Lenovo ideapad 500-14ISK/ ideapad 500-15ISK Hardware Maintenance Manual
Notes: • Before using this information and the product it supports, be sure to read the general information under “Notices” on page 112. • This manual applies to the following models: Lenovo ideapad 500-14ISK/ideapad 500-15ISK. The illustrations used in this manual are for Lenovo ideapad 500-15ISK unless otherwise stated. First Edition (August 2015) © Copyright Lenovo 2015. All rights reserved.
Contents About this manual........................................ iv Safety information......................................... 1 General safety................................................. 2 Electrical safety............................................... 3 Safety inspection guide................................... 5 Handling devices that are sensitive to electrostatic discharge..................................... 6 Grounding requirements..................................
About this manual This manual contains service and reference information for the following Lenovo product: Lenovo ideapad 500-14ISK/ideapad 500-15ISK Use this manual to troubleshoot problems. The manual is divided into the following sections: • The common sections provide general information, guidelines, and safety information required for servicing computers. • The product-specific section includes service, reference, and product-specific parts information.
Safety information Safety information This chapter presents the following safety information that you need to get familiar with before you service a Lenovo ideapad 500-14ISK/ ideapad 500-15ISK computer: • “General safety” on page 2 • “Electrical safety” on page 3 • “Safety inspection guide” on page 5 • “Handling devices that are sensitive to electrostatic discharge” on page 6 • “Grounding requirements” on page 6 • “Safety notices: multilingual translations” on page 7 • “Laser compliance statement” on page
Lenovo ideapad 500-14ISK/ideapad 500-15ISK Hardware Maintenance Manual General safety Follow these rules below to ensure general safety: • Observe a good housekeeping in the area where the machines are put during and after the maintenance. • When lifting any heavy object: 1. Make sure that you can stand safely without slipping. 2. Distribute the weight of the object equally between your feet. 3. Use a slow lifting force. Never move suddenly or twist when you attempt to lift it. 4.
About this manual Electrical safety Observe the following rules when working on electrical equipments. Important: Use only approved tools and test equipments. Some hand tools have handles covered with a soft material that does not insulate you when working with live electrical currents. Many customers have rubber floor mats near their machines that contain small conductive fibers to decrease electrostatic discharges. Do not use such kind of mat to protect yourself from electrical shock.
Lenovo ideapad 500-14ISK/ideapad 500-15ISK Hardware Maintenance Manual • Always look carefully for possible hazards in your work area. Examples of these hazards are moist floors, nongrounded power extension cables, power surges, and missing safety grounds. • Do not touch live electrical circuits with the reflective surface of a plastic dental mirror. The surface is conductive; such touching can cause personal injury and machine damage.
About this manual Safety inspection guide The purpose of this inspection guide is to assist you in identifying potential unsafe conditions. As each machine was designed and built, required safety items were installed to protect users and service personnel from injury. This guide addresses only those items. You should use good judgment to identify potential safety hazards according to the attachment of non-Lenovo features or options not covered by this inspection guide.
Lenovo ideapad 500-14ISK/ideapad 500-15ISK Hardware Maintenance Manual Handling devices that are sensitive to electrostatic discharge Any computer part containing transistors or integrated circuits (ICs) should be considered sensitive to electrostatic discharge (ESD). ESD damage can occur when there is a difference in charge between objects. Protect against ESD damage by equalizing the charge so that the machine, the part, the work mat, and the person handling the part are all at the same charge. Notes: 1.
About this manual Safety notices: multilingual translations The safety notices in this section are provided in English, French, German, Hebrew, Italian, Japanese, and Spanish. Safety notice 1 Before the computer is powered on after FRU replacement, make sure all screws, springs, and other small parts are in place and are not left loose inside the computer. Verify this by shaking the computer and listening for rattling sounds. Metallic parts or metal flakes can cause electrical shorts.
Lenovo ideapad 500-14ISK/ideapad 500-15ISK Hardware Maintenance Manual Safety notice 2 DANGER Some standby batteries contain a small amount of nickel and cadmium. Do not disassemble a standby battery, recharge it, throw it into fire or water, or shortcircuit it. Dispose of the battery as required by local ordinances or regulations. Use only the battery in the appropriate parts listing. Use of an incorrect battery can result in ignition or explosion of the battery.
About this manual Safety notice 3 DANGER The battery pack contains small amounts of nickel. Do not disassemble it, throw it into fire or water, or short-circuit it. Dispose of the battery pack as required by local ordinances or regulations. Use only the battery in the appropriate parts listing when replacing the battery pack. Use of an incorrect battery can result in ignition or explosion of the battery. La batterie contient du nickel. Ne la démontez pas, ne l’exposez ni au feu ni à l’eau.
Lenovo ideapad 500-14ISK/ideapad 500-15ISK Hardware Maintenance Manual Safety notice 4 DANGER The lithium battery can cause a fire, an explosion, or a severe burn. Do not recharge it, remove its polarized connector, disassemble it, heat it above 100°C (212°F), incinerate it, or expose its cell contents to water. Dispose of the battery as required by local ordinances or regulations. Use only the battery in the appropriate parts listing.
About this manual Safety notice 5 If the LCD breaks and the fluid from inside the LCD gets into your eyes or on your hands, immediately wash the affected areas with water at least for 15 minutes. Seek medical care if any symptoms caused by the fluid are present after washing. Si le panneau d’affichage à cristaux liquides se brise et que vous recevez dans les yeux ou sur les mains une partie du fluide, rincez-les abondamment pendant au moins quinze minutes.
Lenovo ideapad 500-14ISK/ideapad 500-15ISK Hardware Maintenance Manual Safety notice 6 DANGER To avoid shock, do not remove the plastic cover that protects the lower part of the inverter card. Afin d’éviter tout risque de choc électrique, ne retirez pas le cache en plastique protégeant la partie inférieure de la carte d’alimentation. Aus Sicherheitsgründen die Kunststoffabdeckung, die den unteren Teil der Spannungswandlerplatine umgibt, nicht entfernen.
About this manual Safety notice 8 DANGER Before removing any FRU, turn off the computer, unplug all power cords from electrical outlets, remove the battery pack, and then disconnect any interconnecting cables. Avant de retirer une unité remplaçable en clientèle, mettez le système hors tension, débranchez tous les cordons d’alimentation des socles de prise de courant, retirez la batterie et déconnectez tous les cordons d’interface.
Lenovo ideapad 500-14ISK/ideapad 500-15ISK Hardware Maintenance Manual Laser compliance statement Some models of Lenovo computer are equipped from the factory with an optical storage device such as a CD-ROM drive or a DVD-ROM drive. Such devices are also sold separately as options. If one of these drives is installed, it is certified in the U.S. to conform to the requirements of the Department of Health and Human Services 21 Code of Federal Regulations (DHHS 21 CFR) Subchapter J for Class 1 laser products.
About this manual A CD-ROM drive, a DVD-ROM drive, or any other storage device installed may contain an embedded Class 3A or Class 3B laser diode. Note the following: DANGER Emits visible and invisible laser radiation when open. Do not stare into the beam, do not view directly with optical instruments, and avoid direct exposure to the beam. Radiação por raio laser ao abrir. Não olhe fixo no feixe de luz, não olhe diretamente por meio de instrumentos óticos e evite exposição direta com o feixe de luz.
Lenovo ideapad 500-14ISK/ideapad 500-15ISK Hardware Maintenance Manual Important service information This chapter presents the following important service information: • “Strategy for replacing FRUs” on page 16 – “Strategy for replacing a hard disk drive” on page 17 – “Important notice for replacing a system board” on page 17 • “Important information about replacing RoHS compliant FRUs” on page 18 Important: BIOS and device driver fixes are customer-installable.
Important service information Use the following strategy to prevent unnecessary expense for replacing and servicing FRUs: • If you are instructed to replace an FRU, but the replacement does not solve the problem, reinstall the original FRU before you continue. • Some computers have both a processor board and a system board. If you are instructed to replace either of them, and replacing one of them does not solve the problem, reinstall that board, and then replace the other one.
Lenovo ideapad 500-14ISK/ideapad 500-15ISK Hardware Maintenance Manual Important information about replacing RoHS compliant FRUs RoHS, The Restriction of Hazardous Substances in Electrical and Electronic Equipment Directive (2002/95/EC) is a European Union legal requirement affecting the global electronics industry. RoHS requirements must be implemented on Lenovo products placed on the market after June 2006. Products on the market before June 2006 are not required to have RoHS compliant parts.
General checkout General checkout This chapter presents the following information: • “What to do first” on page 20 • “Power system checkout” on page 21 Before you go to the checkout, make sure to read the following important notes: Important notes: • Only certified trained personnel can service the computer. • Before replacing any FRU, read the entire page on removing and replacing FRUs. • Carefully remove screws for reuse when replacing FRUs.
Lenovo ideapad 500-14ISK/ideapad 500-15ISK Hardware Maintenance Manual What to do first When you do return an FRU, you must include the following information in the parts exchange form or parts return form that you attach to it: 1. Name and phone number of servicer 2. Date of service 3. Date on which the machine failed 4. Date of purchase 5. Procedure index and page number in which the failing FRU was detected 6. Failing FRU name and part number 7. Machine type, model number, and serial number 8.
General checkout Power system checkout To verify a symptom, follow the steps below: 1. Turn off the computer. 2. Remove the battery pack. 3. Connect the AC adapter. 4. Make sure that power is supplied when you turn on the computer. 5. Turn off the computer. 6. Disconnect the AC adapter and install the charged battery pack. 7. Make sure that the battery pack supplies power when you turn on the computer.
Lenovo ideapad 500-14ISK/ideapad 500-15ISK Hardware Maintenance Manual Checking operational charging To check whether the battery charges properly during operation, use a discharged battery pack or a battery pack that has less than 50% of the total power remaining when installed in the computer. Perform operational charging. If the battery status indicator or icon does not light on, remove the battery pack and let it return to room temperature. Reinstall the battery pack.
Related service information Related service information This chapter presents the following information: • “Restoring the factory contents by using OneKey Recovery” on page 23 • “Passwords” on page 24 • “Power management” on page 25 Restoring the factory contents by using OneKey Recovery Restore of factory default The Lenovo ideapad 500-14ISK/ideapad 500-15ISK computers come with pre-installed OneKey Recovery System.
Lenovo ideapad 500-14ISK/ideapad 500-15ISK Hardware Maintenance Manual Passwords As many as three passwords may be needed for any Lenovo computer: the power-on password (POP), the hard disk password (HDP), and the administrator password. If any of these passwords has been set, a prompt for it appears on the screen whenever the computer is turned on. The computer does not start until the password is entered.
Related service information Power management Note: Power management modes are not supported for APM operating system. To reduce power consumption, the computer has three power management modes: screen blank, sleep (standby), and shut down. Screen blank state If the time set on the “Turn off monitor” timer in the operating system expires, the LCD backlight turns off. You can also turn off the LCD backlight by pressing F9. To end screen blank state and resume normal operation, press any key.
Lenovo ideapad 500-14ISK/ideapad 500-15ISK Hardware Maintenance Manual Lenovo ideapad 500-14ISK/ideapad 500-15ISK This chapter presents the following product-specific service references and product-specific parts information: • “Specifications” on page 26 • “Status indicators” on page 28 • “Fn key combinations/Hotkeys” on page 30 • “FRU replacement notices” on page 31 • “Removing and replacing an FRU” on page 32 • “Locations” on page 80 • “Parts list” on page 83 Specifications The following table lists th
Lenovo ideapad 500-14ISK/ideapad 500-15ISK Table 1. Specifications (continued) Feature Description Storage devices • • • • • • • • • • • • • I/O port Audio Ethernet (on the system board) Bluetooth wireless Keyboard Integrated camera Battery AC adapter Pre-installed operating system 2.5-inch, SATA II/SATA III 500 GB / 1 TB / 2 TB 5,400 rpm HYBRID 500 GB / 1 TB 5,400 rpm SSHD(8 GB) 128 GB / 256 GB(SSD) SATA III Combo audio jack × 1 RJ-45 × 1 HDMI × 1 VGA × 1 USB 2.0 × 1, USB 3.
Lenovo ideapad 500-14ISK/ideapad 500-15ISK Hardware Maintenance Manual Status indicators The system status indicators below show the computer status: ideapad 500-14ISK 1 28 2
Lenovo ideapad 500-14ISK/ideapad 500-15ISK ideapad 500-15ISK 1 2 Table 2. Status indicators Indicator 1 Power Indicator status On (solid white) Charge status --- Blinking --- Off --- On (solid white) Charging Blinking slowly (white) Charging Blinking slowly (amber) Charging Blinking quickly (amber) The computer is in sleep mode. The computer is powered off. The battery has more than 80% charge. Discharging The battery has more than 20% charge.
Lenovo ideapad 500-14ISK/ideapad 500-15ISK Hardware Maintenance Manual Fn key combinations/Hotkeys The following table shows the function of each combination of Fn with a function key. Table 3. Fn key combinations ideapad 500-14ISK Fn + Home: Fn + End: Fn + PgUp : Fn + PgDn : Fn + Space (on select models): Activates the pause function. Activates the break function. Enables/disables the scroll lock. Activates the insert function. Adjusts the keyboard backlight.
Lenovo ideapad 500-14ISK/ideapad 500-15ISK FRU replacement notices This section presents notices related to removing and replacing parts. Read this section carefully before replacing any FRU. Screw notices Loose screws can cause a reliability problem. In the Lenovo computer, this problem is addressed with special nylon-coated screws that have the following characteristics: • They maintain tight connections. • They do not easily come loose, even with shock or vibration. • They are harder to tighten.
Lenovo ideapad 500-14ISK/ideapad 500-15ISK Hardware Maintenance Manual Removing and replacing an FRU This section presents exploded figures with the instructions to indicate how to remove and replace the FRU. Make sure to observe the following general rules: 1. Do not attempt to service any computer unless you have been trained and certified. An untrained person runs the risk of damaging parts. 2. Before replacing any FRU, review “FRU replacement notices” on page 31. 3.
Lenovo ideapad 500-14ISK/ideapad 500-15ISK 1010 Keyboard Figure 1. Removal steps of keyboard Remove the screws 1. ideapad 500-14ISK 1 1 1 ideapad 500-15ISK 1 Step 1 1 1 Screw (quantity) Color Torque M2 × 6 mm, Phillips head, nylok-coated (3) LOW TO KB Black/ Silver 1.85+/-0.
Lenovo ideapad 500-14ISK/ideapad 500-15ISK Hardware Maintenance Manual Figure 1. Removal steps of keyboard (continued) Push the keyboard with the tip of an unfolded paper clip (or similar object without a sharp tip) through the screw hole on the back cover. Loosen the keyboard with fingers in the direction shown by arrows 2.
Lenovo ideapad 500-14ISK/ideapad 500-15ISK Figure 1. Removal steps of keyboard (continued) Lift the keyboard slightly 3, and then detach the connectors in the direction shown by arrows 4, 5 and 6. Remove the keyboard. Note: Select models do not have the keyboard backlight cable (the dashed area).
Lenovo ideapad 500-14ISK/ideapad 500-15ISK Hardware Maintenance Manual Figure 1. Removal steps of keyboard (continued) ideapad 500-15ISK 3 5 6 4 When installing: Make sure that the FPC connector is attached firmly.
Lenovo ideapad 500-14ISK/ideapad 500-15ISK 1020 Optical drive For access, remove this FRU: • “1010 Keyboard” on page 33 Figure 2. Removal steps of optical drive ideapad 500-14ISK Remove the screw 1.Then pull the optical drive out in the direction shown by arrow 2. 1 2 Step 1 Screw (quantity) Color Torque M2 × 6 mm, Phillips head, nylok-coated (1) LOW TO UPPER Silver 1.85+/-0.
Lenovo ideapad 500-14ISK/ideapad 500-15ISK Hardware Maintenance Manual Figure 2. Removal steps of Optical drive (continued) ideapad 500-15ISK Remove the screw 1. Then pull the optical drive out in the direction shown by arrow 2. 1 2 Step 1 38 Screw (quantity) Color Torque M2 × 6 mm, Phillips head, nylok-coated (1) ODD TO LOWER Black 1.85+/-0.
Lenovo ideapad 500-14ISK/ideapad 500-15ISK Figure 2. Removal steps of optical drive (continued) Remove the screws 3, then carefully remove the optical drive bracket and bezel in the directions shown by arrows 4 and 5. 5 4 Step 3 3 3 Screw (quantity) Color Torque M2 × 3 mm, Phillips head, nylok-coated (2) ODD BRK TO ODD MODULE Black 1.85+/-0.
Lenovo ideapad 500-14ISK/ideapad 500-15ISK Hardware Maintenance Manual 1030 Base cover For access, remove this FRU: • “1010 Keyboard” on page 33 • “1020 Optical drive” on page 37 Figure 3. Removal steps of base cover ideapad 500-14ISK Remove the screws 1 and 2. 2 1 2 1 1 1 1 1 Step 1 2 40 Screw (quantity) Color Torque M2 × 6 mm, Phillips head, nylok-coated (6) LOW TO UPPER M2.5 × 6 mm, Phillips head, nylok-coated (2) LOW TO UPPER Black/ Silver 1.85+/-0.15 kgf/cm Black/ Silver 3.0+/-0.
Lenovo ideapad 500-14ISK/ideapad 500-15ISK Figure 3. Removal steps of base cover (continued) Remove the base cover in the directions shown by arrows 3 and 4.
Lenovo ideapad 500-14ISK/ideapad 500-15ISK Hardware Maintenance Manual Figure 3. Removal steps of base cover (continued) ideapad 500-15ISK Remove the screws 1. 1 1 Step 1 42 Screw (quantity) Color Torque M2 × 6 mm, Phillips head, nylok-coated (2) UPPER TO LOWER Black 1.85+/-0.
Lenovo ideapad 500-14ISK/ideapad 500-15ISK Figure 3. Removal steps of base cover (continued) Remove the screws 2 and 3 from the bottom. 3 2 2 3 2 2 2 2 Step 2 3 Screw (quantity) Color Torque M2 × 6 mm, Phillips head, nylok-coated (6) LOW TO UPPER M2.5 × 6 mm, Phillips head, nylok-coated (2) LOW TO UPPER Black/ Silver 1.85+/-0.15 kgf/cm Black/ Silver 3.0+/-0.3 kgf/cm Remove the base cover in the directions shown by arrows 4 and 5.
Lenovo ideapad 500-14ISK/ideapad 500-15ISK Hardware Maintenance Manual Note: Applying labels to the base cover The new base cover FRU is shipped with a kit containing labels of several kinds. When you replace the base cover, you need to apply the following label: The following labels need to be peeled off from the old base cover, and need to be put on the new base cover.
Lenovo ideapad 500-14ISK/ideapad 500-15ISK 1040 Battery pack For access, remove these FRUs in order: • “1010 Keyboard” on page 33 • “1020 Optical drive” on page 37 • “1030 Base cover” on page 40 DANGER Only use the battery specified in the parts list for your computer. Any other battery could ignite or explode. Figure 4. Removal steps of battery pack Detach the battery pack connector in the direction shown by arrow 1, remove the screws 2. 2 2 1 Step 2 Screw (quantity) Color Torque M2.
Lenovo ideapad 500-14ISK/ideapad 500-15ISK Hardware Maintenance Manual Figure 4. Removal steps of battery pack (continued) Remove the battery pack in the direction shown by arrow 3. 3 When installing: Make sure the battery pack connector is attached firmly.
Lenovo ideapad 500-14ISK/ideapad 500-15ISK 1050 Hard disk drive For access, remove these FRUs in order: • “1010 Keyboard” on page 33 • “1020 Optical drive” on page 37 • “1030 Base cover” on page 40 • “1040 Battery pack” on page 45 Attention: • Do not drop the hard disk drive or apply any physical shock to it. The hard disk drive is sensitive to physical shock. Improper handling can cause damages and permanent loss of data.
Lenovo ideapad 500-14ISK/ideapad 500-15ISK Hardware Maintenance Manual Figure 5. Removal steps of hard disk drive (continued) Lift the IO board cable in the direction shown by arrow 3. Remove the screws 4. 3 4 4 Step 4 4 4 Screw (quantity) Color M2.5 × 4 mm, Phillips head, nylok-coated (4) HDD BRK TO UPPER Silver Torque 3.0+/-0.3 kgf/cm When installing: Make sure that the cable connector is attached firmly. Detach the HDD connector in the direction shown by arrow 5.
Lenovo ideapad 500-14ISK/ideapad 500-15ISK Figure 5. Removal steps of hard disk drive (continued) Remove the screws 7, then take out the metal frame. 7 7 7 7 Step 7 Screw (quantity) Color M3 × 3 mm, Phillips head, nylok-coated (4) HDD BRK TO HDD Silver Torque 3.0+/-0.
Lenovo ideapad 500-14ISK/ideapad 500-15ISK Hardware Maintenance Manual 1060 Speakers For access, remove these FRUs in order: • “1010 Keyboard” on page 33 • “1020 Optical drive” on page 37 • “1030 Base cover” on page 40 • “1040 Battery pack” on page 45 Figure 6. Removal steps of speakers Detach the speakers connector in the direction shown by arrow 1. Remove the screws 2.
Lenovo ideapad 500-14ISK/ideapad 500-15ISK Figure 6. Removal steps of speakers (continued) Remove the speakers 3. ideapad 500-14ISK 3 3 ideapad 500-15ISK 3 3 When installing: Make sure that the speakers connector is attached firmly.
Lenovo ideapad 500-14ISK/ideapad 500-15ISK Hardware Maintenance Manual 1070 IO board For access, remove these FRUs in order: • “1010 Keyboard” on page 33 • “1020 Optical drive” on page 37 • “1030 Base cover” on page 40 • “1040 Battery pack” on page 45 • “1060 Speakers” on page 50 Figure 7. Removal steps of IO board Detach the IO board connector in the directions shown by arrows 1 and 2. Remove the screw 3.
Lenovo ideapad 500-14ISK/ideapad 500-15ISK 1080 PCI Express Mini Card for wireless LAN For access, remove these FRUs in order: • “1010 Keyboard” on page 33 • “1020 Optical drive” on page 37 • “1030 Base cover” on page 40 • “1040 Battery pack” on page 45 Important: The preinstalled WLAN module may only be replaced with a Lenovo approved module in order to comply with FCC and IC regulations. Refer to Table 5. "Parts list—Overall" on page 86 for Lenovo part numbers for the approved modules. Figure 8.
Lenovo ideapad 500-14ISK/ideapad 500-15ISK Hardware Maintenance Manual Figure 8. Removal steps of PCI Express Mini Card for wireless LAN (continued) Remove the card in the direction shown by arrow 3. 3 When installing: • In models with a wireless LAN card that has two antenna connectors, plug the black cable (1st) (MAIN) into the jack labeled MAIN, and the white cable (2nd) (AUX) into the jack labeled AUX on the card.
Lenovo ideapad 500-14ISK/ideapad 500-15ISK 1090 ODD board (ideapad 500-15ISK) For access, remove these FRUs in order: • “1010 Keyboard” on page 33 • “1020 Optical drive” on page 37 • “1030 Base cover” on page 40 • “1040 Battery pack” on page 45 Figure 9. Removal steps of ODD board (ideapad 500-15ISK) Detach the FPC connector in the directions shown by arrows 1 and 2. Remove the screws 3.
Lenovo ideapad 500-14ISK/ideapad 500-15ISK Hardware Maintenance Manual 1100 DIMM For access, remove these FRUs in order: • “1010 Keyboard” on page 33 • “1020 Optical drive” on page 37 • “1030 Base cover” on page 40 • “1040 Battery pack” on page 45 Figure 10. Removal steps of DIMM Release the two latches on both edges of the socket at the same time in the direction shown by arrows 1, and then unplug the DIMM in the direction shown by arrow 2.
Lenovo ideapad 500-14ISK/ideapad 500-15ISK 1110 Fan assembly and Heat Sink assembly For access, remove these FRUs in order: • “1010 Keyboard” on page 33 • “1020 Optical drive” on page 37 • “1030 Base cover” on page 40 • “1040 Battery pack” on page 45 Figure 11. Removal steps of fan assembly and heat sink assembly Detach the fan connector in the direction shown by arrow 1 , and then remove the screws 2.
Lenovo ideapad 500-14ISK/ideapad 500-15ISK Hardware Maintenance Manual Figure 11. Removal steps of DIMM (continued) Remove the fan in the direction shown by arrow 3. Be careful not to damage the connector. 3 Remove the screws 4. 4 4 4 4 4 Step 4 58 Screw (quantity) Color M2 × 3, Phillips head, nylok-coated (5) THERMAL MODULE TO CPU BRK & THERMAL Black MODULE TO MB (DIS-40W) Torque 1.85+/-0.
Lenovo ideapad 500-14ISK/ideapad 500-15ISK Figure 11. Removal steps of DIMM (continued) Lift the heat sink in the direction shown by arrow 5. 5 b a When installing: Before you attach the fan assembly to the computer, apply thermal grease, part shown in the figure above. Either at an amount of 0.2 grams, to the too much or too little grease application can cause a thermal problem due to imperfect contact with a component.
Lenovo ideapad 500-14ISK/ideapad 500-15ISK Hardware Maintenance Manual 1120 System board Important notices for handling the system board: When handling the system board, bear the following in mind. • Be careful not to drop the system board on a bench top that has a hard surface, such as metal, wood, or composite. • Avoid rough handling of any kind. • In the whole process, make sure not to drop or stack the system board.
Lenovo ideapad 500-14ISK/ideapad 500-15ISK Figure 12.
Lenovo ideapad 500-14ISK/ideapad 500-15ISK Hardware Maintenance Manual Figure 12. Removal steps of system board (continued) Detach the two connectors in the directions shown by arrows 2. Remove the screws 3. ideapad 500-14ISK 2 2 3 3 3 3 ideapad 500-15ISK 2 3 2 3 3 3 3 3 Step 3 3 62 Screw (quantity) M2.5 × 4 mm, Phillips head, nylok-coated (4) MB TO UPPER (ideapad 500-14ISK) M2.5 × 4 mm, Phillips head, nylok-coated (6) MB TO UPPER & MB TO KB BRK (ideapad 500-15ISK) Color Torque Silver 3.
Lenovo ideapad 500-14ISK/ideapad 500-15ISK Figure 12. Removal steps of system board (continued) Remove the system board in the direction shown by arrow 4.
Lenovo ideapad 500-14ISK/ideapad 500-15ISK Hardware Maintenance Manual Figure 12. Removal steps of system board (continued) Remove the screws 5. ideapad 500-14ISK 5 5 ideapad 500-15ISK 5 5 Step 5 64 Screw (quantity) Color Torque M2 × 3, Phillips head, nylok-coated (2) RJ45 COVER TO MB Black 1.85+/-0.
Lenovo ideapad 500-14ISK/ideapad 500-15ISK Figure 12. Removal steps of system board (continued) Remove the RJ-45 door in the direction shown by arrow 6.
Lenovo ideapad 500-14ISK/ideapad 500-15ISK Hardware Maintenance Manual 1130 Upper case For access, remove these FRUs in order: • “1010 Keyboard” on page 33 • “1020 Optical drive” on page 37 • “1030 Base cover” on page 40 • “1040 Battery pack” on page 45 • “1050 Hard disk drive” on page 47 • “1060 Speakers” on page 50 • “1070 IO board” on page 52 • “1080 PCI Express Mini Card for wireless LAN” on page 53 • “1090 ODD board (ideapad 500-15ISK)” on page 55 • “1110 Fan assembly and Heat Sink assembly” on page 57
Lenovo ideapad 500-14ISK/ideapad 500-15ISK Figure 13. Removal steps of upper case (continued) ideapad 500-15ISK 1 1 1 1 Step 1 1 Screw (quantity) M2.5 × 4, Phillips head, nylok-coated (4) HINGE BRK TO UPPER (ideapad 500-14ISK) M2.5 × 5, Phillips head, nylok-coated (5) HINGE BRK TO UPPER (ideapad 500-15ISK) 1 Color Torque Silver 3.0+/-0.3 kgf/cm Black 3.0+/-0.3 kgf/cm Open the hinge in the direction shown by arrows 2.
Lenovo ideapad 500-14ISK/ideapad 500-15ISK Hardware Maintenance Manual Figure 13. Removal steps of upper case (continued) ideapad 500-15ISK 2 2 Remove the DC in cable in the direction shown by arrow 3.
Lenovo ideapad 500-14ISK/ideapad 500-15ISK Figure 13. Removal steps of upper case (continued) ideapad 500-15ISK 3 Remove the screw 4. Then remove the power board in the direction shown by arrow 5.
Lenovo ideapad 500-14ISK/ideapad 500-15ISK Hardware Maintenance Manual Figure 13. Removal steps of upper case (continued) ideapad 500-15ISK 4 5 Step 4 Screw (quantity) Color Torque M2 × 3, Phillips head, nylok-coated (1) POWER BOARD TO UPPER Black 1.85+/-0.15 kgf/cm Release the antenna cables from the cable guides in the direction shown by arrows 6.
Lenovo ideapad 500-14ISK/ideapad 500-15ISK Figure 13. Removal steps of upper case (continued) ideapad 500-15ISK 6 6 6 Remove the upper case from the LCD module in the directions shown by arrow 7 and 8.
Lenovo ideapad 500-14ISK/ideapad 500-15ISK Hardware Maintenance Manual Figure 13.
Lenovo ideapad 500-14ISK/ideapad 500-15ISK 1140 LCD unit For access, remove these FRUs in order: • “1010 Keyboard” on page 33 • “1020 Optical drive” on page 37 • “1030 Base cover” on page 40 • “1040 Battery pack” on page 45 • “1050 Hard disk drive” on page 47 • “1060 Speakers” on page 50 • “1070 IO board” on page 52 • “1080 PCI Express Mini Card for wireless LAN” on page 53 • “1090 ODD board (ideapad 500-15ISK)” on page 55 • “1100 DIMM” on page 56 • “1110 Fan assembly and Heat Sink assembly” on page 57 • “
Lenovo ideapad 500-14ISK/ideapad 500-15ISK Hardware Maintenance Manual Figure 14. Removal steps of LCD unit (continued) Step 1: unlock LCD bezel as shown by picture 1. Step 2&3: unlock bezel off from the right & left corners as shown by pictures 2 & 3. Step 4: unlock bezel from both sides as shown by picture 4. Step 5: remove bezel from the rear side as shown by picture 5.
Lenovo ideapad 500-14ISK/ideapad 500-15ISK Figure 14. Removal steps of LCD unit (continued) Remove the screws 1. Lift the LCD module slightly 2. Disconnect the connector in the direction shown by arrow 3. Then remove the LCD module. 1 2 1 1 1 3 Step 1 Screw (quantity) Color Torque M2 × 3, Phillips head, nylok-coated (4) HINGE BRK TO LCD PANEL Black 1.85+/-0.
Lenovo ideapad 500-14ISK/ideapad 500-15ISK Hardware Maintenance Manual 1150 LCD hinges For access, remove these FRUs in order: • “1010 Keyboard” on page 33 • “1020 Optical drive” on page 37 • “1030 Base cover” on page 40 • “1040 Battery pack” on page 45 • “1050 Hard disk drive” on page 47 • “1060 Speakers” on page 50 • “1070 IO board” on page 52 • “1080 PCI Express Mini Card for wireless LAN” on page 53 • “1090 ODD board (ideapad 500-15ISK)” on page 55 • “1100 DIMM” on page 56 • “1110 Fan assembly and Heat
Lenovo ideapad 500-14ISK/ideapad 500-15ISK 1160 Integrated camera, LCD cable and antenna assembly For access, remove these FRUs in order: • “1010 Keyboard” on page 33 • “1020 Optical drive” on page 37 • “1030 Base cover” on page 40 • “1040 Battery pack” on page 45 • “1050 Hard disk drive” on page 47 • “1060 Speakers” on page 50 • “1070 IO board” on page 52 • “1080 PCI Express Mini Card for wireless LAN” on page 53 • “1090 ODD board (ideapad 500-15ISK)” on page 55 • “1100 DIMM” on page 56 • “1110 Fan assemb
Lenovo ideapad 500-14ISK/ideapad 500-15ISK Hardware Maintenance Manual Figure 16. Removal steps of integrated camera, LCD cable and antenna assembly (continued) Remove the LCD cable in the direction shown by arrows 2. 2 2 Remove the antenna assembly in the direction shown by arrows 3.
Lenovo ideapad 500-14ISK/ideapad 500-15ISK Figure 16. Removal steps of integrated camera, LCD cable and antenna assembly (continued) Remove the camera in the direction shown by arrow 4. 4 When installing: Stick the integrated camera to the top center of the LCD cover and adjust the placement of it to make sure the connector is attached firmly.
Lenovo ideapad 500-14ISK/ideapad 500-15ISK Hardware Maintenance Manual Locations Front view and right-side view 1 Integrated camera Note: For Lenovo ideapad 500-15ISK, select models have a 3D camera. 2 Built-in microphone 3 Wireless LAN antennas 4 Computer display 5 Power button 6 Touchpad 7 Combo audio jack 8 USB port 9 Memory card slot J Optical drive (on select models) K Kensington lock slot L System status indicators Note: For the description of each indicator, see “Status indicators” on page 28.
Lenovo ideapad 500-14ISK/ideapad 500-15ISK ideapad 500-15ISK 3 2 1 2 3 4 5 6 11 10 9 12 7 8 81
Lenovo ideapad 500-14ISK/ideapad 500-15ISK Hardware Maintenance Manual Bottom and Left-side view 1 2 3 4 5 6 7 8 9 Speakers Novo button USB port HDMI port RJ-45 port VGA port Ventilation slots AC power adapter jack Louvers ideapad 500-14ISK 9 8 1 7 6 5 4 1 3 2 ideapad 500-15ISK 9 8 1 7 6 4 1 82 3 2 5
Lenovo ideapad 500-14ISK/ideapad 500-15ISK Parts list This section presents the following service parts: • “Overall” on page 84 • “LCD FRUs” on page 97 • “Keyboard” on page 100 • “Miscellaneous parts” on page 107 • “AC adapters” on page 108 • “Screws” on page 108 • “Power cords” on page 109 Note: Each FRU is available for all types or models, unless specific types or models are specified. Attention: Do not attempt to replace an FRU on your own.
Lenovo ideapad 500-14ISK/ideapad 500-15ISK Hardware Maintenance Manual Overall ideapad 500-14ISK 1 2 3 4 e 5 6 7 a c b 8 f 9 g 11 13 12 d 14 15 84
Lenovo ideapad 500-14ISK/ideapad 500-15ISK ideapad 500-15ISK 1 2 3 4 e 5 6 a 7 c b 8 f 9 g 10 11 12 13 d 14 15 85
Lenovo ideapad 500-14ISK/ideapad 500-15ISK Hardware Maintenance Manual Table 5. Parts list—Overall No. FRU a-h 1 2 3 3 3 3 3 3 3 3 3 3 3 3 4 5 5 5 5 5 5 5 5 5 5 5 5 5 5 5 5 5 5 6 6 6 6 6 6 6 6 6 6 6 6 6 86 See “Miscellaneous parts” on page 107. LCD unit (see “LCD FRUs” on page 97.) Keyboard (see “Keyboard” on page 100.
Lenovo ideapad 500-14ISK/ideapad 500-15ISK Table 5. Parts list—Overall (continued) No.
Lenovo ideapad 500-14ISK/ideapad 500-15ISK Hardware Maintenance Manual Table 5. Parts list—Overall (continued) No.
Lenovo ideapad 500-14ISK/ideapad 500-15ISK Table 5. Parts list—Overall (continued) No. FRU 7 7 7 7 7 7 7 7 7 7 7 7 7 7 7 8 8 9 10 10 11 11 11 11 11 11 11 11 11 11 11 11 12 12 12 12 13 13 13 13 13 13 13 13 13 13 13 13 HLDS GUE0N 9.0mm internal DVD Rambo ODD PLDS DA-8A6SH 9.0mm Slim Tray Rambo ODD PSN UJ8HC 9.0mm Slim Tray Rambo ODD Z41 White Dummy ODD Z41 Red Dummy ODD Z41 Black Dummy ODD Dummy ODD C Z41-70 Black Dummy ODD C Z41-70 White HLDS GUE0N 9.0mm internal DVD Rambo ODD PLDS DA-8A6SH 9.
Lenovo ideapad 500-14ISK/ideapad 500-15ISK Hardware Maintenance Manual No. FRU 13 13 14 14 14 14 15 15 15 15 — 90 ST2000LM003 9.5mm 5400rpm Samsung MZYLN256HCHP 2.5'' Z41 JBL Blade N Speaker Speaker C Z41-70 Z51/Z71 JBL Blade N Speaker Speaker C Z51-70 Lower Case C Z41-70 Black Lower Case C Z41-70 White Lower Case C Z51-70 Black Lower Case C Z51-70 White AC adapter (see “AC adapters” on page 108). FRU no.
Lenovo ideapad 500-14ISK/ideapad 500-15ISK LCD FRUs In Lenovo ideapad 500-14ISK/ideapad 500-15ISK, there are following types of LCDs. • “14.0-in.
Lenovo ideapad 500-14ISK/ideapad 500-15ISK Hardware Maintenance Manual • “15.6-in. HD LED” ideapad 500-15ISK 1 2 3 4 5 6 7 * For Lenovo Z51-70, select models have a 3D camera. 3D camera cable, EPD cable and microphone board are different from the common models. Please refer to the actual product.
Lenovo ideapad 500-14ISK/ideapad 500-15ISK Table 6. Parts list—LCD FRUs No. FRU FRU no.
Lenovo ideapad 500-14ISK/ideapad 500-15ISK Hardware Maintenance Manual Keyboard Table 7. Parts list—Keyboard Language P/N Chicony Normal ideapad 500-14ISK Liteon Normal 94 English U.K. English Italian Spanish Turkish Thai Portuguese Latin Canadian English&French Korean Traditional Chinese Russian French German Arabic Brazilian Japanese Dutch Greek Hebrew Hungarian Four Nordic countries Belgian Icelandic Slovenian Swiss International English Czechoslovakian Bulgarian Indian French-Arabic English U.K.
Lenovo ideapad 500-14ISK/ideapad 500-15ISK Table 7. Parts list—Keyboard (continued) Language P/N Liteon Normal ideapad 500-14ISK Sunrex Normal French German Arabic Brazilian Japanese Dutch Greek Hebrew Hungarian Four Nordic countries Belgian Icelandic Slovenian Swiss International English Czechoslovakian Bulgarian Indian French-Arabic English U.K.
Lenovo ideapad 500-14ISK/ideapad 500-15ISK Hardware Maintenance Manual Table 7. Parts list—Keyboard (continued) Language P/N Sunrex Normal Chicony Backlight ideapad 500-14ISK Sunrex Backlight 96 Czechoslovakian Bulgarian Indian French-Arabic English English (for USA) U.K.
Lenovo ideapad 500-14ISK/ideapad 500-15ISK Table 7. Parts list—Keyboard (continued) Language ideapad 500-14ISK Sunrex Backlight ideapad 500-15ISK Chicony Normal P/N Canadian English&French Korean Traditional Chinese Russian French German Arabic Brazilian Dutch Greek Hebrew Hungarian Four Nordic countries Belgian Icelandic Slovenian Swiss International English Czechoslovakian Bulgarian Indian French-Arabic English U.K.
Lenovo ideapad 500-14ISK/ideapad 500-15ISK Hardware Maintenance Manual Table 7. Parts list—Keyboard (continued) Language P/N Chicony Normal ideapad 500-15ISK Sunrex Normal Darfon Normal 98 Icelandic Slovenian Swiss International English Czechoslovakian Bulgarian Indian French-Arabic English U.K.
Lenovo ideapad 500-14ISK/ideapad 500-15ISK Table 7. Parts list—Keyboard (continued) Language P/N Darfon Normal ideapad 500-15ISK Sunrex Backlight Portuguese Latin Canadian English&French Korean Traditional Chinese Russian French German Arabic Brazilian Japanese Dutch Greek Hebrew Hungarian Four Nordic countries Belgian Icelandic Slovenian Swiss International English Czechoslovakian Bulgarian Indian English English (for USA) U.K.
Lenovo ideapad 500-14ISK/ideapad 500-15ISK Hardware Maintenance Manual Table 7. Parts list—Keyboard (continued) Language P/N Sunrex Backlight ideapad 500-15ISK Darfon Backlight 100 Hungarian Four Nordic countries Belgian Icelandic Slovenian Swiss International English Czechoslovakian Bulgarian Indian French-Arabic English English (for USA) U.K.
Lenovo ideapad 500-14ISK/ideapad 500-15ISK Miscellaneous parts Table 8. Parts list—Miscellaneous parts FRU FRU no.
Lenovo ideapad 500-14ISK/ideapad 500-15ISK Hardware Maintenance Manual AC adapters Table 9. Parts list—3-pin AC adapters FRU FRU no. Delta ADLX45NDC3A 20V2.25A adap DOE Liteon ADLX45DLC3A 20V2.25A adap DOE Chicony ADLX45NCC3A 20V2.25A adap DOE Acbel ADLX45NAC3A 20V2.25A adap Liteon ADLX45DLC3A 20V2.25A adap DOE Chicony ADLX45NCC3A 20V2.25A adap DOE Delta ADLX45NDC3A 20V2.25A adap DOE Liteon ADLX45DLC3A 20V2.25A adap DOE Chicony ADLX45NCC3A 20V2.25A adap DOE Chicony ADLX65NCC3A 20V3.
Lenovo ideapad 500-14ISK/ideapad 500-15ISK Power cords A Lenovo power cord for a specific country or region is usually available only in that country or region: Table 11.
Lenovo ideapad 500-14ISK/ideapad 500-15ISK Hardware Maintenance Manual Table 11.
Lenovo ideapad 500-14ISK/ideapad 500-15ISK Table 11. Parts list—3-pin power cords (continued) Region Argentina 3PIN • VOLEX VA2073+H03VV-F+VAC5S 1m Brazil 3PIN • VOLEX CH10S3+H03VV-F+VAC5S 1m Israel 3PIN • VOLEX SI16S3+H03VV-F+VAC5S 1m CE 3PIN • VOLEX M2511+HO3VV-F+VAC5S 1m UK • lux 0031+H03VV-F 0.75/3C+0011 1m Europe • lux 0033+H03VV-F 0.75/3C+0011 1m US • lux 0014+SPT-2 60°C 18/3C+0016 1m China • lux 0036+RVV 300/300 0.75/3C+0002 1m Indian • lux 0046+IS694 0.75/3C+0011 1m Japan • lux 0018(E)+VCTF 0.
Lenovo ideapad 500-14ISK/ideapad 500-15ISK Hardware Maintenance Manual Notices Lenovo may not offer the products, services, or features discussed in this document in all countries. Consult your local Lenovo representative for information on the products and services currently available in your area. Any reference to a Lenovo product, program, or service is not intended to state or imply that only that Lenovo product, program, or service may be used.
Notices Any performance data contained herein was determined in a controlled environment. Therefore, the result obtained in other operating environments may vary significantly. Some measurements may have been made on development-level systems and there is no guarantee that these measurements will be the same on generally available systems. Furthermore, some measurements may have been estimated through extrapolation. Actual results may vary.
