website:http://www.lgservice.
Table of Contents Introduction Installation Operation Suggestion on Food Storage Care and Maintenance 2 Entry 3 Important Safety Instruction 3 Identification of Parts 4 Where to Install 5 Door Removal 6 Door Replacement 7 Water Pipe Installation 7 Water Connection Instruction Guide 8 Operation Instruction Guide 10 Height Adjustment 12 Starting 13 Adjusting the Temperatures and functions (Dispenser/Automatic Icemaker) 13 Shelf 19 Wine Holder 19 Can Server Adjustment 19 Egg
Introduction Entry The model and serial numbers are found on the inner case or back of refrigerator compartment of this unit. These numbers are unique to this unit and not available to others. You should record requested information here and retain this guide as a permanent record of your purchase. Staple your receipt here. Date of purchase Dealer Dealer address Dealer phone no. Model no. Serial no.
Introduction Child Entrapment Warning DANGER: Risk of child entrapment. Before you throw away your old refrigerator or freezer: Take off the doors but leave the shelves in place so that children may not easily climb inside. The appliance is not intended for use by young children without supervision. Young children should be supervised to ensure that they do not play with the appliance.
Installation Where to Locate 1. Place your appliance where it is easy to use. Select a Good Location 2. Avoid placing the unit near heat sources, direct sunlight, or moisture. 3. To avoid vibrations, the appliance must be leveled. 4. Do not install this refrigerator in areas where the ambient temperature is below 41°F. It will have an adverse effect on performance.
Installation Door removal Warning Electric Shock Hazard Disconnect electrical supply to refrigerator before installing. Failure to do so could result in death or serious injury. If your entrance door is too narrow for the refrigerator to pass through, remove the refrigerator door and pass the refrigerator laterally. Remove Lower Cover and Water Feed Tube Remove the lower cover by lifting upward, and then pull up the water feed tube while pressing area shown in the figure to the right.
Installation Push the refrigerator sideways through the entrance door as shown in the right picture. Move the Refrigerator Max 5 4 3 2 1 FRZ TEMP Min 1 2 REF TEMP 3 4 5 Max Door replacement Mount the doors in the reverse order of removal after the refrigerator is brought to the installation area. Feed water tube installation Before Installation Automatic icemaker operation needs water pressure of 21.3~121psi(lb/inch2) (That is, an instant paper cup (70z) will be fully filled within 3 sec.
Installation Water Connection Instruction Guide Connecting the Refrigerator to a Water Source Read all directions carefully before you begin. Warning Connect to potable water supply only. IMPORTANT Tools Required • If operating the refrigerator before installing the water connection, turn icemaker to the OFF position to prevent operation without water. • All installations must be in accordance with local plumbing code requirements. • Use copper tubing and check for leaks.
Installation Connect the Tubing to Water Line 1. Unplug refrigerator or disconnect power. 2. Turn OFF main water supply. Turn on the nearest faucet to relieve the pressure on the line. It may help to open an outside hydrant to allow the water to drain from the line in the house. 3. Find a 1/2-inch to 1-1/4-inch vertical COLD water pipe near the refrigerator. NOTE • Horizontal pipe will work, but the following precaution must be taken: Drill on the top of the pipe, not the bottom.
Installation Operation Instruction Guide Connect the Tubing to the Refrigerator Before making the connection to the refrigerator, be sure the refrigerator power cord is not plugged into the Refrigerator wall outlet. Connection • If your refrigerator does not have a water filter, we recommend Ferrule (sleeve) installing one. If your water supply has sand or particles that could clog Tubing the screen of the refrigerator’s Clamp water valve. Install the filter in the water line near the refrigerator.
Installation When Icemaker Does Not Operate Smoothly Ice is clumped together When ice is clumped together, take the ice clumps out of the ice storage bin, break them into small pieces, and then place them into the ice storage bin again. When the icemaker produces too small or clumped ice, the amount of water supplied to the ice maker must be adjusted. Contact the service center. If ice is not used frequently, it may clump together. Power failure Water may drop into the freezer compartment.
Installation Height Adjustment If the freezer compartment door is lower than the refrigerator compartment door Level the door by inserting flat ( - type) driver into the groove of the left height adjusting screw and rotating it clockwise . If the freezer compartment door is higher than the refrigerator compartment door Level the door by inserting flat ( - type) driver into the groove of the right height adjusting screw and rotating it clockwise .
Operation Starting When your refrigerator is first installed, allow it to stabilize at normal operating temperatures for 2-3 hours prior to filling it with fresh or frozen foods. If operation is interrupted, wait 5 minutes before restarting.
Operation You can adjust temperature of freezer room and refrigerator Compartment. How to adjust the temperature in the freezer compartment Freezer Compartment temperature adjustment Setting temperature BAR Indication How to adjust the temperature in the refrigerator compartment Refrigerator Compartment temperature adjustment Setting temperature BAR Indication ❇ Whenever pressing button, setting is repeated in the order of (Middle) ➔ (Middle Strong) ➔ (Strong) ➔ (Weak) ➔ (Middle Weak).
Operation Automatic Icemaker The automatic icemaker can automatically make 8 cubes at a time, 120~150 pieces per day. This quantity may vary by circumstance, including ambient temperature, door opening, freezer load. etc. Icemaking stops when the ice storage bin is full. If you don't want to use automatic icemaker, turn the icemaker switch to OFF. If you want to use automatic ice-maker again, change the switch to ON.
Operation The Other Functions Ambient Temperature Display Window. Temperature is displayed only between 16°F ~ 120°F. Temperature less than 15°F is indicated with LO and temperature more than 121°F is indicated with HI. ROOM TEMP Door open warning A warning tone will sound 3 times at thirty-second intervals if the refrigerator or freezer door is left open for more than sixty seconds. Please contact with the local service center if warning continue to sound even after closing the door.
Operation NOTE Crushed ice will be automatically selected after a power failure or when the power plug is connected again. • Place glasses or other containers near the ice outlet otherwise ice is likely to be dropped on the floor. • A snap sound will be heard 5 seconds after ice is fully dispensed. This sound is made when the ice outlet is closed.
Operation LCD(GR-:267AV(T)BA Model) As demonstrated below, it displays the months left in units of 30 days or about 4,700 seconds of using water filter until the filter replacement is required, starting from when the refrigerator power usage is first begun. 3 SECS After 6 months, the following sentence and will appear on the filter condition part of the LCD. FILTER LIGHT 3SECS.
Operation Shelf Shelf Height Adjustment The refrigerator compartment shelf is movable so that you can place it at a height according to space requirement of foods. 1 How to separate a shelf : Lift the shelf a the direction of Arrow ,then remove it from the rack by pulling it in the direction of Arrow . 2 1 How to install a shelf : Holding the shelf up at the front, insert the tab at the desired height and lower the shelf into place. NOTE • Make sure the shelf is horizontal. If not, it may drop.
Operation Egg Bin (Applicable to some models only) You can place the egg box to wherever you want it. [Normal] [For Many Eggs] NOTE • • Never use the egg box as an ice storage bin. It can be broken. Never store the egg box in the freezer compartment or fresh compartment. Humidity control in the vegetable compartment The humidity can be controlled by adjusting the humidity control switch to the left or right when storing vegetabes or fruits.
Operation OptiChill Temperature Transition Corner (Applicable to some models only) By pressing the button, store vegetables, fruits or other types of food such as meat to be defrosted, raw fish, etc. Temperature Change at OptiChill Method to Use You can select optimum temperature range depending on types of foods stored. - Reword as indicated: four steps of temperature selection are available, including 27°F,30°F, 39°F and 50°F.
Suggestion on Food Storage Location of Foods (Refer to Identification of Parts) Wine Holder Store wine. Snack Drawer Store small foods such as bread, snacks, etc. Freezer Compartment Shelf Store various frozen foods such as meat, fish, ice cream, frozen snacks, etc. Freezer Compartment Door Rack Freezer Compartment Drawer Store small packed frozen food. Temperature is likely to increase as door opens. So, do not store long-term food such ice cream, etc. Store meat, fish, chicken, etc.
Suggestion on Food Storage Storing Foods Store fresh food in the refrigerator compartment. How food is frozen and thawed is an important factor in maintaining its freshness and flavor. Do not store food which spoils easily at low temperatures, such as bananas and melons. Allow hot food to cool prior to storing, placing hot food in the refrigerator could spoil other food, and lead to higher energy consumption. When storing the food, cover it with vinyl wrap or store in a container with a lid.
Care and Maintenance How to Dismantle Parts NOTE • Freezer Compartment Lamp Dismantling is done in the reverse sequence of assembly. Be sure to unplug the power plug before dismantling and assembly. Never apply severe force to dismantle parts. Parts may be damaged. Separate the lamp by pulling it out ➂ while slightly striking ➀ and rotating ➁ the lamp cover. Turn the bulb counterclockwise. Max. 40 W bulb for refrigerator is used and can be purchased at a service center.
Care and Maintenance To remove the lamp cover, press the protrusion under the lamp cover to the front and then pull the lamp cover out. Turn the bulb counterclockwise. Max. 40 W bulb for refrigerator is used and can be purchased at a service center. Lamp in Refrigerator Compartment NOTE • Be sure to remove parts from the refrigerator door when removing the vegetable compartment, snack drawer, and refreshment center cover.
Care and Maintenance General Information Vacation Time During average length vacations, you will probably find it best to leave the refrigerator in operation. Place freezable items in freezer for longer life. When you plan to store the refrigerator, remove all food, disconnect the power cord, clean the interior thoroughly, and Block the doors open to prevent mold and mildew. Be certain the stored refrigerator does not present a child entrapment danger.
Care and Maintenance Troubleshooting Before calling for service, review this list. It may save you both time and expense. This list includes common occurrences that are not the result of defective workmanship or materials in this appliance. Occurrence Possible cause Solution Runing of refrigerator Refrigerator compressor does not run. Refrigerator runs too much or too long Refrigerator control is off. Set refrigerator control. See setting the controls. Refrigerator is in defrost cycle.
Care and maintenance Occurrence Possible cause Refrigerator compressor does not run. Thermostat is keeping the refrigerator at a constant temperature. Solution This is normal. The refrigerator goes on and off to keep the temperature constant. Temperatures are too cold Temperature in the freezer is too cold but the refrigerator temperature is satisfactory. Temperature in the refrigerator is too cold and the freezer temperature is satisfactory. Food stored in drawers freezes.
Care and Maintenance Occurrence Possible cause Solution Sound and noise Louder sound levels when refrigerator is on. Today’s refrigerators have increased storage capacity and maintain more even temperatures. It is normal for sound levels to be higher. Louder sound levels when compressor comes on. Refrigerator operates at higher pressures during the start of the ON cycle. This is normal. The sound will level off as the refrigerator continues to run. Vibrating or rattling noise.
Care and Maintenance Possible cause Occurrence Solution Odors in refrigerator Interior needs to be cleaned. Clean interior with sponge,warm water and baking soda. Food with strong odor is in the refrigerator. Cover food completely. Some containers and wrapping materials produce odors. Use a different container or brand of wrapping materials. Opening/Closing of doors/Drawers Door(s) will not close. Food package is keeping door open. Move packages that keep door from closing.
Care and Maintenance Occurrence Possible cause Dispenser will not dispense ice. Ice has melted and frozen around auger due to infrequent use, temperature fluctuations and/or power outrages. Remove ice storage bin, and thaw and the contents. Clean bin, wipe dry and replace in proper position. When new ice is made, dispenser should operate. Ice dispenser is jammed. Ice cubes are jammed between the ice maker arm and back of the bin. Remove the ice cubes that are jamming the dispenser.
LG Twin Tower, 20, Yoido-Dong, Youngdungpo-Gu, Seoul, 150-721, Korea. http://www.lge.
