Monocrystalline Solar Module LGXXXS1C(W, K)-G3
Revisions Table Date Version 2012.08.01 1.0 (1st edition) 2012.11.16 nd 2.
Safety The instructions related to safety and use indicated in the this installation manual are intended for the prevention of unexpected danger, damage, or failure. Non-compliance with the instructions may cause product damage, product failure, and/or serious bodily injury or death. ① Do not contact electrically active parts of the panel, such as terminals, without appropriate safety gear. Contact may result in lethal spark or electric shock. ② Do not use or install if the module is broken or torn.
Before & After Installation Before Installation Please carefully read this manual before installation. • Contact with electrically active parts of the panels, such as terminals, may result in burns, sparks and lethal shock whether the panel is connected or disconnected. • Panels produce voltage even when not connected to an electrical circuit or load. • Solar module installation and maintenance must be performed by qualified and authorized installer.
Electrical Installation Danger • Avoid all electrical hazards when installing, wiring, operating and maintaining all panels. • Do not connect panels that have different electrical properties or physical configurations in the same system. • Match the polarities of cables and terminals when making the connections; failure to do so may result in damage to the panel. • The rating of the over-current device shall not exceed the maximum series fuse rating marked on the name plate.
Electrical Installation General Wiring • LG Electronics recommends that all wiring be double insulated with a minimum rating of 90°C (194°F). • All wiring should use a flexible copper (Cu) conductor. • The minimum size should be determined by the applicable codes. • LG Electronics recommends a size no smaller than 4mm2. Earth Grounding • The solar modules from LG Electronics meet the conditions of safety class II. Therefore grounding is not mandatory. However grounding is recommended.
Mechanical Installation Module Mounting • The LG Electronics‟ (LGE) Limited Warranty for solar modules is contingent upon modules being mounted in accordance with the requirements described in this section. • The solar modules are in Application Class A and have the Safety Class II. Therefore, they can be operated in systems with 120 V DC and higher. General access is not restricted.
Mechanical Installation Mounting Type LGXXXS1C(W,K)-G3 Clamping Type (Long Side) Use four mounting holes on two opposite sides. Clamping Range (230mm) 270mm 270mm Use four clamps on the long frame. This method is not tested by IEC / UL. Clamping Type (Short Side) Center ± 100mm Clamping Range: From module Edge to 270mm Clamping Range: From module Edge to 120mm Center ± 100mm Use four clamps on the short frame. Use four clamps on the short frame and two clamps at the center of long frame.
Product Specifications - Electrical and Mechanical Properties (Rated electrical characteristics are within 10 percent) Standard Test Condition(STC) : Irradiation 1,000W/m2, Cell temp. 25℃, 1.5AM Certifi cates Height 1640 1000 35 16.8 15 LG245S1C-G3 Yes 245 3% 38.11 8.52 30.57 8.02 46.0+2 -0.420 <4.5 600 12 MC4 1640 1000 35 16.8 15 LG250S1C-G3 Yes 250 3% 38.26 8.62 30.77 8.13 46.0+2 -0.420 <4.5 600 12 MC4 1640 1000 35 16.8 15 LG255S1C-G3 Yes 255 3% 38.41 8.
Disclaimer of Liability / Disposal Disclaimer of Liability • By beginning the installation process the installer represents the he/she has read and completely understands this Installation Manual. He/She further represents if he/she had any questions regarding this installation manual he/she would have contacted LG with any questions or concerns.
LG Electronics U.S.A Inc. 1000 Sylvan Ave, Englewood Cliffs, NJ 07632 Contact : lg.solar@lge.com http://www.lgsolarusa.com This document is subject to change without notice. LG, LG logo and Life's Good are trademarks of LG Electronics, Inc. worldwide. Trademarks and intellectual properties of LG Electronics, Inc. are protected by international copyright laws.
