Safety Data Sheet according to Regulation (EC) No 1907/2006 Page 1 of 13 SDS No. : 178347 V002.0 Revision: 12.03.2019 printing date: 29.08.2019 Replaces version from: 13.12.2017 LOCTITE 406/770 TAK PAK SECTION 1: Identification of the substance/mixture and of the company/undertaking 1.1. Product identifier LOCTITE 406/770 TAK PAK 1.2. Relevant identified uses of the substance or mixture and uses advised against Intended use: Adhesive 1.3.
SDS No.: 178347 V002.0 LOCTITE 406/770 TAK PAK Page 2 of 13 Signal word: Warning Hazard statement: H315 Causes skin irritation. H319 Causes serious eye irritation. H335 May cause respiratory irritation. Supplemental information EUH202 Cyanoacrylate. Danger. Bonds skin and eyes in seconds. Keep out of the reach of children. Precautionary statement: Prevention P261 Avoid breathing vapors. P280 Wear protective gloves/eye protection.
SDS No.: 178347 V002.0 LOCTITE 406/770 TAK PAK Page 3 of 13 Inhalation: Move to fresh air, consult doctor if complaint persists. Skin contact: Do not pull bonded skin apart. It may be gently peeled apart using a blunt object such as a spoon, preferably after soaking in warm soapy water. Cyanoacrylates give off heat on solidification. In rare cases a large drop will generate enough heat to cause a burn. Burns should be treated normally after the adhesive has been removed from the skin.
SDS No.: 178347 V002.0 LOCTITE 406/770 TAK PAK Page 4 of 13 6.3. Methods and material for containment and cleaning up Do not use cloths for mopping up. Flood with water to complete polymerization and scrape off the floor. Cured material can be disposed of as non-hazardous waste. 6.4. Reference to other sections See advice in section 8 SECTION 7: Handling and storage 7.1.
SDS No.: 178347 V002.
SDS No.: 178347 V002.0 LOCTITE 406/770 TAK PAK Page 6 of 13 Hand protection: Chemical-resistant protective gloves (EN 374). Suitable materials for short-term contact or splashes (recommended: at least protection index 2, corresponding to > 30 minutes permeation time as per EN 374): nitrile rubber (NBR; >= 0.4 mm thickness) Suitable materials for longer, direct contact (recommended: protection index 6, corresponding to > 480 minutes permeation time as per EN 374): nitrile rubber (NBR; >= 0.
SDS No.: 178347 V002.0 LOCTITE 406/770 TAK PAK Oxidising properties Page 7 of 13 No data available / Not applicable 9.2. Other information No data available / Not applicable SECTION 10: Stability and reactivity 10.1. Reactivity Rapid exothermic polymerization will occur in the presence of water, amines, alkalis and alcohols. 10.2. Chemical stability Stable under recommended storage conditions. 10.3. Possibility of hazardous reactions See section reactivity 10.4.
SDS No.: 178347 V002.0 LOCTITE 406/770 TAK PAK Page 8 of 13 Acute inhalative toxicity: No data available. Skin corrosion/irritation: Bonds skin in seconds. Considered to be of low toxicity: acute dermal LD50 (rabbit)>2000mg/kg Due to polymerisation at the skin surface allergic reaction is unlikely to occur Hazardous substances CAS-No.
SDS No.: 178347 V002.0 LOCTITE 406/770 TAK PAK Page 9 of 13 Germ cell mutagenicity: The mixture is classified based on threshold limits referring to the classified substances present in the mixture. Hazardous substances CAS-No. Result Type of study / Route of administration bacterial reverse mutation assay (e.g Ames test) mammalian cell gene mutation assay Metabolic activation / Exposure time in vitro mammalian chromosome aberration test bacterial reverse mutation assay (e.
SDS No.: 178347 V002.0 LOCTITE 406/770 TAK PAK Page 10 of 13 STOT-single exposure: No data available. STOT-repeated exposure:: The mixture is classified based on threshold limits referring to the classified substances present in the mixture. Hazardous substances CAS-No.
SDS No.: 178347 V002.0 LOCTITE 406/770 TAK PAK Page 11 of 13 The mixture is classified based on calculation method referring to the classified substances present in the mixture. Hazardous substances CAS-No.
SDS No.: 178347 V002.0 LOCTITE 406/770 TAK PAK Page 12 of 13 Product disposal: Cured adhesive: Dispose of as water insoluble non-toxic solid chemical in authorised landfill or incinerate under controlled conditions. Dispose of in accordance with local and national regulations.
SDS No.: 178347 V002.0 LOCTITE 406/770 TAK PAK RID ADN IMDG IATA 14.7. Page 13 of 13 not applicable not applicable not applicable Primary packs containing less than 500ml are unregulated by this mode of transport and may be shipped unrestricted. Transport in bulk according to Annex II of Marpol and the IBC Code not applicable SECTION 15: Regulatory information 15.1. Safety, health and environmental regulations/legislation specific for the substance or mixture VOC content <3% (2010/75/EC) 15.2.
Safety Data Sheet according to Regulation (EC) No 1907/2006 Page 1 of 15 SDS No. : 153555 V002.0 Revision: 12.03.2019 printing date: 29.08.2019 Replaces version from: 13.12.2017 LOCTITE 406/770 TAK PAK SECTION 1: Identification of the substance/mixture and of the company/undertaking 1.1. Product identifier LOCTITE 406/770 TAK PAK 1.2. Relevant identified uses of the substance or mixture and uses advised against Intended use: primer 1.3.
SDS No.: 153555 V002.0 LOCTITE 406/770 TAK PAK Page 2 of 15 Hazard pictogram: Contains n-Heptane Signal word: Danger Hazard statement: H225 Highly flammable liquid and vapor. H304 May be fatal if swallowed and enters airways. H315 Causes skin irritation. H336 May cause drowsiness or dizziness. H410 Very toxic to aquatic life with long lasting effects. Precautionary statement: "***" ***For consumer use only: P101 If medical advice is needed, have product container or label at hand.
SDS No.: 153555 V002.0 LOCTITE 406/770 TAK PAK Page 3 of 15 Declaration of the ingredients according to CLP (EC) No 1272/2008: Hazardous components CAS-No. n-Heptane 142-82-5 EC Number REACH-Reg No. 205-563-8 01-2119457603-38 content Classification 50- 100 % Flam. Liq. 2 H225 Asp. Tox. 1 H304 Skin Irrit. 2 H315 STOT SE 3 H336 Aquatic Acute 1 H400 Aquatic Chronic 1 H410 Methylcyclohexane 108-87-2 203-624-3 0,1- < 1 % Flam. Liq. 2 H225 Asp. Tox. 1 H304 Skin Irrit.
SDS No.: 153555 V002.0 LOCTITE 406/770 TAK PAK Page 4 of 15 4.3. Indication of any immediate medical attention and special treatment needed Small amounts of liquid aspirated into the respiratory system during ingestion or from vomiting may cause bronchopneumonia or pulmonary oedema. Do not induce vomiting. Seek medical attention from a specialist. See section: Description of first aid measures SECTION 5: Firefighting measures 5.1.
SDS No.: 153555 V002.0 LOCTITE 406/770 TAK PAK Page 5 of 15 SECTION 8: Exposure controls/personal protection 8.1. Control parameters Occupational Exposure Limits Valid for Great Britain Ingredient [Regulated substance] ppm mg/m3 Value type Heptane 142-82-5 [N-HEPTANE] Heptane 142-82-5 [N-HEPTANE] 500 2.085 Time Weighted Average (TWA): 500 2.
SDS No.: 153555 V002.
SDS No.: 153555 V002.0 LOCTITE 406/770 TAK PAK Page 7 of 15 Hand protection: Chemical-resistant protective gloves (EN 374). Suitable materials for short-term contact or splashes (recommended: at least protection index 2, corresponding to > 30 minutes permeation time as per EN 374): nitrile rubber (NBR; >= 0.4 mm thickness) Suitable materials for longer, direct contact (recommended: protection index 6, corresponding to > 480 minutes permeation time as per EN 374): nitrile rubber (NBR; >= 0.
SDS No.: 153555 V002.0 LOCTITE 406/770 TAK PAK Page 8 of 15 9.2. Other information Ignition temperature 215 °C (419 °F) SECTION 10: Stability and reactivity 10.1. Reactivity Strong oxidizing agents. 10.2. Chemical stability Stable under recommended storage conditions. 10.3. Possibility of hazardous reactions See section reactivity 10.4. Conditions to avoid Stable under normal conditions of storage and use. 10.5. Incompatible materials See section reactivity. 10.6.
SDS No.: 153555 V002.0 LOCTITE 406/770 TAK PAK Page 9 of 15 Acute inhalative toxicity: The mixture is classified based on calculation method referring to the classified substances present in the mixture. Hazardous substances CAS-No.
SDS No.: 153555 V002.0 LOCTITE 406/770 TAK PAK Page 10 of 15 Carcinogenicity No data available. Reproductive toxicity: The mixture is classified based on threshold limits referring to the classified substances present in the mixture. Hazardous substances CAS-No.
SDS No.: 153555 V002.0 LOCTITE 406/770 TAK PAK Page 11 of 15 SECTION 12: Ecological information General ecological information: Do not empty into drains / surface water / ground water. 12.1. Toxicity Toxicity (Fish): The mixture is classified based on calculation method referring to the classified substances present in the mixture. Hazardous substances CAS-No. n-Heptane 142-82-5 Methylcyclohexane 108-87-2 1,8-Diazabicyclo[5.4.
SDS No.: 153555 V002.0 LOCTITE 406/770 TAK PAK Page 12 of 15 The mixture is classified based on calculation method referring to the classified substances present in the mixture. Hazardous substances CAS-No. Methylcyclohexane 108-87-2 Value type EC50 Value Exposure time Species Method 0,134 mg/l 72 h other guideline: Methylcyclohexane 108-87-2 NOEC 0,022 mg/l 72 h 1,8-Diazabicyclo[5.4.0]undec- EC50 7-ene 6674-22-2 1,8-Diazabicyclo[5.4.
SDS No.: 153555 V002.0 LOCTITE 406/770 TAK PAK Hazardous substances CAS-No. n-Heptane 142-82-5 Methylcyclohexane 108-87-2 LogPow Temperature 4,66 Page 13 of 15 Method OECD Guideline 107 (Partition Coefficient (n-octanol / water), Shake Flask Method) other guideline: 3,88 12.5. Results of PBT and vPvB assessment Hazardous substances CAS-No. n-Heptane 142-82-5 1,8-Diazabicyclo[5.4.
SDS No.: 153555 V002.0 LOCTITE 406/770 TAK PAK SECTION 14: Transport information 14.1. UN number ADR RID ADN IMDG IATA 14.2. UN proper shipping name ADR RID ADN IMDG IATA 14.3. Environmentally Hazardous Environmentally Hazardous Environmentally Hazardous Marine pollutant not applicable Special precautions for user ADR RID ADN IMDG IATA 14.7. II II II II II Environmental hazards ADR RID ADN IMDG IATA 14.6. 3 3 3 3 3 Packing group ADR RID ADN IMDG IATA 14.5.
SDS No.: 153555 V002.0 LOCTITE 406/770 TAK PAK Page 15 of 15 15.2. Chemical safety assessment A chemical safety assessment has not been carried out. SECTION 16: Other information The labelling of the product is indicated in Section 2. The full text of all abbreviations indicated by codes in this safety data sheet are as follows: H225 Highly flammable liquid and vapor. H301 Toxic if swallowed. H304 May be fatal if swallowed and enters airways. H314 Causes severe skin burns and eye damage.
