ENERGYSTORM ES1500( CA) Oper at i ngI ns t r uc t i ons andOwner ’ sManual PLEASEREADTHI SMANUALCAREFLLYBEFOREOPERATI NGYOURNEW I NVERTERGENERATOR ( CA)i nt h eMo d e lNu mb e rd e s i g n a t e sCa l i f o r n i aCo mp l i a n tb yCARB
Operating Instructions and Owner’s Manual ES1500 PLEASE READ THIS MANUAL CAREFULLY BEFORE OPERATING YOUR NEW PORTABLE GENERATOR
PLEASE READ THE FOLLOWING INSTRUCTIONS! 1. Unit Shipped with “NO OIL” in Engine or where applicable pumps and/or accessories. Check and fill with proper oil as outlined in the Owner’s Manual for the respective product. 2.
Table of Contents Preface 4 Product Specifications 5 Safety Instructions 6 Controls and Features 10 PRE-‐OPERATING INSTRUCTIONS 11 Assembly 11 Generator Setup 12 Operation of Generator 15 Storing the Unit 18 Maintenance 19 Troubleshooting 23 Generator Safety 24
Preface Thank you for choosing LIFAN Power USA for your Power Equipment Needs. LIFAN Power USA prides itself on providing quality products at affordable pricing, creating the “Best Equipment Value on Today’s Market!” All LIFAN Power USA products are manufactured utilizing the latest technology.
PRODUCT5SPECIFICATIONS ENERGY5STORM5PORTABLE5GENERATOR GENERATOR ENGINE Model Manufacturer ES1500 Voltage 120V*AC*&*12V*DC AC5Surge5Output1 2 Rated5AC5Output Maximum5AC5Amperage Engine5Model: 1500*Watts Maximum5Horsepower5(MHP) 1200*Watts Engine5Displacement 12amps*@*120V AC5Cycle Fuel5Tank5Capacity Regulation Adjustable*by*Throttle*Control 120V520amp5AC5Receptacle Run5Time5(@550%5Load) 2*ea.
Safety Instructions This is the safety alert symbol. It is used to alert you to potential personal injury hazards. Obey all safety messages that follow this symbol to avoid possible injury or death. For your safety read this manual carefully.
Safety Instructions (continued) WARNING! Rapid recoil of starter cord (kickback) may pull hand and arm forward toward engine at a rapid rate. Broken bones, bruises, sprains, and fractures may result. When starting engine, pull cord slowly until tension is felt, and then pull rapidly to avoid kickback.
Safety Instructions (continued) WARNING! Fuel and its vapors are extremely flammable and explosive. Fire or explosion can cause severe burns or death. WHEN ADDING OR DRAINING FUEL • • • • Turn generator off and let it cool for at least three minutes before removing fuel cap.
Safety Instructions (continued) WARNING! While engine is running temperature may exceed 150°F (65°C). Server burns may occur. Exhaust heat/gasses can ignite combustibles, structures or damage fuel tank causing a fire. Do NOT touch hot surfaces and do avoid exhaust gasses. Allow generator to cool before touching.
Controls and Features Read this Owner’s Manual Completely and Carefully before Operating Generator. Fuel Tank Fuel Filler Cap Fuel Cock Legend 1. Fuel Filler Cap -‐ Vented Fuel Cap Must be Properly Installed at all times during Operation. 2. Breaker -‐ Electrical Overload Safety Feature. 3.
Pre-‐Operating Instructions: Assembly Your LIFAN Power USA generator is packaged without fuel and oil. Some assembly is required before operating your LIFAN Power USA Generator. For further assistance in assembling your generator please visit our website (www.lifanpowerusa.com) or call 1-‐866-‐471-‐7464 between the hours of 9am-‐5pm Monday-‐Friday.
Pre-‐Operating Instructions: Generator Setup CAUTION: Any attempt to start the generator before it has been properly serviced may result in engine failure and void warranty. ADD ENGINE OIL: Refer to diagram below. 1. Place generator on level surface. 2. Clean area around Oil Hole Dipstick/Plug & Unscrew Oil Hole Dipstick/Plug. 3.
Pre-‐Operating Instructions: Generator Setup (continued) WARNING! Fuel and its vapors are extremely flammable and explosive. Fire or explosion can cause severe burns or death. WHEN ADDING FUEL • • • • Turn generator off and let it cool for a minimum of three minutes before removing fuel cap.
Pre-‐Operating Instructions: Generator Setup (continued) CHECK AIR CLEANER ELEMENT: Refer to “Air Cleaner Maintenance” in the Maintenance section of this Owner’s Manual to ensure Air Cleaner Element is in operable condition. GROUNDING THE GENERATOR: Refer to Controls and Features section. 1.
Operation of Generator HOW TO USE YOUR GENERATOR GENERATOR LOCATION: WARNING! Running generator gives off carbon monoxide gas. It is odorless, colorless, and highly toxic. Breathing carbon monoxide gas can leads to fainting, nausea or may result in death. Only operate generator outdoors.
Operation of Generator HOW TO USE YOUR GENERATOR (continued) CONNECTING ELECTRICAL LOADS: 1. Ensure engine is started before plugging in any electrical appliance. 2. Plug in desired 120 Volt load to the 120 Volt U-‐Ground. Always plug appliances into the generator with appliance in its “OFF” position. 3.
Operation of Generator HOW TO USE YOUR GENERATOR (continued) STOPPING THE GENERATOR: Refer to Controls and Features section for diagram. EMERGENCY SHUTDOWN 1. Turn the Fuel Valve to “OFF” position 1. 2. 3. 4. 5. 6. NORMAL SHUTDOWN Unplug all electrical loads or turn the main breaker to the “OFF” position.
Storing the Unit STORAGE Before long term storage of your power equipment product, typically 30 days or more, perform the following: 1. Set the fuel cock (valve) to the “OFF” position. 2. Let the unit continue to run until it stops itself, burning all of the fuel in the fuel system. 3.
Maintenance MAINTENANCE SCHEDULE PROCEDURE Engine Oil Check TIME Each Use After Each 40 Hours of Use (For Initial Break Replace Engine Oil in – After First (1st) 10 Hours of Use Air Cleaner Filter Check Each Use Air Cleaner Filter When Needed or After Every 100 Hours of Replacement Use Air Cleaner Wash When Needed Spark
Maintenance (continued) OIL CHANGE PROCEDURES (continued): Always use your dipstick to check the oil level and only fill to the full mark on the dipstick. Never overfill the engine as this can cause damage to the unit and void warranty. 5. Replace the dipstick/oil cap on the engine. 6.
Maintenance (continued) SPARK PLUG MAINTENANCE: 1. Remove Spark Plug Cap (refer to "Spark Plug Cap Removal” figure below.) 2. Remove Spark Plug with socket and handle supplied with your unit (refer to “Spark Plug Removal” figure below.) 3. Clean any carbon build-‐up around the Spark Plug. 4.
Maintenance (continued) FUEL SYSTEM MAINTENANCE (continued): diagram below) and either clean or replace the fuel filter element. Re-‐assemble the fuel filter element (refer to “Fuel Filter Element Assembly” diagram below.
Troubleshooting IF THE ENGINE WILL NOT START: 1. Check to ensure switches are in the “ON” position. (Both unit and engine) 2. Check engine oil level. Your unit possesses a Low Oil Alarm System that will not allow your engine to start if the oil is below safe operating levels.
Troubleshooting (continued) UNIT DOES NOT PROVIDE ELECTRICAL CURRENT (continued): 4. If your unit still does NOT produce electricity after performing the previous checks, call LIFAN Power USA at 1-‐866-‐471-‐7464, your dealer, or authorized Service Center. Generator Safety 1.
Wire Diagram ES1500 Wiring Diagram 25 LIFAN Power USA 2205 Industrial Park Road Van Buren, AR 72956 866-‐471-‐7464 www.lifanpowerusa.
Tool/Appliance Rated (Running) Watts Additional Starting Watts Tool/Appliance Rated (Running) Watts Additional Starting Watts 2100 500 1200 540 175 400 750 1000 625 775 1200 0 1000 0 1500 0 0 0 0 0 0 0 500 25 50 100 250 100 500 450 100 100 0 0 0 0 250 0 0 0 0 0 900 1500 1200 550 2400 0 0 0 1000 300 500 1080 1800 0 0 0 2700 4500 1600 750 75 100 900 0 0 0 0 0 HOME ESSENTIALS: KITCHEN: Cell Phone Charger 40 Watt Light Bulb 60 Watt Light Bulb 75 Watt Light Bulb Deep Freezer Electric Water Heat
This worksheet will aid in determining the generator that best fits your needs based on the appliances/tools you wish to power simultaneously! The larger the generator, the more items you may power at once. To Determine the Generator you Require, Follow these Four Easy Steps Below: 1.) Use the "Personal Power Requirements" Chart below, the list the tools/appliances you plan to power simultaneously.
This$warranty$is$limited$to$the$following$LIFAN$Power$and$Storm$Series$products$that$are$distributed$by$the$Equipsource$LLC,$dba$ LIFAN$Power$USA,$located$at$2205$Industrial$Park$Road,$Van$Buren,$AR$72956.
Please Read this Owner’s Manual Carefully Before Operating Your New Generator. This Owner’s Manual includes the operation and maintenance of the ES1500.
Pl e a s eRe a dt hi sma nua lc a r e f u l l yb e f o r eo p e r a t i n gy o u rNe wGe n e r a t o r Tha nkyouf orpu r c ha s i n gourEne r gySt o r mI n v e r t e r . Th i sma n u a li n c l u d e st h eo p e r a t i o na n d ma i nt e na nc eoft h eES1500Mo de l . Al li nf or ma t i oni nt hi spubl i c a t i oni sba s e do nt h el a t e s tp r o d u c ti n f o r ma t i o na v a i l a b l ea tt h et i meo f a ppr ova lf orpr i nt i n g.