Hardware Maintenance Manual Machine Types: 6393, 6394, 6395, 6396, and 6397
Hardware Maintenance Manual Machine Types: 6393, 6394, 6395, 6396, and 6397
Note: Before using this information and the product it supports, be sure to read the information under Appendix A “Notices” on page 143. Eighth Edition (September 2010) © Copyright Lenovo 2005, 2010. LENOVO products, data, computer software, and services have been developed exclusively at private expense and are sold to governmental entities as commercial items as defined by 48 C.F.R. 2.101 with limited and restricted rights to use, reproduction and disclosure.
Contents Chapter 1. About this manual . . . . . 1 device . . . . . . . . . . . . . . . 41 41 41 Chapter 2. Safety information . . . . . 3 Chapter 7. Symptom-to-FRU Index . 43 General safety . . . . . . . . . . . . Electrical safety . . . . . . . . . . . Safety inspection guide . . . . . . . . Handling electrostatic discharge-sensitive devices . . . . . . . . . . . . . . Grounding requirements . . . . . . . . Safety notices (multi-lingual translations) . Hard disk drive boot error . .
Updating (flashing) BIOS from a CD-ROM or diskette . . . . . . . . . . . . . . . . Recovering from a POST/BIOS update failure . Power management . . . . . . . . . . . Automatic configuration and power interface (ACPI) BIOS . . . . . . . . . . . . . vi Hardware Maintenance Manual Automatic Power-On features . . . . . . . . . . 139 140 140 . 141 Appendix A. Notices . . . . . . . . Television output notice . . . . . . . . . . . Trademarks . . . . . . . . . . . . . . . .
Chapter 1. About this manual This manual contains service and reference information for ThinkCentre® computers listed on the cover. It is intended only for trained servicers who are familiar with Lenovo® computer products. Before servicing a Lenovo product, be sure to read the Safety Information. See Chapter 2 “Safety information” on page 3. This manual includes a complete Field Replaceable Unit (FRU) part number listing for each machine type listed on the cover.
Note: RoHS and non-RoHS FRU part numbers with the same fit and function are identified with unique FRU part numbers. Lenovo plans to transition to RoHS compliance well before the implementation date and expects its suppliers to be ready to support Lenovo's requirements and schedule in the EU. Products sold in 2005, will contain some RoHS compliant FRUs. The following statement pertains to these products and any product Lenovo produces containing RoHS compliant parts.
Chapter 2. Safety information This chapter contains the safety information that you need to be familiar with before servicing a computer. General safety Follow these rules to ensure general safety: • Observe good housekeeping in the area of the machines during and after maintenance. • When lifting any heavy object: 1. Ensure you can stand safely without slipping. 2. Distribute the weight of the object equally between your feet. 3. Use a slow lifting force.
Important: Use only approved tools and test equipment. Some hand tools have handles covered with a soft material that does not insulate you when working with live electrical currents. Many customers have, near their equipment, rubber floor mats that contain small conductive fibers to decrease electrostatic discharges. Do not use this type of mat to protect yourself from electrical shock. • Find the room emergency power-off (EPO) switch, disconnecting switch, or electrical outlet.
Safety inspection guide The intent of this inspection guide is to assist you in identifying potentially unsafe conditions on these products. Each machine, as it was designed and built, had required safety items installed to protect users and service personnel from injury. This guide addresses only those items. However, good judgment should be used to identify potential safety hazards due to attachment of features or options not covered by this inspection guide.
• Wear a grounded wrist strap against your skin to eliminate static on your body. • Prevent the part from touching your clothing. Most clothing is insulative and retains a charge even when you are wearing a wrist strap. • Use the black side of a grounded work mat to provide a static-free work surface. The mat is especially useful when handling ESD-sensitive devices. • Select a grounding system, such as those listed below, to provide protection that meets the specific service requirement.
• When possible, use one hand only to connect or disconnect signal cables. • Never turn on any equipment when there is evidence of fire, water, or structural damage. • Disconnect the attached power cords, telecommunications systems, networks, and modems before you open the device covers, unless instructed otherwise in the installation and configuration procedures.
≥18 kg (37 lbs) ≥32 kg (70.5 lbs) ≥55 kg (121.2 lbs) CAUTION: Use safe practices when lifting. CAUTION: The power control button on the device and the power switch on the power supply do not turn off the electrical current supplied to the device. The device also might have more than one power cord. To remove all electrical current from the device, ensure that all power cords are disconnected from the power source.
Chapter 2.
≥18 kg (37 lbs) ≥32 kg (70.5 lbs) ≥55 kg (121.
A corrente elétrica proveniente de cabos de alimentação, de telefone e de comunicações é perigosa. Para evitar risco de choque elétrico: • Não conecte nem desconecte nenhum cabo ou execute instalação, manutenção ou reconfiguração deste produto durante uma tempestade com raios. • Conecte todos os cabos de alimentação a tomadas elétricas corretamente instaladas e aterradas. • Todo equipamento que for conectado a este produto deve ser conectado a tomadas corretamente instaladas.
• Não remova as tampas. A remoção das tampas de um produto a laser pode resultar em exposição prejudicial à radiação de laser. Não existem peças que podem ser consertadas no interior do dispositivo. • A utilização de controles ou ajustes ou a execução de procedimentos diferentes dos especificados aqui pode resultar em exposição prejudicial à radiação. PERIGO Alguns produtos a laser contêm diodo de laser integrado da Classe 3A ou da Classe 3B. Observe o seguinte: Radiação a laser quando aberto.
Chapter 2.
2 1 14 Hardware Maintenance Manual
Chapter 2.
2 1 DANGER Le courant électrique provenant de l'alimentation, du téléphone et des câbles de transmission peut présenter un danger. Pour éviter tout risque de choc électrique : • Ne manipulez aucun câble et n'effectuez aucune opération d'installation, d'entretien ou de reconfiguration de ce produit au cours d'un orage. • Branchez tous les cordons d'alimentation sur un socle de prise de courant correctement câblé et mis à la terre.
Connexion Déconnexion 1. Mettez les unités HORS TENSION. 1. Mettez les unités HORS TENSION. 2. Commencez par brancher tous les cordons sur les unités. 2. Débranchez les cordons d'alimentation des prises. 3. Branchez les câbles d'interface sur des connecteurs. 4. Débranchez tous les câbles des unités. 3. Débranchez les câbles d'interface des connecteurs. 4. Branchez les cordons d'alimentation sur des prises. 5. Mettez les unités SOUS TENSION.
≥18 kg (37 lbs) ≥32 kg (70.5 lbs) ≥55 kg (121.2 lbs) ATTENTION: Soulevez la machine avec précaution. ATTENTION: L'interrupteur de contrôle d'alimentation de l'unité et l'interrupteur dubloc d'alimentation ne coupent pas le courant électrique alimentantl'unité. En outre, le système peut être équipé de plusieurs cordonsd'alimentation. Pour mettre l'unité hors tension, vous devez déconnectertous les cordons de la source d'alimentation.
• Die Verbindung zu den angeschlossenen Netzkabeln, Telekommunikationssystemen, Netzwerken und Modems ist vor dem Öffnen des Gehäuses zu unterbrechen, sofern in den Installations- und Konfigurationsprozeduren keine anders lautenden Anweisungen enthalten sind. • Zum Installieren, Transportieren und Öffnen der Abdeckungen des Computers oder der angeschlossenen Einheiten die Kabel gemäß der folgenden Tabelle anschließen und abziehen.
Laserstrahlung bei geöffneter Verkleidung. Nicht in den Strahl blicken. Keine Lupen oder Spiegel verwenden. Strahlungsbereich meiden. ≥18 kg (37 lbs) ≥32 kg (70.5 lbs) ≥55 kg (121.2 lbs) ACHTUNG: Arbeitsschutzrichtlinien beim Anheben der Maschine beachten. ACHTUNG: Mit dem Netzschalter an der Einheit und am Netzteil wird die Stromversorgung für die Einheit nicht unterbrochen. Die Einheit kann auch mit mehreren Netzkabeln ausgestattet sein.
Chapter 2.
2 1 PERICOLO La corrente elettrica proveniente dai cavi di alimentazione, del telefono e di comunicazione può essere pericolosa. Per evitare il rischio di scosse elettriche: • Non collegare o scollegare qualsiasi cavo oppure effettuare l'installazione, la manutenzione o la riconfigurazione del prodotto durante un temporale. • Collegare tutti i fili elettrici a una presa di alimentazione correttamente cablata e dotata di messa a terra.
• Se possibile, utilizzare solo una mano per collegare o scollegare i cavi di segnale. • Non accendere assolutamente apparecchiature in presenza di incendi, perdite d'acqua o danno strutturale. • Scollegare i cavi di alimentazione, i sistemi di telecomunicazione, le reti e il modem prima di aprire i coperchi del dispositivo, salvo istruzioni contrarie relative alle procedure di installazione e configurazione.
PERICOLO Alcune unità laser contengono un diodo laser di Classe 3A o Classe 3B. Tener presente quanto segue: Aprendo l'unità vengono emesse radiazioni laser. Non fissare il fascio, non guardarlo direttamente con strumenti ottici ed evitare l'esposizione al fascio. ≥18 kg (37 lbs) ≥32 kg (70.5 lbs) ≥55 kg (121.2 lbs) ATTENZIONE: Prestare attenzione nel sollevare l'apparecchiatura.
Chapter 2.
2 1 PELIGRO La corriente eléctrica procedente de cables de alimentación, teléfonos y cables de comunicación puede ser peligrosa. Para evitar el riesgo de descarga eléctrica: • No conecte ni desconecte los cables ni realice ninguna tarea de instalación, mantenimiento o reconfiguración de este producto durante una tormenta eléctrica. • Conecte todos los cables de alimentación a tomas de corriente debidamente cableadas y conectadas a tierra.
• Desconecte los cables de alimentación, los sistemas de telecomunicaciones, las redes y los módems conectados antes de abrir las cubiertas de los dispositivos, a menos que se indique lo contrario en los procedimientos de instalación y configuración. • Conecte y desconecte los cables, como se describe en la tabla siguiente, cuando instale, mueva o abra las cubiertas de este producto o de los dispositivos conectados. Para conectar Para desconectar 1. APÁGUELO todo. 1. APÁGUELO todo. 2.
Algunos productos láser tienen incorporado un diodo láser de clase 3A o clase 3B. Tenga en cuenta lo siguiente: Cuando se abre, queda expuesto a radiación láser. No mire directamente al rayo láser, ni siquiera con instrumentos ópticos, y evite exponerse directamente al rayo láser. ≥18 kg (37 lbs) ≥32 kg (70.5 lbs) ≥55 kg (121.2 lbs) PRECAUCIÓN: Adopte procedimientos seguros al levantar el equipo.
Chapter 3. General information This chapter provides general information that applies to all machine types supported by this publication. The ThinkVantage Productivity Center program Use the ThinkVantage® Productivity Center program for general information about the use, operation, and maintenance of the computer. The ThinkVantage Productivity Center program also contains information to help solve problems and get repair service or other technical assistance.
Dimensions Width: 275 mm (10.83 in.) Height: 81 mm (3.19 in.) Depth: 242 mm (9.53 in.) Weight Note: The weight does not include the power supply or any external cables. Minimum configuration as shipped: 3.27 kg (7.2 lbs) Maximum configuration: 3.72 kg (8.2 lbs) Environment • Air temperature: – Operating at 0 - 3000 ft (914.4 m): 10° to 35°C (50° to 95°F) – Non-operating: -40° to 60°C (-40° to 140°F) – Maximum altitude: 3000 ft (914.4 m) Note: The maximum altitude, 3000 ft. (914.
Chapter 4. General Checkout Attention The drives in the computer you are servicing might have been rearranged or the drive startup sequence changed. Be extremely careful during write operations such as copying, saving, or formatting. Data or programs can be overwritten if you select an incorrect drive. General error messages appear if a problem or conflict is found by an application program, the operating system, or both.
5. Check the power cord continuity. 6. Replace the AC/DC power adapter. 7. Verify that the power cord from the AC/DC power adapter to the computer is properly connected. See “Connectors on the rear of the computer” on page 66. 8. Open the cover. See “Opening the cover” on page 68. 9. Check the Power switch/LED assembly connector on the system board. See “System board locations” on page 68. Reseat the cable from the Power switch/LED assembly to the system board. 10. Replace the power switch/LED assembly. 11.
Chapter 5. Diagnostics Diagnostic programs are used to test hardware components of your computer and report operating-system-controlled settings that can cause hardware failures. There are two diagnostic programs preinstalled on your computer to help you diagnose problems: • PC-Doctor for Windows (used when diagnosing problems while running the Windows operating system) • PC-Doctor for Windows PE (used when your Windows operating system will not start) Notes: 1.
6. Follow the instructions on the screen. Note: Rescue media includes PC-Doctor for Windows PE. For more information about rescue media, see the User Guide for the computer. PC-Doctor for DOS Use PC-Doctor for DOS, if you are unable to start the Windows operating system or if PC-Doctor for Windows has not been successful in isolating a possible problem. You can run PC-Doctor for DOS from a diagnostic CD image or diagnostic diskettes that have been created.
3. Insert the CD into the optical drive or the first diagnostic diskette into the diskette drive. 4. Restart the computer. Note: If the diagnostic program does not start, you might not have your optical drive or diskette drive set as a startable device. See “Selecting a startup device” on page 40 for instructions on how to change the startup device. 5. When the diagnostics program opens, follow the instructions on the screen.
• Function Code: Represents the feature or function within the PC. • Failure Type: Represents the type of error encountered. • DeviceID: Contains the component's unit-ID which corresponds to either a fixed disk drive, removable media drive, processor, specific RIMM, or a device on the PCI bus. • Date: Contains the date when the diagnostic test was run. The date is retrieved from CMOS and displayed using the YYYYMMDD format.
To view details of a failure or to view a list of test results, use the following procedure from any test category screen: 1. Press F3 to activate the log file. 2. Press F3 again to save the file to diskette or press F2 to print the file. Chapter 5.
38 Hardware Maintenance Manual
Chapter 6. Using the Setup Utility The Setup Utility program is used to view and change the configuration settings of the computer, regardless of which operating system you are using. However, the operating-system settings might override any similar settings in the Setup Utility program. Starting the Setup Utility program To start the Setup Utility program, do the following: 1. If the computer is already on when you start this procedure, shut down the operating system and turn off the computer. 2.
• Setup Utility program and hard disk drive passwords are not case sensitive • Not be your name or your user name • Not be a common word or a common name • Be significantly different from your previous password User Password When a User Password is set, the computer cannot be used until a valid password is typed from the keyboard. Administrator Password When an Administrator Password is set, it deters unauthorized persons from changing configuration settings.
Selecting or changing the startup device sequence To view or permanently change the configured startup device sequence, do the following: 1. Start the Setup Utility program (see “Starting the Setup Utility program” on page 39). 2. Select Startup. 3. Select Startup Sequence. See the information displayed on the right side of the screen. 4. Select the devices for the Primary Startup Sequence, the Automatic Startup Sequence, and the Error Startup Sequence. 5.
42 Hardware Maintenance Manual
Chapter 7. Symptom-to-FRU Index The Symptom-to-FRU index lists error symptoms and possible causes. The most likely cause is listed first. Always begin with Chapter 4 “General Checkout” on page 31. This index can also be used to help you decide which FRUs to have available when servicing a computer. If you are unable to correct the problem using this index, go to “Undetermined problems” on page 62. Notes: • If you have both an error message and an incorrect audio response, diagnose the error message first.
Diagnostic Error Code FRU/Action 000-026-XXX FLASH data error 1. Flash the system. See “Updating (flashing) BIOS from a CD-ROM or diskette” on page 139 2. System board 000-027-XXX BIOS Configuration/Setup error 1. Run Setup 2. Flash the system. See “Updating (flashing) BIOS from a CD-ROM or diskette” on page 139 3. System board 000-034-XXX BIOS Buffer Allocation failure 1. Reboot the system 2. Flash the system. See “Updating (flashing) BIOS from a CD-ROM or diskette” on page 139 3. Run memory test 4.
Diagnostic Error Code FRU/Action 000-250-XXX BIOS APM failure 1. Flash the system. See “Updating (flashing) BIOS from a CD-ROM or diskette” on page 139 2. System board 000-270-XXX BIOS ACPI failure 1. Flash the system. See “Updating (flashing) BIOS from a CD-ROM or diskette” on page 139 2.
Diagnostic Error Code FRU/Action 001-197-XXX System test warning 1. Make sure the component that is called out is connected and/or enabled. See Chapter 6 “Diagnostics, Test and Recovery Information” on page 39 2. Re-run test 3. Replace the component that is called out in warning statement 4. Replace the component under test 001-198-XXX System test aborted 1. If a component is called out, make sure it is connected and/or enabled. See Chapter 6 “Diagnostics, Test and Recovery Information” on page 39 2.
Diagnostic Error Code FRU/Action 001-278-XXX System IRQ11 failure 1. Device on IRQ11 2. System board 001-279-XXX System IRQ12 failure 1. Device on IRQ12 2. System board 001-280-XXX System IRQ13 failure 1. Device on IRQ13 2. System board 001-281-XXX System IRQ14 (hard disk drive) failure 1. Hard disk drive cable 2. Hard disk drive 3. System board 001-282-XXX System IRQ15 failure 1. Device on IRQ15 2.
Diagnostic Error Code FRU/Action 005-031-XXX Video Device Cable failure 1. Video cable 2. Monitor 3. Video card, if installed 4. System board 005-032-XXX Video Device Controller failure 1. Video card, if installed 2. System board 005-036-XXX Video Register error 1. Video card, if installed 2. System board 005-038-XXX System BIOS extension failure 1. Video card, if installed 2. System board 005-040-XXX Video IRQ failure 1. Video card, if installed 2.
Diagnostic Error Code FRU/Action 006-197-XXX Diskette interface test warning 1. If a component is called out, make sure it is connected and/or enabled 2. Re-run test 3. Replace the component that is called out in warning statement 4. Replace the component under test 006-198-XXX Diskette interface test aborted 1. If a component is called out, make sure it is connected and/or enabled 2. Flash the system and re-test. See “Updating (flashing) BIOS from a CD-ROM or diskette” on page 139 3.
Diagnostic Error Code FRU/Action 015-197-XXX USB port test warning 1. Make sure the component that is called out is connected and/or enabled. See Chapter 6 “Diagnostics, Test and Recovery Information” on page 39 2. Re-run test 3. Replace the component that is called out in warning statement 4. Replace the component under test 015-198-XXX USB port test aborted 1. If a component is called out, make sure it is connected and/or enabled.
Diagnostic Error Code FRU/Action 018-250-XXX PCI Card Services error 1. PCI card 2. Riser card, if installed 3. System board 020-000-XXX PCI Interface Test Passed No action 020-0XX-XXX PCI Interface error 1. PCI card 2. Riser card, if installed 3. System board 020-195-XXX PCI Test aborted by user Information only Re-start the test, if necessary 020-196-XXX PCI test halt, error threshold exceeded 1. Press F3 to review the log file 2.
Diagnostic Error Code FRU/Action 025-02X-XXX 025-03X-XXX 025-04X-XXX IDE Interface failure 1. IDE signal cable 2. Check AC/DC power adapter 3. Reseat IDE signal cable 4. IDE device 5. System board 025-195-XXX IDE interface Test aborted by user Information only Re-start the test, if necessary 025-196-XXX IDE interface test halt, error threshold exceeded 1. Press F3 to review the log file 025-197-XXX IDE interface test warning 1. Make sure the component that is called out is connected and/or enabled.
Diagnostic Error Code FRU/Action 030-195-XXX SCSI interface Test aborted by user Information only Re-start the test, if necessary 030-196-XXX SCSI interface test halt, error threshold exceeded 1. Press F3 to review the log file 030-197-XXX SCSI interface test warning 1. Make sure the component that is called out is connected and/or enabled. See Chapter 6 “Diagnostics, Test and Recovery Information” on page 39 2. Re-start the test to reset the log file 2. Re-run test 3.
Diagnostic Error Code FRU/Action 035-199-XXX RAID interface test failed, cause unknown 1. See “Undetermined problems” on page 62 2. Flash the system and re-test. See “Updating (flashing) BIOS from a CD-ROM or diskette” on page 139 3. Replace component under function test 071-000-XXX Audio port Interface Test Passed No action 071-00X-XXX 071-01X-XXX 071-02X-XXXAudio port error 1. Run Setup 2. Flash the system. See “Updating (flashing) BIOS from a CD-ROM or diskette” on page 139 3.
Diagnostic Error Code FRU/Action 080-196-XXX Game Port interface test halt, error threshold exceeded 1. Press F3 to review the log file 080-197-XXX Game Port interface test warning 1. Make sure the component that is called out is connected and/or enabled. See Chapter 6 “Diagnostics, Test and Recovery Information” on page 39 2. Re-start the test to reset the log file 2. Re-run test 3. Replace the component that is called out in warning statement 4.
Diagnostic Error Code FRU/Action 086-198-XXX Mouse Port interface test aborted 1. If a component is called out, make sure it is connected and/or enabled. See Chapter 6 “Diagnostics, Test and Recovery Information” on page 39 2. Flash the system and re-test. See “Updating (flashing) BIOS from a CD-ROM or diskette” on page 139 3. Go to “Undetermined problems” on page 62 086-199-XXX Mouse Port interface test failed, cause unknown 1. See “Undetermined problems” on page 62 2. Flash the system and re-test.
Diagnostic Error Code FRU/Action 170-197-XXX Voltage Sensor(s) test warning 1. Make sure the component that is called out is connected and/or enabled. See Chapter 6 “Diagnostics, Test and Recovery Information” on page 39 2. Re-run test 3. Replace the component that is called out in warning statement 4. Replace the component under test 170-198-XXX Voltage Sensor(s) test aborted 1. If a component is called out, make sure it is connected and/or enabled.
Diagnostic Error Code FRU/Action 175-199-XXX Thermal Sensor(s) test failed, cause unknown 1. See “Undetermined problems” on page 62 2. Flash the system and re-test. See “Updating (flashing) BIOS from a CD-ROM or diskette” on page 139 3. Replace component under function test 175-250-XXX 175-251-XXX Thermal Sensor(s) limit error 1. Check fans 2. Check AC/DC power adapter voltages 3. Microprocessor 4. System board 185-000-XXX Asset Security Test Passed No action 185-XXX-XXX Asset Security failure 1.
Diagnostic Error Code FRU/Action 217-28X-XXX 217-29X-XXX Hard Disk Drive (SCSI) error 1. Hard Disk Drive Cable 2. Check AC/DC power adapter voltages 3. Reseat the hard disk drive cable 4. Hard Disk drive (SCSI) 5. SCSI adapter card 6. System board 220-000-XXX Hi-Capacity Cartridge Drive Test Passed No action 220-XXX-XXX Hi-Capacity Cartridge Drive error 1. Remove the Hi-Capacity Cartridge Drive and re-test the system 301-XXX-XXX Keyboard error 1. Keyboard 2. Check and test mouse 3.
POST error codes Each time you power-on the system, it performs a series of tests that check the operation of the system and some options. This series of tests is called the Power-On Self-Test, or POST. POST does the following operations. • Checks some basic system-board operations • Checks the memory operation • Starts the video operation • Verifies that the boot drive is working If the POST detects a problem, an error message appears on the screen.
POST Error Message Description/Action Press TAB to show POST screen Pressing the TAB key permits the user to toggle between the default POST display screen and a custom POST display screen. Error: Non-System disk or disk error Replace and press any key when ready The BIOS was unable to find a suitable boot device. Make sure the boot drive is properly connected to the computer. Make sure you have bootable media.
Message/Symptom FRU/Action "Insert a Diskette" icon appears with a known-good diagnostics diskette in the first 3.5-inch diskette drive. 1. System Board 2. Diskette Drive Cable 3. Network Adapter Intensity or color varies from left to right of characters and color bars 1. Display 2. Video adapter (if present) 3. System Board No power or fan not running 1. See “Power problems” on page 31. Non-system disk or disk error-type message with a known-good diagnostic diskette. 1. Diskette Drive 2.
4. Repeat steps 1 through 3 until you find the failing device or adapter. If all devices and adapters have been removed, and the problem continues, replace the system board. Chapter 7.
64 Hardware Maintenance Manual
Chapter 8. Replacing FRUs This chapter provides step-by-step instructions for replacing major FRUs. Important Before you replace any FRU, read Chapter 2 “Safety information” on page 3. These precautions and guidelines will help you work safely. FRU replacements are to be done by trained service technicians only. Locations This section provides illustrations to help locate the various connectors, controls, and components of the computer.
Connectors on the rear of the computer 1 USB connector 8 Microphone connector 2 Ethernet connector 9 USB connectors (3) 3 Audio line in connector 10 Video graphics array (VGA) monitor connector 4 Serial connector 11 Digital video interface (DVI) monitor connector 5 RJ11 modem connector 12 Power adapter connector 6 ExpressCard (PCIe x 1) connector 13 Cable lock latch 7 Audio line out connector Locating components This section shows the location of the various components in the comp
1 Front Audio/USB assembly 8 Microprocessor 2 Hard disk drive 9 Heat sink 3 System fan assembly 10 Side cover 4 Optical drive 11 Memory modules 5 AC/DC Power Adapter 12 Internal speaker 6 Express Card assembly 13 Media Card Reader Chapter 8.
7 System board System board locations 1 Microprocessor and heat sink 10 ExpressCard USB connector 2 Modem daughter card (MDC) connector 11 ExpressCard PCIe connector 3 Battery 12 Clear CMOS/Recovery jumper 4 Thermal sense cable connector 13 Media card reader connector 5 Memory connectors (2) 14 Internal speaker connector 6 Serial (COM) connector 15 Front audio connector 7 Front panel connector 16 Rear USB connector 8 Front USB connector 17 Fan connector 9 SATA IDE connecto
Turn off the computer and wait 3 to 5 minutes to let the computer cool before opening the computer cover. This section provides instructions on how to open the computer cover. 1. Remove any media (diskettes, CDs, or tapes) from the drives, shut down your operating system, and turn off all attached devices and the computer. 2. Unplug all power cords from electrical outlets. 3. Disconnect the cables attached to the computer.
4. Install the new battery. 5. Close the computer cover, and connect all the cables. See “Completing the FRU replacement” on page 81. Note: When the computer is turned on for the first time after battery replacement, an error message might be displayed. This is normal after replacing the battery. 6. Turn on the computer and all attached devices. 7. Use the Setup Utility program to set the date and time and any passwords. See Chapter 6 “Diagnostics, Test and Recovery Information” on page 39.
Notes: a. Your microprocessor and socket might look different than the one illustrated. b. Note the orientation of the microprocessor in the socket. Look for the small triangle on one corner of the microprocessor. This is important when reinstalling the microprocessor on the system board. c. Do not drop anything onto the microprocessor socket while it is exposed. The socket pins must be kept as clean as possible. 6.
Note: Install the black protective cover that was removed from the new microprocessor onto the defective microprocessor after the installation is complete. 10. Secure the microprocessor in the socket by pivoting the small handle downward. Be sure to lock it into position. 11. Position the heat sink on the retention module so that the four screws are aligned with the posts on the system board. Tighten the four screws to secure the heat sink to the system board. 12.
6. If the system board has a modem daughter card installed, remove it from the failing system board and install it on the new system board. See “Replacing the modem” on page 76. 7. Remove the heat sink and microprocessor from the failing system board and install them on the new system board. See “Replacing the microprocessor” on page 70. Note: You might have to install a new retention module on the new system board. 8.
8. Connect the signal and power cables to the rear of the new hard disk drive. 9. Slide the new hard disk drive into the drive bay until it snaps into position. 10. Reconnect the power cable to the optical drive. 11. Go to “Completing the FRU replacement” on page 81. Replacing an optical drive This section provides instructions on how to replace an optical drive. 1. Open the computer cover. See “Opening the cover” on page 68. 2.
5. Remove the retainer bracket from the failing drive and install it on the new optical drive. 6. Slide the new optical drive into the drive bay until it snaps into position. 7. Connect the signal and power cables to the drive. 8. Replace the front bezel. 9. Go to “Completing the FRU replacement” on page 81. Replacing a memory module This section provides instructions on how to replace a memory module. 1. Open the computer cover. See “Opening the cover” on page 68. 2. Locate the memory connector.
4. Insert the notched end 2 of the memory module into the socket 1 . Press the memory module firmly, and pivot the memory module until it snaps into place. Make sure that the memory module is firmly fixed in the connector and does not move easily. 5. Go to “Completing the FRU replacement” on page 81. Replacing the modem This section provides instructions on how to replace the modem. 1. Open the computer cover. See “Opening the cover” on page 68. 2. Locate the MDC connector.
3. Remove the two screws that secure the modem card to the system board. 4. Disconnect the modem card from the system board. 5. Disconnect the RJ11 modem cable from the modem card. 6. Connect the RJ11 modem cable to the new modem card. 7. Install the new modem card to the MDC connector on the system board by aligning the holes in the modem card with the pins in the system board. 8. Install the two screws to secure the modem card to the system board. 9. Go to “Completing the FRU replacement” on page 81.
3. Disconnect the cable connected to the Express card. 4. Remove the four screws that secure the Express card assembly to the Chassis. 5. Remove the Express card assembly from the system board. 6. Install the new Express card assembly into the chassis by aligning the holes in the Express card assembly with the pins in the chassis. 7. Install the four screws to secure the Express card assembly to the chassis. 8. Reconnect the cable to the Express card assembly. 9.
5. Remove the Media Card Reader from the chassis. 6. Install the new Media Card Reader into the chassis and align the screw-hole in the Media Card Reader with the hole in the chassis. 7. Install the screw to secure the Media Card Reader to the chassis. 8. Connect the Media Card Reader cable to the system board. 9. Go to “Completing the FRU replacement” on page 81. Replacing the system fan assembly This section provides instructions on how to replace the system fan assembly.
7. When installing your new system fan assembly, use the new rubber mounts that come with the new system fan. 8. Install the two short rubber mounts in the new system fan assembly as shown. 9. Install the two long rubber mounts into the rear of the chassis as shown. Push the mounts through the holes of the chassis. If necessary, pull the mounts through the holes from inside the chassis. 10.
Completing the FRU replacement After replacing the parts, you need to close the cover and reconnect cables, including telephone lines and power cords. Also, depending on the part that was replaced, you might need to confirm the updated information in the Setup Utility program. See Chapter 6 “Diagnostics, Test and Recovery Information” on page 39. This section provides instructions on how to complete the parts replacement. 1.
4. If a cover lock is installed, lock the cover. 5. Reconnect the external cables and power cords to the computer. See “Connectors on the rear of the computer” on page 66. 6. To update your configuration, see Chapter 6 “Diagnostics, Test and Recovery Information” on page 39.
Chapter 9. FRU lists Attention: Read “Important information about replacing RoHS compliant FRUs” on page 1 before replacing any FRUs. Note: In the following tables, a CRU (Customer Replaceable Unit) is identified as either "1", "2", or "N" in the CRU column. "N" means that the part is not a CRU, "1" means that the part is a Self-service CRU, and "2" means that the part is an Optional-service CRU.
Item # 6393 FRUs FRU# CRU 2 Hard disk drive, 1TB 7200rpm SATA (models CTO) 45C5973 2 3 System fan (all models) 41R8511 2 4 DVD-ROM Drive - 16x/48x - SATA (models 12Q 14C 14V 11S 11D 11Y 15S 15D 15Y 15Q 15C 16Q 17S 17Y) 41N3325 2 4 DVD-ROM Drive - DVD-RW/CD-RW Rambo 8 (SATA) Matrix (models) 43C1042 2 4 DVD-ROM Drive - DVD-ROM/CD-RW Combo Drive - 48x/32x/48x/16x - SATA Matrix (models 13B 13H 18S 18Y) 42Y9353 2 5 Power Adapter, 120W AC/DC (models 12Q 14C 14V 11S 11D 11Y 13B 13H 15S 15D
6393 FRUs FRU# CRU Hard Disk Drive tray (all models) 41R8518 2 Shield Kit (all models) 41R8543 N Cable, C2 Swtich/Housing assembly (all models) 41R8544 N Cable, Serial (all models) 41R8548 N USB Cable (all models) 41R8560 N PWR/LED Cable Assembly (all models) 41R8555 N FRU# CRU US English (models 12Q 15Q 16Q) 41A5289 1 Arabic(models) 41A5290 1 Arabic/French (models) 41A5291 1 Belgian/French (models) 41A5292 1 Belgian/UK (models) 41A5293 1 Brazilian (models) 41A5294 1
6393 Keyboards (USB Preferred Pro) FRU# CRU Slovak (models) 41A5320 1 Spanish (models 11S 11D 11Y 15S 15D 15Y 17S 17Y 18S 18Y) 41A5321 1 Swedish/Finn (models) 41A5322 1 Swiss (models) 41A5323 1 Thailand (models) 41A5324 1 Turkish 440 (models) 41A5325 1 Turkish 179 (models) 41A5326 1 UK English (models) 41A5327 1 US Euro (models) 41A5328 1 Slovenian (models) 41A5329 1 FRU# CRU US (models) 41A5248 1 Arabic (models) 41A5249 1 Arabic/French (models) 41A5250 1 Belgian/
6393 Keyboard (USB Preferred Pro Fingerprint Keyboard) FRU# CRU Romanian 446 (models) 41A5276 1 Romanian 96 (models) 41A5275 1 Russian/Cyrilic (models) 41A5277 1 Serbian/Cyrilic (models) 41A5278 1 Slovak (models) 41A5279 1 Spanish (models) 41A5280 1 Swedish/Finn (models) 41A5281 1 Swiss, F/G (models) 41A5282 1 Thailand (models) 41A5283 1 Turkish 179 (models) 41A5284 1 Turkish 440 (models) 41A5285 1 UK (models) 41A5286 1 US Euro(models) 41A5287 1 Slovenian (models)
6393 Power Cords FRU# CRU Power cord - Italy (models) 42T5047 1 Power cord - Australia / New Zealand (models) 42T5050 1 Power cord - South Africa (models) 42T5056 1 Power cord - Israel (models) 42T5062 1 Power cord - China (PRC) (models 14C 15C) 42T5065 1 Power cord - Taiwan (models) 42T5071 1 Power cord - Korea (models) 42T5077 1 Power cord - India (models 12Q 15Q 16Q) 42T5083 1 Power cord - Thailand (models) 42T4406 1 Power cord - US/Canada--optional second source (models 11S
6393 Windows XP Home Recovery CDs FRU# CRU FI (models) 45R6017 1 NO (models) 45R6012 1 PL (models) 45R6019 1 PO (models) 45R6030 1 RU (models) 45R6021 1 RE (models) 45R6029 1 HU (models) 45R6023 1 CZ (models) 45R6016 1 TR (models) 45R6022 1 GK (models) 45R6024 1 Japanese (models) 45R6011 1 Simplified Chinese (models) 45R6025 1 Taiwan-TC (models) 45R6026 1 Hong Kong-TC (models) 45R6027 1 Korea (models) 45R6028 1 FRU# CRU US/UK/AP/TH (models) 45R5979 1 FR/C
6393 Windows XP Pro Recovery CDs FRU# CRU Simplified Chinese (models) 45R5999 1 Taiwan-TC (models) 45R6000 1 Hong Kong-TC (models) 45R6001 1 Korea (models) 45R6002 1 Multilingual 1 XP-P -- EN, NL, FR, GR, IT (models) 45R5977 1 Multilingual 2 XP-P -- EN, DK, FI, NO, SV (models) 45R5978 1 FRU# CRU English (models 13H) 46R7098 1 Russian English (models) 46R7099 1 French (models) 46R7100 1 German (models) 46R7101 1 Spanish (models) 46R7102 1 Brazilian (models) 46R7103 1
6393 Vista Business 32 Recovery DVDs FRU# CRU English (models 15Q) 46R7070 1 Russian (models) 46R7071 1 French (models) 46R7072 1 German (models) 46R7073 1 Spanish (models 15S 15D 15Y 17S 17Y 18S 18Y) 46R7074 1 Brazilian (models) 46R7075 1 Italian (models) 46R7076 1 Japanese (models) 46R7077 1 Norwegian (models) 46R7078 1 Swedish (models) 46R1028 1 Danish (models) 46R7079 1 Dutch (models) 46R1030 1 Czech (models) 46R1031 1 Finnish (models) 46R1032 1 Polish (model
6393 Vista Ultimate 32 Recovery DVDs FRU# CRU Japanese (models) 46R7119 1 Norwegian (models) 46R7120 1 Swedish (models) 46R1114 1 Danish (models) 46R7121 1 Dutch (models) 46R1116 1 Czech (models) 46R1117 1 Finnish (models) 46R1118 1 Polish (models) 46R1119 1 Russian (models) 46R7122 1 Turkish (models) 46R1121 1 Hungarian (models) 46R1122 1 Greek (models) 46R1123 1 Simplified Chinese (models) 46R7123 1 Traditional Chinese (models) 46R7124 1 Traditional Chinese (mo
6393 Vista Business 64 Recovery DVDs FRU# CRU Turkish (models) 46R1065 1 Hungarian (models) 46R1066 1 Greek (models) 46R1067 1 Simplified Chinese (models) 46R7095 1 Taiwan (models) 46R7096 1 Hong Kong (models) 46R7097 1 Korea (models) 46R1071 1 Slovenian (models) 46R1072 1 Arabic Localized (models) 46R1073 1 Hebrew (models) 46R1074 1 Portuguese (models) 46R1075 1 Slovakian (models) 46R1076 1 Machine Type 6394 Chapter 9.
Item # 6394 FRUs FRU# CRU 1 Front audio/USB card and cable (included in Cables kit 41R8510) ( models) 41R8510 N 2 Hard disk drive, 80 GB 7200rpm SATA (models) 40Y9034 2 2 Hard disk drive, 160 GB 7200rpm SATA (models) 40Y9035 2 2 Hard disk drive, 25 GB 7200rpm SATA (models) 40Y9036 2 2 Hard disk drive, 320 GB 7200rpm SATA (models) 87H4891 2 2 Hard disk drive, 500 GB 7200rpm SATA (models) 41X5582 2 2 Hard disk drive, 750 GB 7200rpm SATA (models) 43C3671 2 2 Hard disk drive, 1T
The FRUs listed in the following tables are not illustrated.
6394 Keyboards (USB Preferred Pro) FRU# CRU Serbian/Cyrillic (models) 41A5319 1 Slovak (models) 41A5320 1 Spanish (models ) 41A5321 1 Swedish/Finn (models) 41A5322 1 Swiss (models) 41A5323 1 Thailand (models) 41A5324 1 Turkish 440 (models) 41A5325 1 Turkish 179 (models) 41A5326 1 UK English (models) 41A5327 1 US European (models) 41A5328 1 Slovenian (models) 41A5329 1 FRU# CRU US (models) 41A5248 1 Arabic (models) 41A5249 1 Arabic/French (models) 41A5250 1 Belg
6394 Keyboard (USB Preferred Pro Fingerprint Keyboard) FRU# CRU Portuguese (models) 41A5274 1 Romanian 446 (models) 41A5276 1 Romanian 96 (models) 41A5275 1 Russian/Cyrillic (models) 41A5277 1 Serbian/Cyrillic (models) 41A5278 1 Slovak (models) 41A5279 1 Spanish (models) 41A5280 1 Swedish/Finn (models) 41A5281 1 Swiss, F/G (models) 41A5282 1 Thailand (models) 41A5283 1 Turkish 179 (models) 41A5284 1 Turkish 440 (models) 41A5285 1 UK (models) 41A5286 1 US European (m
6394 Power Cords FRU# CRU Power cord - Italy (models) 42T5047 1 Power cord - Australia / New Zealand (models) 42T5050 1 Power cord - South Africa (models) 42T5056 1 Power cord - Israel (models) 42T5062 1 Power cord - China (PRC) (models) 42T5065 1 Power cord - Taiwan (models) 42T5071 1 Power cord - Korea (models) 42T5077 1 Power cord - India (models) 42T5083 1 Power cord - Thailand (models) 42T4406 1 Power cord - US/Canada--optional second source (models) 42T5089 1 Power cor
6394 Windows XP Home Recovery CDs FRU# CRU FI (models) 45R6017 1 NO (models) 45R6012 1 PL (models) 45R6019 1 PO (models) 45R6030 1 RU (models) 45R6021 1 RE (models) 45R6029 1 HU (models) 45R6023 1 CZ (models) 45R6016 1 TR (models) 45R6022 1 GK (models) 45R6024 1 Japanese (models) 45R6011 1 Simplified Chinese (models) 45R6025 1 Taiwan-TC (models) 45R6026 1 Hong Kong-TC (models) 45R6027 1 Korea (models) 45R6028 1 FRU# CRU US/UK/AP/TH (models) 45R5979 1 FR/C
6394 Windows XP Pro Recovery CDs FRU# CRU Simplified Chinese (models) 45R5999 1 Taiwan-TC (models) 45R6000 1 Hong Kong-TC (models) 45R6001 1 Korea (models) 45R6002 1 Multilingual 1 XP-P -- EN, NL, FR, GR, IT (models) 45R5977 1 Multilingual 2 XP-P -- EN, DK, FI, NO, SV (models) 45R5978 1 FRU# CRU English (models 13H) 46R7098 1 Russian English (models) 46R7099 1 French (models) 46R7100 1 German (models) 46R7101 1 Spanish (models) 46R7102 1 Brazilian (models) 46R7103 1
6394 Vista Business 32 Recovery DVDs FRU# CRU English (models 15Q) 46R7070 1 Russian (models) 46R7071 1 French (models) 46R7072 1 German (models) 46R7073 1 Spanish (models 15S 15D 15Y 17S 17Y 18S 18Y) 46R7074 1 Brazilian (models) 46R7075 1 Italian (models) 46R7076 1 Japanese (models) 46R7077 1 Norwegian (models) 46R7078 1 Swedish (models) 46R1028 1 Danish (models) 46R7079 1 Dutch (models) 46R1030 1 Czech (models) 46R1031 1 Finnish (models) 46R1032 1 Polish (model
6394 Vista Ultimate 32 Recovery DVDs FRU# CRU Japanese (models) 46R7119 1 Norwegian (models) 46R7120 1 Swedish (models) 46R1114 1 Danish (models) 46R7121 1 Dutch (models) 46R1116 1 Czech (models) 46R1117 1 Finnish (models) 46R1118 1 Polish (models) 46R1119 1 Russian (models) 46R7122 1 Turkish (models) 46R1121 1 Hungarian (models) 46R1122 1 Greek (models) 46R1123 1 Simplified Chinese (models) 46R7123 1 Traditional Chinese (models) 46R7124 1 Traditional Chinese (mo
6394 Vista Business 64 Recovery DVDs FRU# CRU Turkish (models) 46R1065 1 Hungarian (models) 46R1066 1 Greek (models) 46R1067 1 Simplified Chinese (models) 46R7095 1 Taiwan (models) 46R7096 1 Hong Kong (models) 46R7097 1 Korea (models) 46R1071 1 Slovenian (models) 46R1072 1 Arabic Localized (models) 46R1073 1 Hebrew (models) 46R1074 1 Portuguese (models) 46R1075 1 Slovakian (models) 46R1076 1 FRU# CRU Machine Type 6395 Item # 6395 FRUs 1 Front audio/USB card and c
Item # 6395 FRUs FRU# CRU 2 Hard disk drive, 160 GB 7200rpm SATA (models 14S 14D 14Y 14M 14A 14T 14K 14J 15M 15A 15Q 17U 17F 17S 17D 17Y 17G 17M 17A 17T 17K 17J 18S 18D 18Y 18A 18Q 18T 18C 18B 18H 19S 19A 19Q 19T 19K 19J 21S 21D 21Y 21A 21Q 21T 21B 21H 21V 21K 21J 23U 23F 23S 23L 23D 23Y 23G 23M 23A 23Q 23T 23C 23B 23H 23V 23K 23R 23E 23J 24U 24F 24G 24M 24A 24T 24K 24J 25S 25D 25Y 27U 27F 28U 28F 29U 29F 29S 29L 29D 29Y 29G 29M 29A 29Q 29T 29C 29B 29H 29V 29K 29R 29E 29J 31U 31F 33S 33K 33J 33A 33Q 33
Item # 6395 FRUs FRU# CRU 5 Power Adapter, 120W AC/DC (models 11S 11D 11Y 11A 11T 12S 12D 12Y 12G 13S 13G 13C 13B 13H 14S 14D 14Y 14M 14A 14T 14K 14J 15M 15A 15Q 15T 16S 16G 17U 17F 17S 17D 17Y 17G 17M 17A 17T 17K 17J 18S 18D 18Y 18A 18Q 18T 18C 18B 18H 19S 19A 19Q 19T 19K 19J 21S 21D 21Y 21A 21Q 21T 21B 21H 21V 21K 21J 22B 22H 22V 23U 23F 23S 23L 23D 23Y 23G 23M 23A 23Q 23T 23C 23B 23H 23V 23K 23R 23E 23J 24U 24F 24G 24M 24A 24T 24K 24J 25S 25D 25Y 26U 26F 26M 26A 26Q 26T 26K 26J 27U 27F 28U 28F 29U 2
Item # 6395 FRUs FRU# CRU 7 System board, non-AMT Mini-ITX Intel (Q35, ICH9DO) (models 11S 11D 11Y 11A 11T 12S 12D 12Y 12G 13S 13G 13C 13B 13H 14S 14D 14Y 14M 14A 14T 14K 14J 15M 15A 15Q 15T 16S 16G 17U 17F 17S 17D 17Y 17G 17M 17A 17T 17K 17J 18S 18D 18Y 18A 18Q 18T 18C 18B 18H 19S 19A 19Q 19T 19K 19J 21S 21D 21Y 21A 21Q 21T 21B 21H 21V 21K 21J 22B 22H 22V 23U 23F 23S 23L 23D 23Y 23G 23M 23A 23Q 23T 23C 23B 23H 23V 23K 23R 23E 23J 24U 24F 24G 24M 24A 24T 24K 24J 38A 38Q 38T 38K 39M 39A 39Q 39T 39K 39J
Item # 6395 FRUs FRU# CRU 11 Memory module, 1GB DDR2 PC2-5300 (667MHz) SoDIMM (models 12S 12D 12Y 12G 13S 13G 13C 13B 13H 14S 14D 14Y 14M 14A 14T 14K 14J 15M 15A 15Q 15T 16S 16G 17U 17F 17S 17D 17Y 17G 17M 17A 17T 17K 17J 18S 18D 18Y 18A 18Q 18T 18C 18B 18H 19S 19A 19Q 19T 19K 19J 21S 21D 21Y 21A 21Q 21T 21B 21H 21V 21K 21J 22B 22H 22V 33S 33K 33J 33A 33Q 33T 34S 34D 34Y 34A 34Q 34T 34B 34H 34V 34K 34J 35B 35H 35V 38A 38Q 38T 38K 39M 39A 39Q 39T 39K 39J 41M 41A 41Q 41T 41K 41J 42M 42A 42J 43M 43A 43Q 4
6395 Keyboards (USB Preferred Pro) FRU# CRU Dutch (models 12G 13G 16G 17G 23G 24G 29G 36G 37G 66G 68G) 41A5299 1 French (models 12G 13G 16G 17G 23G 24G 29G 36G 37G 66G 68G) 41A5300 1 French Canadian 445 (models 17F 23F 24F 26F 27F 28F 31F 36F 37F 61F 83F 84F 85F 86F 87F 88U 89F 54F 55F 56F 57F) 41A5301 1 French Canadian 58 (models 17F 23F 24F 26F 27F 28F 31F 36F 37F 61F 83F 84F 85F 86F 87F 88U 89F 54F 55F 56F 57F ) 41A5302 1 German (models 12G 13G 16G 17G 23G 24G 29G 36G 37G 66G 68G) 41A5303
6395 Keyboard (USB Preferred Pro Fingerprint Keyboard) FRU# CRU Arabic/French (models) 41A5250 1 Belgian/French (models) 41A5251 1 Belgian/UK (models) 41A5252 1 Brazil/Portuguese (models) 41A5253 1 Bulgarian (models) 41A5254 1 Chinese/US (models) 41A5255 1 Czech (models) 41A5256 1 Danish (models) 41A5257 1 Dutch (models) 41A5258 1 French (models) 41A5259 1 French Canadian 445 (models) 41A5260 1 French Canadian 58 (models) 41A5261 1 German (models) 41A5262 1 Greek (m
6395 mice FRU# CRU Optical wheel mouse (400DPI, USB) (models 11S 11D 11Y 11A 11T 12S 12D 12Y 12G 13S 13G 13C 13B 13H 14S 14D 14Y 14M 14A 14T 14K 14J 15M 15A 15Q 15T 16S 16G 17U 17F 17S 17D 17Y 17G 17M 17A 17T 17K 17J 18S 18D 18Y 18A 18Q 18T 18C 18B 18H 19S 19A 19Q 19T 19K 19J 21S 21D 21Y 21A 21Q 21T 21B 21H 21V 21K 21J 22B 22H 22V 23U 23F 23S 23L 23D 23Y 23G 23M 23A 23Q 23T 23C 23B 23H 23V 23K 23R 23E 23J 24U 24F 24G 24M 24A 24T 24K 24J 25S 25D 25Y 26U 26F 26M 26A 26Q 26T 26K 26J 27U 27F 28U 28F 29U 29F
6395 Power Cords FRU# CRU Power cord - US/Canada (models 11S 11D 12S 12D 13S 14S 14D 16S 17S 17D 18S 18D 19S 21S 21D 23S 23D 25S 25D 29S 29D 32S 32D 23L 29L 11A 11T 14A 14T 15A 15T 17A 17T 18A 18T 19A 19T 21A 21T 23A 23T 24A 24T 26A 26T 29A 29T 17U 17F 23U 23F 26U 26F 27U 27F 28U 28F 29U 29F 31U 31F 36U 37U 36F 37F 33S 34S 36S 34D 36D 33A 34A 36A 33T 34T 36T 38A 39A 41A 42A 43A 44A 45A 46A 47A 49A 51A 52A 38T 39T 41T 43T 44T 45T 46T 47T 49T 51T 52T 61U 61F 61S 62U 63A 64A 65A 67S 67A 68S 69S 82U 82F 83U
6395 Power Cords FRU# CRU Power cord - Brazil (new type) - optional second source (models) 42T5177 1 Power cord - Europe (Germany) - optional second source (models 11A 14A 15A 17A 18A 19A 21A 23A 24A 26A 29A 33A 34A 36A 38A 39A 41A 42A 43A 44A 45A 46A 47A 49A 51A 52A 63A 64A 65A 67A 68A 81A 84A ) 42T5114 1 Power cord - UK - optional second source (models 11A 14A 15A 17A 18A 19A 21A 23A 24A 26A 29A 12G 13G 16G 17G 23G 24G 29G 33A 34A 36A 38A 39A 41A 42A 43A 44A 45A 46A 47A 49A 51A 52A 63A 64A 65A 67
6395 Windows XP Home Recovery CDs FRU# CRU NO (models) 45R6012 1 PL (models) 45R6019 1 PO (models) 45R6030 1 RU (models) 45R6021 1 RE (models) 45R6029 1 HU (models) 45R6023 1 CZ (models) 45R6016 1 TR (models) 45R6022 1 GK (models) 45R6024 1 Japanese (models) 45R6011 1 Simplified Chinese (models) 45R6025 1 Taiwan- TC (models) 45R6026 1 Hong Kong- TC (models) 45R6027 1 Korea (models) 45R6028 1 FRU# CRU US/UK/AP/TH (models 39M 39A 39Q 41M 41A 41Q 43M 43A 43Q 45M 4
6395 Windows XP Pro Recovery CDs FRU# CRU Simplified Chinese (models) 45R5999 1 Taiwan-TC (models) 45R6000 1 Hong Kong-TC (models) 45R6001 1 Korea (models 39K 41K 43K 45K 63K 82K 84K) 45R6002 1 Multilingual 1 XP-P -- EN, NL, FR, GR, IT (models) 45R5977 1 Multilingual 2 XP-P -- EN, DK, FI, NO, SV (models) 45R5978 1 FRU# CRU English (models 13H) 46R7098 1 Russian English (models) 46R7099 1 French (models) 46R7100 1 German (models) 46R7101 1 Spanish (models) 46R7102 1 Braz
6395 Vista Business 32 Recovery DVDs FRU# CRU English (models 15Q) 46R7070 1 Russian (models) 46R7071 1 French (models) 46R7072 1 German (models) 46R7073 1 Spanish (models 15S 15D 15Y 17S 17Y 18S 18Y) 46R7074 1 Brazilian (models) 46R7075 1 Italian (models) 46R7076 1 Japanese (models) 46R7077 1 Norwegian (models) 46R7078 1 Swedish (models) 46R1028 1 Danish (models) 46R7079 1 Dutch (models) 46R1030 1 Czech (models) 46R1031 1 Finnish (models) 46R1032 1 Polish (model
6395 Vista Ultimate 32 Recovery DVDs FRU# CRU Japanese (models) 46R7119 1 Norwegian (models) 46R7120 1 Swedish (models) 46R1114 1 Danish (models) 46R7121 1 Dutch (models) 46R1116 1 Czech (models) 46R1117 1 Finnish (models) 46R1118 1 Polish (models) 46R1119 1 Russian (models) 46R7122 1 Turkish (models) 46R1121 1 Hungarian (models) 46R1122 1 Greek (models) 46R1123 1 Simplified Chinese (models) 46R7123 1 Traditional Chinese (models) 46R7124 1 Traditional Chinese (mo
6395 Vista Business 64 Recovery DVDs FRU# CRU Turkish (models) 46R1065 1 Hungarian (models) 46R1066 1 Greek (models) 46R1067 1 Simplified Chinese (models) 46R7095 1 Taiwan (models) 46R7096 1 Hong Kong (models) 46R7097 1 Korea (models) 46R1071 1 Slovenian (models) 46R1072 1 Arabic Localized (models) 46R1073 1 Hebrew (models) 46R1074 1 Portuguese (models) 46R1075 1 Slovakian (models) 46R1076 1 FRU# CRU Machine Type 6396 Item # 6396 FRUs 1 Front audio/USB card and c
Item # 6396 FRUs FRU# CRU 2 Hard disk drive, 160 GB 7200rpm SATA (models) 40Y9035 2 2 Hard disk drive, 25 GB 7200rpm SATA (models) 40Y9036 2 2 Hard disk drive, 320 GB 7200rpm SATA (models ) 87H4891 2 2 Hard disk drive, 500 GB 7200rpm SATA (models) 41X5582 2 2 Hard disk drive, 750 GB 7200rpm SATA (models) 43C3671 2 2 Hard disk drive, 1TB 7200rpm SATA (models CTO) 45C5973 2 3 System fan (models) 41R8511 2 4 DVD-ROM Drive - 16x/48x - SATA (models) 41N3325 2 4 DVD-ROM Drive
6396 FRUs FRU# CRU Hard disk drive tray (models) 41R8518 2 Shield kit (models) 41R8543 N Cable, C2 swtich/housing assembly (models) 41R8544 N Cable, serial (models) 41R8548 N USB cable (models) 41R8560 N Kit, shell (models) 41R8563 N FRU# CRU US English (models) 41A5289 1 Arabic (models) 41A5290 1 Arabic/French (models) 41A5291 1 Belgian/French (models) 41A5292 1 Belgian/UK (models) 41A5293 1 Brazilian (models) 41A5294 1 Bulgarian (models) 41A5295 1 Hong Kong/Taiw
6396 Keyboards (USB Preferred Pro) FRU# CRU Slovak (models) 41A5320 1 Spanish (models ) 41A5321 1 Swedish/Finn (models) 41A5322 1 Swiss (models) 41A5323 1 Thailand (models) 41A5324 1 Turkish 440 (models) 41A5325 1 Turkish 179 (models) 41A5326 1 UK English (models) 41A5327 1 US European (models) 41A5328 1 Slovenian (models) 41A5329 1 FRU# CRU US (models) 41A5248 1 Arabic (models) 41A5249 1 Arabic/French (models) 41A5250 1 Belgian/French (models) 41A5251 1 Belgia
6396 Keyboard (USB Preferred Pro Fingerprint Keyboard) FRU# CRU Romanian 446 (models) 41A5276 1 Romanian 96 (models) 41A5275 1 Russian/Cyrillic (models) 41A5277 1 Serbian/Cyrillic (models) 41A5278 1 Slovak (models) 41A5279 1 Spanish (models) 41A5280 1 Swedish/Finn (models) 41A5281 1 Swiss, F/G (models) 41A5282 1 Thailand (models) 41A5283 1 Turkish 179 (models) 41A5284 1 Turkish 440 (models) 41A5285 1 UK (models) 41A5286 1 US European (models) 41A5287 1 Slovenian (mo
6396 Power Cords FRU# CRU Power cord - Italy (models) 42T5047 1 Power cord - Australia / New Zealand (models) 42T5050 1 Power cord - South Africa (models) 42T5056 1 Power cord - Israel (models) 42T5062 1 Power cord - China (PRC) (models) 42T5065 1 Power cord - Taiwan (models) 42T5071 1 Power cord - Korea (models) 42T5077 1 Power cord - India (models) 42T5083 1 Power cord - Thailand (models) 42T4406 1 Power cord - US/Canada--optional second source (models) 42T5089 1 Power cor
6396 Windows XP Home Recovery CDs FRU# CRU FI (models) 45R6017 1 NO (models) 45R6012 1 PL (models) 45R6019 1 PO (models) 45R6030 1 RU (models) 45R6021 1 RE (models) 45R6029 1 HU (models) 45R6023 1 CZ (models) 45R6016 1 TR (models) 45R6022 1 GK (models) 45R6024 1 Japanese (models) 45R6011 1 Simplified Chinese (models) 45R6025 1 Taiwan-TC (models) 45R6026 1 Hong Kong-TC (models) 45R6027 1 Korea (models) 45R6028 1 FRU# CRU US/UK/AP/TH (models) 45R5979 1 FR/C
6396 Windows XP Pro Recovery CDs FRU# CRU Simplified Chinese (models) 45R5999 1 Taiwan-TC (models) 45R6000 1 Hong Kong-TC (models) 45R6001 1 Korea (models) 45R6002 1 Multilingual 1 XP-P -- EN, NL, FR, GR, IT (models) 45R5977 1 Multilingual 2 XP-P -- EN, DK, FI, NO, SV (models) 45R5978 1 FRU# CRU English (models 13H) 46R7098 1 Russian English (models) 46R7099 1 French (models) 46R7100 1 German (models) 46R7101 1 Spanish (models) 46R7102 1 Brazilian (models) 46R7103 1
6396 Vista Business 32 Recovery DVDs FRU# CRU English (models 15Q) 46R7070 1 Russian (models) 46R7071 1 French (models) 46R7072 1 German (models) 46R7073 1 Spanish (models 15S 15D 15Y 17S 17Y 18S 18Y) 46R7074 1 Brazilian (models) 46R7075 1 Italian (models) 46R7076 1 Japanese (models) 46R7077 1 Norwegian (models) 46R7078 1 Swedish (models) 46R1028 1 Danish (models) 46R7079 1 Dutch (models) 46R1030 1 Czech (models) 46R1031 1 Finnish (models) 46R1032 1 Polish (model
6396 Vista Ultimate 32 Recovery DVDs FRU# CRU Japanese (models) 46R7119 1 Norwegian (models) 46R7120 1 Swedish (models) 46R1114 1 Danish (models) 46R7121 1 Dutch (models) 46R1116 1 Czech (models) 46R1117 1 Finnish (models) 46R1118 1 Polish (models) 46R1119 1 Russian (models) 46R7122 1 Turkish (models) 46R1121 1 Hungarian (models) 46R1122 1 Greek (models) 46R1123 1 Simplified Chinese (models) 46R7123 1 Traditional Chinese (models) 46R7124 1 Traditional Chinese (mo
6396 Vista Business 64 Recovery DVDs FRU# CRU Turkish (models) 46R1065 1 Hungarian (models) 46R1066 1 Greek (models) 46R1067 1 Simplified Chinese (models) 46R7095 1 Taiwan (models) 46R7096 1 Hong Kong (models) 46R7097 1 Korea (models) 46R1071 1 Slovenian (models) 46R1072 1 Arabic Localized (models) 46R1073 1 Hebrew (models) 46R1074 1 Portuguese (models) 46R1075 1 Slovakian (models) 46R1076 1 FRU# CRU Machine Type 6397 Item # 6397 FRUs 1 Front audio/USB card and c
Item # 6397 FRUs FRU# CRU 2 Hard disk drive, 160 GB 7200rpm SATA (models 11U 11F 11S 11L 11D 11Y 11G 11M 11A 11Q 11T 11C 11B 11H 11V 11K 11R 11E 11J) 40Y9035 2 2 Hard disk drive, 25 GB 7200rpm SATA (models) 40Y9036 2 2 Hard disk drive, 320 GB 7200rpm SATA (models ) 87H4891 2 2 Hard disk drive, 500 GB 7200rpm SATA (models) 41X5582 2 2 Hard disk drive, 750 GB 7200rpm SATA (models) 43C3671 2 2 Hard disk drive, 1TB 7200rpm SATA (models CTO) 45C5973 2 3 System fan (all models) 41R85
Item # 6397 FRUs FRU# CRU 12 Internal speaker (all models) 41R8517 2 13 Media card reader (all models) 41R8568 N FRU# CRU Hard disk drive tray (all models) 41R8518 2 Shield kit (all models) 41R8543 N Cable, C2 swtich/housing assembly (all models) 41R8544 N Cable, serial (all models) 41R8548 N USB cable (all models) 41R8560 N Kit, shell (all models) 41R8563 N PWR/LED cable assembly (all models) 41R8555 N FRU# CRU US English (models 11U 11G 11M 11A 11Q 11H 11R 11E) 41A528
6397 Keyboards (USB Preferred Pro) FRU# CRU Norwegian (models 11G) 41A5313 1 Polish (models 11G) 41A5314 1 Portuguese (models 11G) 41A5315 1 Romanian 446 (models 11G) 41A5316 1 Romanian 096 (models 11G) 41A5317 1 Russian/Cyrillic (models 11G) 41A5318 1 Serbian/Cyrillic (models 11G) 41A5319 1 Slovak (models 11G) 41A5320 1 Spanish (models 11G) 41A5321 1 Swedish/Finn (models 11G) 41A5322 1 Swiss (models 11G) 41A5323 1 Thailand (models 11T) 41A5324 1 Turkish 440 (models 11
6397 Keyboard (USB Preferred Pro Fingerprint Keyboard) FRU# CRU Italian (models) 41A5268 1 Japanese (models) 41A5269 1 Korean (models) 41A5270 1 LA Spanish (models) 41A5271 Norwegian (models) 41A5272 1 Polish (models) 41A5273 1 Portuguese (models) 41A5274 1 Romanian 446 (models) 41A5276 1 Romanian 96 (models) 41A5275 1 Russian/Cyrillic (models) 41A5277 1 Serbian/Cyrillic (models) 41A5278 1 Slovak (models) 41A5279 1 Spanish (models) 41A5280 1 Swedish/Finn (models) 41
6397 Power Cords FRU# CRU Power cord - US/Canada (models 11U 11F 11S 11D 11L 11A 11T) 42T5004 1 Power cord - Japan (models 11J) 42T5011 1 Power cord - Argentina (models 11Y 11L) 42T5017 1 Power cord - Brazil (models) 42T5174 1 Power cord - Europe (Germany) (models 11A) 42T5029 1 Power cord - UK (models 11G 11A) 42T5035 1 Power cord - Denmark (models 11G) 42T5041 1 Power cord - Switzerland (models 11G) 42T5044 1 Power cord - Italy (models 11S 11Y 11L 11G) 42T5047 1 Power cord -
6397 Windows XP Home Recovery CDs FRU# CRU IT (models) 45R6010 1 BR (models) 45R6009 1 SP/LA (models) 45R6008 1 DK (models) 45R6014 1 NL (models) 45R6015 1 AE (models) 45R6020 1 SV (models) 45R6013 1 HE (models) 45R6018 1 FI (models) 45R6017 1 NO (models) 45R6012 1 PL (models) 45R6019 1 PO (models) 45R6030 1 RU (models) 45R6021 1 RE (models) 45R6029 1 HU (models) 45R6023 1 CZ (models) 45R6016 1 TR (models) 45R6022 1 GK (models) 45R6024 1 Japanese (mod
6397 Windows XP Pro Recovery CDs FRU# CRU PO (models) 45R6004 1 RU (models) 45R5995 1 RE (models) 45R6003 1 HU (models) 45R5997 1 CZ (models) 45R5990 1 TR (models) 45R5996 1 GK (models) 45R5998 1 Japanese (models) 45R5985 1 Simplified Chinese (models) 45R5999 1 Taiwan-TC (models) 45R6000 1 Hong Kong-TC (models) 45R6001 1 Korea (models) 45R6002 1 Multilingual 1 XP-P -- EN, NL, FR, GR, IT (models) 45R5977 1 Multilingual 2 XP-P -- EN, DK, FI, NO, SV (models) 45R5978
6397 Vista Home Basic 32 Recovery DVDs FRU# CRU Slovenian (models) 46R1100 1 Hebrew (models) 46R1101 1 Portuguese (models) 46R1102 1 Arabic Localized (models) 46R1103 1 Slovakia (models) 46R1104 1 FRU# CRU English (models 15Q) 46R7070 1 Russian (models) 46R7071 1 French (models) 46R7072 1 German (models) 46R7073 1 Spanish (models 15S 15D 15Y 17S 17Y 18S 18Y) 46R7074 1 Brazilian (models) 46R7075 1 Italian (models) 46R7076 1 Japanese (models) 46R7077 1 Norwegian (mo
6397 Vista Ultimate 32 Recovery DVDs FRU# CRU English (models) 46R7112 1 Russian (models) 46R7113 1 French (models) 46R7114 1 German (models) 46R7115 1 Spanish (models) 46R7116 1 Brazilian (models) 46R7117 1 Italian (models) 46R7118 1 Japanese (models) 46R7119 1 Norwegian (models) 46R7120 1 Swedish (models) 46R1114 1 Danish (models) 46R7121 1 Dutch (models) 46R1116 1 Czech (models) 46R1117 1 Finnish (models) 46R1118 1 Polish (models) 46R1119 1 Russian (models)
6397 Vista Business 64 Recovery DVDs FRU# CRU Swedish (models) 46R1058 1 Danish (models) 46R7093 1 Dutch (models) 46R1060 1 Czech (models) 46R1061 1 Finnish (models) 46R1062 1 Polish (models) 46R1063 1 Russian (models) 46R7094 1 Turkish (models) 46R1065 1 Hungarian (models) 46R1066 1 Greek (models) 46R1067 1 Simplified Chinese (models) 46R7095 1 Taiwan (models) 46R7096 1 Hong Kong (models) 46R7097 1 Korea (models) 46R1071 1 Slovenian (models) 46R1072 1 Arabic
138 Hardware Maintenance Manual
Chapter 10. Additional Service Information This chapter provides additional information that the service representative might find helpful. Security features Security features in this section include the following: • Passwords • Vital Product Data • Management Information Format (MIF) Hardware controlled Passwords Hardware controlled passwords are set using the Setup Utility program. For more information about passwords, see “Using passwords” on page 39.
• If using a CD-ROM, make sure the computer is turned on. Insert the system program update (flash) CD-ROM into the optical drive. The update begins. • If using a diskette, make sure the computer is turned off. Insert the system program update (flash) diskette and turn on the computer. The update begins. 2. When you are prompted to select a language, press the number on your keyboard that corresponds to the language and then press Enter. 3. When prompted to change the serial number, press Y. 4.
Automatic configuration and power interface (ACPI) BIOS Being an ACPI BIOS system, the operating system is allowed to control the power management features of the computer and the setting for Advanced Power Management (APM) BIOS mode is ignored. Not all operating systems support ACPI BIOS mode. Automatic Power-On features The Automatic Power-On features within the Power Management menu allow you to enable and disable features that turn on the computer automatically.
142 Hardware Maintenance Manual
Appendix A. Notices Lenovo may not offer the products, services, or features discussed in this document in all countries. Consult your local Lenovo representative for information on the products and services currently available in your area. Any reference to a Lenovo product, program, or service is not intended to state or imply that only that Lenovo product, program, or service may be used.
Television output notice The following notice applies to models that have the factory-installed television-output feature. This product incorporates copyright protection technology that is protected by method claims of certain U.S. patents and other intellectual property rights owned by Macrovision Corporation and other rights owners.
Part Number: 43C6257 Printed in USA (1P) P/N: 43C6257 *43C6257*
