Safety Data Sheet according to Regulation (EC) No 1907/2006 Page 1 of 13 SDS No. : 153541 V006.1 Revision: 23.04.2019 printing date: 28.04.2020 Replaces version from: 16.05.2016 LOCTITE 496 SECTION 1: Identification of the substance/mixture and of the company/undertaking 1.1. Product identifier LOCTITE 496 1.2. Relevant identified uses of the substance or mixture and uses advised against Intended use: Adhesive 1.3.
SDS No.: 153541 V006.1 LOCTITE 496 Page 2 of 13 Signal word: Warning Hazard statement: H315 Causes skin irritation. H319 Causes serious eye irritation. H335 May cause respiratory irritation. Supplemental information EUH202 Cyanoacrylate. Danger. Bonds skin and eyes in seconds. Keep out of the reach of children. Precautionary statement: Prevention P261 Avoid breathing vapors. P280 Wear protective gloves/eye protection.
SDS No.: 153541 V006.1 LOCTITE 496 Page 3 of 13 Skin contact: Do not pull bonded skin apart. It may be gently peeled apart using a blunt object such as a spoon, preferably after soaking in warm soapy water. Cyanoacrylates give off heat on solidification. In rare cases a large drop will generate enough heat to cause a burn. Burns should be treated normally after the adhesive has been removed from the skin.
SDS No.: 153541 V006.1 LOCTITE 496 Page 4 of 13 6.4. Reference to other sections See advice in section 8 SECTION 7: Handling and storage 7.1. Precautions for safe handling Ventilation (low level) is recommended when using large volumes Use of dispensing equipment is recommended to minimise the risk of skin or eye contact Hygiene measures: Good industrial hygiene practices should be observed. Wash hands before work breaks and after finishing work. Do not eat, drink or smoke while working. 7.2.
SDS No.: 153541 V006.
SDS No.: 153541 V006.1 LOCTITE 496 Page 6 of 13 Hand protection: Chemical-resistant protective gloves (EN 374). Suitable materials for short-term contact or splashes (recommended: at least protection index 2, corresponding to > 30 minutes permeation time as per EN 374): nitrile rubber (NBR; >= 0.4 mm thickness) Suitable materials for longer, direct contact (recommended: protection index 6, corresponding to > 480 minutes permeation time as per EN 374): nitrile rubber (NBR; >= 0.
SDS No.: 153541 V006.1 LOCTITE 496 Explosive properties Oxidising properties Page 7 of 13 No data available / Not applicable No data available / Not applicable 9.2. Other information No data available / Not applicable SECTION 10: Stability and reactivity 10.1. Reactivity Rapid exothermic polymerization will occur in the presence of water, amines, alkalis and alcohols. 10.2. Chemical stability Stable under recommended storage conditions. 10.3.
SDS No.: 153541 V006.1 LOCTITE 496 Page 8 of 13 Acute inhalative toxicity: No data available. Skin corrosion/irritation: Bonds skin in seconds. Considered to be of low toxicity: acute dermal LD50 (rabbit)>2000mg/kg Due to polymerisation at the skin surface allergic reaction is unlikely to occur Hazardous substances CAS-No.
SDS No.: 153541 V006.1 LOCTITE 496 Page 9 of 13 Carcinogenicity The mixture is classified based on threshold limits referring to the classified substances present in the mixture. Hazardous components CAS-No.
SDS No.: 153541 V006.1 LOCTITE 496 Page 10 of 13 SECTION 12: Ecological information General ecological information: Biological and Chemical Oxygen Demands (BOD and COD) are insignificant. Do not empty into drains / surface water / ground water. 12.1. Toxicity Toxicity (Fish): The mixture is classified based on calculation method referring to the classified substances present in the mixture. Hazardous substances CAS-No.
SDS No.: 153541 V006.1 LOCTITE 496 Page 11 of 13 12.3. Bioaccumulative potential No data available. No substance data available. 12.4. Mobility in soil Cured adhesives are immobile. Hazardous substances CAS-No. Hydroquinone 123-31-9 LogPow Temperature 0,59 Method EU Method A.8 (Partition Coefficient) 12.5. Results of PBT and vPvB assessment Hazardous substances CAS-No.
SDS No.: 153541 V006.1 LOCTITE 496 Page 12 of 13 SECTION 14: Transport information 14.1. UN number ADR RID ADN IMDG IATA 14.2. UN proper shipping name ADR RID ADN IMDG IATA 14.3. not applicable not applicable not applicable not applicable not applicable Special precautions for user ADR RID ADN IMDG IATA 14.7. Not dangerous goods Not dangerous goods Not dangerous goods Not dangerous goods III Environmental hazards ADR RID ADN IMDG IATA 14.6.
SDS No.: 153541 V006.1 LOCTITE 496 Page 13 of 13 SECTION 16: Other information The labelling of the product is indicated in Section 2. The full text of all abbreviations indicated by codes in this safety data sheet are as follows: H302 Harmful if swallowed. H315 Causes skin irritation. H317 May cause an allergic skin reaction. H318 Causes serious eye damage. H319 Causes serious eye irritation. H335 May cause respiratory irritation. H341 Suspected of causing genetic defects.
