Design Guide Wine and Undercounter Release 06 2016
Welcome Liebherr's engineering excellence in Germany provides the largest selection of freezers, refrigerators and wine refrigerators worldwide. Liebherr is one of the World’s leading Manufacturers of Premium Refrigeration. For more than 60 years, Liebherr has specialized in developing and manufacturing first class refrigerators and freezers as well as wine cabinets. We focus on performance and efficiency as well as keeping food fresher longer.
Introduction LIEBHERR WARRANTY PLAN FULL TWO YEAR WARRANTY For two years from the date of original purchase, your Liebherr warranty covers all parts and labor to repair or replace any part of the product which proves to be defective in materials or workmanship. FULL FIVE YEAR WARRANTY For five years from the date of original purchase, your Liebherr warranty covers all parts and labor to repair or replace any components that prove to be defective in materials or workmanship in the sealed system.
Content DesignGuide Safety Warnings................................................................................................................................ 7 Electrical Requirements & Safety.................................................................................................. 8 Area Requirements.......................................................................................................................... 9 Safety Regulations.....................................................
General Remarks Safety Warnings PLEASE READ AND FOLLOW THESE INSTRUCTIONS This design guide contains Warning and Important statements. This information is important for planning a safe and efficient installation. Please refer to the Installation Manual specific to your model for complete installation instructions. This design guide is intended for planning purposes and is not a replacement for your appliance's Use and Care Manual which contains important information on how to use Liebherr appliances.
General Remarks Electrical Requirements & Safety A 15 amp or 20 amp, 110-120 VAC, circuit which is grounded and protected by a circuit breaker or fuse is required. Additional Electrical Requirements for Outdoor Refrigerator RO 510 We recommend using a dedicated circuit for each appliance to prevent circuit overload and the chance of interruption to the appliance.
General Remarks Area Requirements Safety Regulations Verify the following: The appliances are designed to cool and store wine and beverages. • Finished kitchen floor height is level. The appliance must be shimmed to the floor level, or levelled, to make sure air vents are not obstructed. • Remove anything attached to the rear or side walls that can obstruct the refrigerator opening. • Cutout dimensions are accurate. • Electrical outlet is in correct location.
Wine and Undercounter Specifications Wine Cabinets WU 3400, WUgb 3400, WU 4500 WU 3400 Energy Supply: 115V / 60Hz / 2A Climate Rating: SN-ST Door hinges: right/reversible Door: glass door with stainless steel frame • Touch electronic control system • Telescopic wine shelves • Activated charcoal filter • LED-light WUgb 3400 Energy Supply: 115V / 60Hz / 2A Climate Rating: SN-ST Door hinges: right/reversible Door: glass door • Touch electronic control system • Telescopic wine shelves • Activ
Wine and Undercounter Specifications Wine Cabinets HWS 1800, HWgb 1803, HWgw 1803 HWS 1800 Energy Supply: 115V / 60Hz / 1A Climate Rating: SN Door hinges: right/reversible Door: glass door with stainless steel frame • Touch electronic control system • Telescopic wine shelves • Activated charcoal filter • LED-light HWgb 1803 (black glass front) HWgw 1803 (white glass front) Energy Supply: 115V / 60Hz / 1A Climate Rating: SN-ST Door: Drop down glass door • Touch electronic control system • Teles
Wine and Undercounter Specifications Wine Cabinet WS 17800 WS 17800 Energy Supply: 115V / 60Hz / 2A Climate Rating: SN-ST Door hinges: right/reversible Door: glass door with stainless steel frame • Touch electronic control system • Telescopic wine shelves • Activated charcoal filter • LED-light 12
Wine and Undercounter Specifications Undercounter Beverage Center RU 510 Outdoor Refrigerator RO 510 RU 510 Energy Supply: 115V / 60Hz / 1.5A Climate Rating: SN-ST Door hinges: right/reversible Door: glass door with stainless steel frame • Touch electronic control system • Telescopic bottom shelf • Activated charcoal filter • LED-light • Glass shelves with stainless steel trim RO 510 Energy Supply: 115V / 60Hz / 1.
Wine and Undercounter Undercounter Wine Cabinet WU 3400 / WU 4500 WU 3400 IMPORTANT To ensure proper refrigeration performance of the appliance, the ventilation grille supplied must be installed. The ventilation grille must be installed into the toe kick panel. The foam block supplied must be installed in order to ensure the required air flow through the appliance base. WU 4500 Failure to follow this instruction may result in poor refrigeration performance.
Wine and Undercounter Appliance and Cabinet Dimensions Side view Counter depth dimension without cabinet door Height when adjustable feet have been screwed in as far as they will go. Delivery status = feet approx. 1/8" unscrewed. Maximum height adjustment = 2" (51 mm) to allow for a 6" (153 mm) toe kick. The power cord extits the rear of the appliance at this location.
Wine and Undercounter Undercounter Wine Cabinet WUgb 3400 IMPORTANT To ensure proper refrigeration performance of the appliance, the ventilation grille supplied must be installed. The ventilation grille must be installed into the toe kick panel. The foam block supplied must be installed in order to ensure the required air flow through the appliance base. Failure to follow this instruction may result in poor refrigeration performance.
Wine and Undercounter Appliance and Cabinet Dimensions Side view Counter depth dimension without cabinet door Height when adjustable feet have been screwed in as far as they will go. Delivery status = feet approx. 1/8" unscrewed. Maximum height adjustment = 2" (51 mm) to allow for a 6" (153 mm) toe kick. The power cord extits the rear of the appliance at this location.
Wine and Undercounter Built in Wine Cabinet HWS 1800 Appliance Dimensions Side view For installation in a 30" recess the Trim Kit is required. See chapter "Accessories".
Wine and Undercounter Cabinet Dimensions Appliance Venting The power cord exits the rear of the appliance at this location. Free length of the power cord = 48" (1220 mm) IMPORTANT The electrical outlet must not be situated behind the appliance and must be easily accessible. IMPORTANT The clear ventilation cross section must be at least 31 sq inches from the lower to the top opening. Cabinet Dimensions - Flush Face Installation Cabinet dimensions for installations into a cabinet wall.
Wine and Undercounter Built in Wine Cabinet HWgb 1803, HWgw 1803 Appliance Dimensions Side view Maximum door opening angle R600a Refrigerant Top view WARNING! The refrigerant R600a contained within the appliance is environmentally friendly, but flammable. Leaking refrigerant can ignite. To prevent possible ignition, designed ventilation is required.
Wine and Undercounter Cabinet Dimensions Appliance Venting The power cord exits the rear of the appliance at this location. Free length of the power cord = 102" (2600 mm) The electrical outlet must not be situated behind the appliance and must be easily accessible. Important The area of ventilation above the unit should be at least 31 square inches (200 cm²). The air supply passes below the appliance door.
Wine and Undercounter Fully integrated Undercounter UPR 503 After installing the kitchen cabinet door, there must be a ventilation gap between the appliance ventilation grill and the kitchen cabinet door. The ventilation grille is movable to guarantee sufficient ventilation. Important A minimum opening of 1-3/8" (35 mm) must be maintained to allow proper air flow for ventilation.
Wine and Undercounter Appliance and Cabinet Dimensions IMPORTANT The floor on which the appliance stands must be horizontal and level. The kitchen units must be aligned horizontally and vertically. Cabinet Dimensions with integrated Appliance - Sideview - Cabinet Dimensions D 32-1/4 " - 34-5/8 " (820 mm - 880 mm) F closed: 21-5/8 " (550 mm) max. opened: 39-3/4 " (1010 mm) L 21-1/4 " (540 mm) M 1/8 " (4 mm) N 25-7/16 " - 30-5/16 " (646 mm - 770 mm) O max. 4 " - 6 " ( max. 102 mm - 152 mm) A B C D min.
Wine and Undercounter Fastening Method Appliance - Cabinet Side fastening: • Installation below hard worktops such as granite. • With the adjusting feet completely screwed out, the appliance is lower than the counter top. Toe Kick Panel The toe kick installation will be different depending on the cabinets where the appliance is installed. A toe kick panel will be required to cover the gap between the ventilation grill and the floor.
Wine and Undercounter Kitchen Cabinet Doors Kitchen Cabinet Door Panel for standard Toe Kick Designing the Kitchen Cabinet Door You will need one door for the kitchen cabinet. In general, the door has these characteristics: • The width of the cabinet door depends on the kitchen style and the size of the gaps between the door panels of the cabinetry. Generally, a 1/8 in. (3 mm) vertical and horizontalgap between the door panels is recommended (1). • The door should be at least 5/8 in.
Wine and Undercounter Freestanding Wine Cabinet WS 17800 Appliance Dimensions Wine cooler with three temperature zones. Every temperature zone can be adjusted separately and independent from the other zones. Appliance Dimensions Top view The handle protrudes approx. 1/8" to the left side wall of the appliance.
Wine and Undercounter Cabinet Opening Dimensions Side by Side WS 17800 To avoid condensation on the side walls at side by side applications a minimum distance of 2" between the appliances is required. Optional venting 46 square inches The power cord exits the rear of the appliance at this location. Free length of the power cord is 90". The electrical outlet must not be situated behind the appliance and must be easily accessible. The given cabinet opening height dimension includes 2" for ventilation.
Wine and Undercounter Door Swing Clearance WS 17800 Right side wall of appliance housing Front of appliance housing Top View Do or op en ing an gle 56 ° Door closed 28 The door has its maximum outreach to the right at 56° opening angle.
Wine and Undercounter Door Swing Clearance WS 17800 Right side wall of appliance housing Front of appliance housing Top View Ma xim um do or op en ing an gle 14 5° 29
Wine and Undercounter Undercounter Beverage Center RU 510 IMPORTANT To ensure proper refrigeration performance of the appliance, the ventilation grille supplied must be installed. The ventilation grille must be installed into the toe kick panel. The foam block supplied must be installed in order to ensure the required air flow through the appliance base. R600a Refrigerant Failure to follow this instruction may result in poor refrigeration performance.
Wine and Undercounter Appliance and Cabinet Dimensions Side view Counter depth dimension without cabinet door Height when adjustable feet have been screwed in as far as they will go. Delivery status = feet unscrewed approx. 1/8" . Maximum height adjustment = 2" (51 mm) to allow for a 6" (153 mm) toe kick. The power cord extits the rear of the appliance at this location.
Wine and Undercounter Outdoor Refrigerator RO 510 Appliance Dimensions Side view R600a Refrigerant WARNING! The refrigerant R600a contained within the appliances is environmentally friendly, but flammable. Leaking refrigerant can ignite. Height when adjustable feet have been screwed in as far as they will go. Delivery status = feet approx. 1/8" unscrewed. Maximum height adjustment = 2" (51 mm) To prevent possible ignition, designed ventilation is required.
Wine and Undercounter Dimensions of Appliance Door 33
Wine and Undercounter Accessories Image Article number Name of the item For use with model 7434 557-00 Charcoal Filter WU 3400 WUgb 3400 WU 4500 HWgb 1803 HWgw 1803 7440 999-00 Charcoal Filter HWS 1800 WS 17800 9590 131-00 Overlay Kit WU 3400 WU 4500 RU 510 Includes hinges, brackets, screws and manual. Panel is not included. 9901 647-00 Side by Side Kit Includes angle brackets, screws and installation manual.
Wine and Undercounter Image Article number Name of the item For use with model 9901 651-00 WU 3400 WUgb 3400 WU 4500 RU 510 Angle bracket for cover panel One is included with the appliance. The bracket can be mounted at top or bottom of the appliance.
Wine and Undercounter Accessories Image 36 Article number Name of the item For use with model 7742 052-00 UPR 503 Stainless steel panel (no handle holes)
