Owner’s Manual OPUS DANGER If you smell gas: 1. Shut off gas to the appliance. 2. Extinguish any open flame. 3. If odor continues, keep away from the appliance and immediately call you gas supplier or fire department. WARNING WARNING indicates an imminently hazardous situation which, if not avoided, will result in death or serious injury. WARNING Do not store or use gasoline or other flammable vapors and liquids in the vicinity of this or any other appliance.
PACKAGE CONTENTS PART A B C D E F G H I J K L 2 A Reflector B Emitter C Support D Protective Guard E Borosilicate Glass Tube F Burner Ignition Plate G Control Box Casing H Gas Hose & Regulator I Back Panel J Front Door Panel K Wheel Kit L Bottom plate DESCRIPTION Reflector Emitter Support Protective Guard Borosilicate Glass Tube Burner Ignition Plate Control Box Casing Gas Hose & Regulator Back Panel Front Door Panel Wheel Kit Base plate QUANTITY 1 1 3 3 1 1 1 1 1 1 1 1
INCLUDED HARDWARE OO EE HH DD Wrench Qty. 1 Bolt Ø10 ×15mm Qty. 2 Nut M8 Qty. 2 Screw Ø8×15 mm Qty. 10 ADDITIONAL REQUIRED HARDWARE SAFETY INFORMATION Please read and understand this entire manual before attempting to assemble, operate or install the product. This manual contains important information about the assembly, operation and maintenance of this patio heater. General safety information is presented in these first few pages and is also located throughout the manual.
SAFETY INFORMATION DANGER DANGER DANGER WARN DANGER 4
SAFETY INFORMATION WARNING WARNING California Proposition 65 Combustion by-products produced when using this product contain chemicals known to the State of California to cause cancer, birth defects, and other reproductive harm. is invisible, odorless, and flammable. An odorant is normally added to help detect leaks and can be described as a “rotten egg” smell. The odorant can fade over time so leaking gas is not always detectable by smell alone. WARNING will sink to the lowest level possible.
ASSEMBLY INSTRUCTIONS 1.You will need to remove at least one of the three protective steel guards (D) in order to safely remove the bubble rap and foam material from the boroscilate glass tube located in the center of the unit. Unscrew all (4) of the MM Ø8×10 mms screws, then remove the protective steel guard from its supports slots. Now that you have properly and carefully removed all transit protection materials from the unit, you will need to place the unit back in its original proper order.
ASSEMBLY INSTRUCTIONS 3. Propane Only-Proper Hose Connection. WARNING! Ensure the hose does not contact any high temperature surfaces, or it may melt and leak causing a fire. 3 4. Connect hose and regulator to cylinder. 4 The propane gas and cylinder are sold separately. Use a standard 20 lb. propane cylinder only. Use this heater only with a propane vapor withdrawal supply system. See chapter 12 of the standard for storage and handling of liquefied petroleum gas, ANSI/NFPA 58 or CSA B149.
OPERATION INSTRUCTIONS DANGER Caution: Do not attempt to operate until you have read and understand all General Safety Information in this manual and all assembly is complete and leak checks have been performed. Note: This heater is equipped with a pilot light that allows for safer startups and shutdowns. Pilot must be lit before main burner can be started.
OPERATION INSTRUCTIONS 4. Press the DOWN button to switch to lower temperature setting and UP button to switch to higher temperature setting. TO TURN OFF THE HEATER 1. Press the POWER button. 2. Turn off the valve of the gas cylinder and disconnect the cylinder. WARNING: 1. The whole gas system, hose, regulator, pilot or burner should be inspected for leak before use. 2. Check the hose assembly for sign of extreme abrasion, cuts or wears.Leak test suspected areas.
OPERATION INSTRUCTIONS WARNING WARNING FOR YOUR SAFETY Be careful when attempting to manually ignite this heater. Holding in the control knob for more than 20 seconds before igniting the gas will cause a ball of flame upon ignition. FOR YOUR SAFETY Heater will be hot after use. Handle with extreme care. When heater is ON: The flame should be blue with straight yellow tops. If excessive yellow flame is detected, turn off heater and consult “Troubleshooting” on page 18. B.
OPERATION INSTRUCTIONS 9. Heater is away from gasoline or other flammable liquids or vapors. 10. Heater is away from windows, air intake openings, sprinklers and other water sources. 11. Heater is at least 24 in. on top and at least 36 in. on sides from combustible materials. 12. Heater is on a hard and level surface. 13. There are no signs of spider or insect nests. 14. All burner passages are clear. 15. All air circulation passages are clear. 16.
CARE AND MAINTENANCE Gas odor with extreme yellow tipping of flame. Heater does NOT reach the desired temperature. Heater glow is excessively uneven. Heater makes popping noises. Spiders and insects can nest in burner or orifices. This dangerous condition can damage heater and render it unsafe for use. Clean burner holes by using a heavy-duty pipe cleaner. Compressed air may help clear away smaller particles. Carbon deposits may create a fire hazard.
TROUBLESHOOTING PROBLEM POSSIBLE CAUSE CORRECTIVE ACTION Cylinder valve is closed Open valve Blockage in orifice or pilot tube Pilot won’t light Air in gas line Note: Heater operates Low gas pressure with cylinder valve fully open at reduced efficiency below 40ºF (5ºC) Igniter fails Clean or replace orifice or pilot tube Open gas line and bleed it (pressing control knob in) for not more than 1 - 2 minutes or until you smell gas Turn cylinder valve OFF and replace cylinder Use match to light pilot;
TEN -YEAR LIMITED WARRANTY The appliance has been manufactured under the highest standards of quality and workmanship. We warrant to the original consumer purchaser that all aspects of this product will be free of defects in material and workmanship for ten(10) year from the date of purchase. A replacement for any defective part will be supplied free of charge for installation by the consumer. Defects or damage caused by the use of other than genuine parts are not covered by this warranty.