex flange lock nut (#3), 5/8"-11 GR5 hex head cap screws (#4) and lock washers (#5). Torque all hardware including bearing set collar screw (#2). 8. Remove vice grip from spring rod.
Table of Contents Land Pride Section 1: Assembly & Set-up Special Instructions For Spike Roller Refer to Figure 1-7: NOTE: Do not tighten bolts (#11 & #18) until after adjustments have been made. See “Mud Scraper Adjustment (Optional)” on page 14 for instructions. 1. Attach spike scrapers (#17) to scraper hanger (#9) with 3/8"-16 x 1 1/4" GR5 round head square neck bolts (#18) and hex flange lock nuts (#19). Draw nuts up snug, do not tighten until after completing adjustments in Section 3. 2.
Table of Contents Land Pride Section 2: Operating Instructions Section 2: Operating Instructions Operating Check List Hazard control and accident prevention are dependent upon the awareness, concern, prudence and proper training involved in the operation, transport, maintenance and storage of the seeder. Therefore, it is absolutely essential that no one operates the All Purpose Seeder without first having read, fully understood and become totally familiar with the Operator’s Manual.
Table of Contents Land Pride Section 2: Operating Instructions 4. The bag opener (#4) (sharp point on top of the baffle plate) can be used to tear open the seed bags. 5. Maker certain the seed box is filled uniformly to insure one side dose not run out of product ahead of the other side. 6. Close lid by pulling on the handle of the over center latch arms (#2) with one hand while holding the lid up with the other hand. Lower lid gently while keeping hands and fingers clear. 7.
Land Pride Table of Contents Section 2: Operating Instructions 4. Make sure each seed cup door handle is set at the same height across the seeder. The highest position is usually used for grass seeds. 5. Be sure all bolts and nuts are tight. 6. Be certain all guards are in place and secure. 7. Clear area to be seeded of rocks, branches and other foreign objects. Mark any potential hazards. 8. Tall grass and weeds should be mowed before seeding. 9. Never allow anyone to ride on the seeder. 10.
Table of Contents Land Pride Section 3: Adjustments Section 3: Adjustments Front Roller Angle Adjustment Mud Scraper Adjustment (Optional) Refer to Figure 3-1: Refer to “Torque Values Chart For Common Bolt Size” on page 28 when tightening hardware. NOTE: Gang slide (#1) is shown in its furthest back position. In this position, both bent pins (#6) are in front of the gang slide as shown. In all other positions, one bent pin is in back of the gang slide and the other is in front of the gang slide. 1.
Land Pride Table of Contents Section 3: Adjustments Drive Chain Engagement Refer to Figure 3-3: Soil that is very hard or with a lot of unwanted vegetation may require several passes with the front rollers set at a very aggressive angle before planting begins. Disengage drive chain from the rear roller while making these passes and engage drive chain when ready to start planting seed. 1. Lower seeder frame onto blocks supporting rear roller just above ground level to allow roller to turn freely. 2.
Table of Contents Land Pride Section 3: Adjustments Speed Change Sprocket The All Purpose Seeder is designed with two drive speeds to accommodate different seed sizes and seed dispersal rates. The two drive speeds are high range (fast speed) and low range (slow speed). High Range Set-up Refer to Figure 3-4: 1. Loosen 3/8" flange lock nut(#1) and drive tension sprocket (#2). Remove drive chain (#3) from speed change sprocket (#6). 2. Remove 5/8” nut (#4) and 5/8” flat washer (#5). 3.
Table of Contents Land Pride Section 3: Adjustments Seeding Adjustments 1. Use seed rate charts beginning on page 18 to determine correct seeding rate. Make adjustments as follows: a. Decide whether your drive needs to be set-up for low range or high range. If necessary, change the speed change sprocket to accommodate the correct speed range. See “Speed Change Sprocket” on page 16. Refer to Figure 3-6: IMPORTANT: Use seed rate charts as a guide.
Table of Contents Land Pride Section 3: Adjustments Seed Rate Charts (English) (Pounds per 1000 square foot and Pounds per acre) Cup Setting 0 5 10 Alfalfa (Pounds per Acre) 15 20 25 30 35 40 45 50 55 60 65 70 75 80 85 90 95 100 High Range Low Range 198 63 269 85 341 108 412 131 485 154 555 176 626 198 699 221 769 244 842 267 913 289 985 312 1056 335 1129 358 1199 380 1270 402 1343 425 1413 448 0 0 54 17 125 40 Alfalfa (Pounds per 1000 Square Feet) High Range Lo
Table of Contents Land Pride Section 3: Adjustments Cup Setting 0 5 10 15 20 Lovegrass - Sand (Pounds per Acre) 25 30 35 40 45 50 55 60 65 70 75 80 85 90 95 100 High Range Low Range 293 93 343 109 394 125 445 141 496 157 547 173 598 189 649 206 700 222 751 238 802 254 852 270 925 286 977 302 1029 319 1081 335 0 0 89 28 140 44 191 61 242 77 Lovegrass - Sand (Pounds per 1000 Square Feet) High Range Low Range 0.0 0.0 2 0.6 3.2 1 4.4 1.4 5.6 1.8 6.7 2.1 7.9 2.
Table of Contents Land Pride Section 3: Adjustments Seed Rate Charts (Metric) (Kilograms per 1000 square meter and Kilograms per hectare) Cup Setting 0 5 10 15 Alfalfa (Kilograms per Hectare) 20 25 30 35 40 45 50 55 60 65 70 75 80 85 90 95 100 High Range Low Range 301 95 382 121 461 147 543 172 621 197 700 222 782 247 860 273 942 299 1021 323 1102 349 1181 375 1263 41 1341 425 1421 450 1503 475 1581 501 0 0 60 19 140 45 222 70 Alfalfa (Kilograms per 1000 Square M
Table of Contents Land Pride Section 3: Adjustments Cup Setting 0 5 10 15 20 25 Lovegrass - Sand (Kilograms per Hectare) 30 35 40 45 50 55 60 65 70 75 80 85 90 95 100 High Range Low Range 384 122 441 140 498 158 555 176 612 194 669 211 726 230 783 248 840 266 897 284 953 302 1035 320 1093 338 151 357 1209 375 0 0 100 31 157 49 214 68 271 86 328 104 Lovegrass - Sand (Kilograms per 1000 Square Meters) High Range Low Range 0 0 10 3 16 5 21 7 27 9 33 10 39 12 44
Table of Contents Land Pride Section 4: Maintenance & Lubrication Section 4: Maintenance & Lubrication Maintenance Proper servicing and adjustment is the key to the long life of any implement. With careful and systematic inspection, you can avoid costly maintenance, time and repair. After using your All Purpose Seeder for several hours, check all bolts to be sure they are tight. Replace any worn, damaged or illegible safety labels by obtaining new labels from your Land Pride Dealer.
Table of Contents Land Pride Section 4: Maintenance & Lubrication Lubrication Points Lubrication Legend Multi-purpose spray lube Multi-purpose grease lube Multi-purpose oil lube 50 Intervals in hours at which lubrication is required 50 Hours Feed Cup Drive Sprocket Square Bore Type of Lubrication: Oil Quantity: Squirt a generous amount of oil on to the square feed cup shaft and move seed rate adjustment lever back and forth in order to get oil back into the square bore.
Table of Contents Land Pride Section 4: Maintenance & Lubrication 25 Hours Rear Roller Bearings 2 Zerks (1 At each rear roller end) Type of Lubrication: Multi-purpose Grease Quantity: 4 - 5 pumps 24977 As Required Roller Chains Type of Lubrication: Chain Lubricant Quantity: Coat Generously 12227 24 APS1548, APS1560, APS1572 & APS1586 All Purpose Seeder 313-354M 5/13/08
Table of Contents Land Pride Section 5: Specifications & Capacities Section 5: Specifications & Capacities APS1548 & APS1572 All Purpose Seeder Description Overall Width Seeding Width (Broadcast) Weight (Approximate Pounds) Seed Capacity Number of Seed Cups APS1548 APS1560 APS1572 APS1586 61 3/8” 73 3/8" 85 3/8” 99 3/8" 51” 60" 70 1/2” 86" 700# 884# 1046# 1320# 1 Bushel/Foot (4 bushel) 1 Bushel/Foot (5 bushel) 1 Bushel/Foot (6 bushel) 1 Bushel/Foot (7 bushel) 7 8 10 12 Seed Cup T
Table of Contents Land Pride Section 6: Features and Benefits Section 6: Features and Benefits APS1548, APS1560, APS1572 & APS1586 Models Features Benefits 1548, 1560 & 1572 = Cat 1 QH 1586 = Cat1&2 QH Fits Land Pride Quick Hitch for easy one person hook-up to tractor. Seeding Width APS1548 & APS1560 48" & 60" seeding width provides capability to maneuver around landscape obstacles and over uneven hilly terrain.
Table of Contents Land Pride Section 7: Troubleshooting Section 7: Troubleshooting Troubleshooting Chart Problem Uneven seed spacing or uneven stand. Cause Check for plugging in seed cup. Reduce ground speed. Check for trash or mud buildup on rollers. Actual seeding rate is different than desired. Seed treatment will affect seeding rate if the chemicals buildup in seed cup. Unless cleaned regularly, this buildup can cause breakage of the seed cup shaft.
Table of Contents Land Pride Section 8: Appendix Section 8: Appendix Torque Values Chart For Common Bolt Size Bolt Head Identification Bolt Size (Inches) in-tpi 1 1/4" - 20 1/4" - 28 5/16" - 18 5/16" - 24 3/8" - 16 3/8" - 24 7/16" - 14 7/16" - 20 1/2" - 13 1/2" - 20 9/16" - 12 9/16" - 18 5/8" - 11 5/8" - 18 3/4" - 10 3/4" - 16 7/8" - 9 7/8" - 14 1" - 8 1" - 12 1-1/8" - 7 1 1/8" - 12 1 1/4" - 7 1 1/4" - 12 1 3/8" - 6 1 3/8" - 12 1 1/2" - 6 Grade 2 Grade 5 N · m ft-lb 3 N · m 7.4 8.
Table of Contents Land Pride Section 8: Appendix Warranty Land Pride warrants to the original purchaser that this Land Pride product will be free from defects in material and workmanship beginning on the date of purchase by the end user according to the following schedule when used as intended and under normal service and conditions for personal use. Overall Unit: One year Parts and Labor Front & Rear Rollers: Considered wear items.
Corporate Office: P.O. Box 5060 Salina, Kansas 67402-5060 USA www.landpride.