Safety Data Sheets (SDS)

ManualsBrandsLoctite ManualsCaulk & SealantsPL 28 oz. Gray Self-Leveling Concrete Sealant (12-Pack)

Safety Data Sheet

Revision Number: 004.0

Issue date: 07/21/2015

IDH number: 1618172

Product name: Loctite® PL® Polyurethane Self Leveling Concrete Sealant

Page 1 of 7

1. PRODUCT AND COMPANY IDENTIFICATION

Product name:

Loctite® PL® Polyurethane Self

Leveling Concrete Sealant

IDH number:

1618172

Product type:

Sealant

Restriction of Use:

None identified

Region:

United States

Company address:

Contact information:

Henkel Corporation

One Henkel Way

Rocky Hill, Connecticut 06067

Telephone: +1 (800) 624-7767

MEDICAL EMERGENCY Phone: Poison Control Center 1-877-671-

4608 (toll free) or 1-303-592-1711 TRANSPORT EMERGENCY

Phone: CHEMTREC 1-800-424-9300 (toll free) or 1-703-527-3887

2. HAZARDS IDENTIFICATION

EMERGENCY OVERVIEW

DANGER:

ABRASION COULD RELEASE RESPIRABLE PARTICLES OF SILICA QUARTZ,

A CANCER HAZARD BY INHALATION. NORMAL USE OF THIS PRODUCT

CAUSES NO SUCH RELEASE.

COMBUSTIBLE LIQUID.

CAUSES SKIN IRRITATION.

MAY CAUSE AN ALLERGIC SKIN REACTION.

CAUSES SERIOUS EYE IRRITATION.

MAY CAUSE ALLERGY OR ASTHMA SYMPTOMS OR BREATHING

DIFFICULTIES IF INHALED.

MAY CAUSE RESPIRATORY IRRITATION.

HAZARD CLASS

HAZARD CATEGORY

FLAMMABLE LIQUID

SKIN IRRITATION

EYE IRRITATION

RESPIRATORY SENSITIZATION

SKIN SENSITIZATION

SPECIFIC TARGET ORGAN TOXICITY - SINGLE EXPOSURE

PICTOGRAM(S)

Precautionary Statements

Prevention:

Keep away from heat, sparks, open flames, hot surfaces - no smoking. Avoid breathing vapors,

mist, or spray. Wash thoroughly after handling. Use only outdoors or in a well-ventilated area.

Contaminated work clothing should not be allowed out of the workplace. Wear protective

gloves, eye protection, and face protection. In case of inadequate ventilation wear respiratory

protection.

Response:

IF ON SKIN: Wash with plenty of water. IF INHALED: Remove person to fresh air and keep

comfortable for breathing.

IF IN EYES: Rinse cautiously with water for several minutes. Remove contact lenses, if

present and easy to do. Continue rinsing. If skin irritation or rash occurs: Get medical attention.

Summary of content (7 pages)

PAGE 1
Safety Data Sheet Revision Number: 004.0 Issue date: 07/21/2015 1.
PAGE 2
If eye irritation persists: Get medical attention. If experiencing respiratory symptoms: Call a poison center or physician. Take off contaminated clothing. In case of fire: Use foam, dry chemical or carbon dioxide to extinguish. Store in a well-ventilated place. Keep container tightly closed. Store in a well-ventilated place. Keep cool. Store locked up. Dispose of contents and/or container according to Federal, State/Provincial and local governmental regulations.
PAGE 3
Hazardous combustion products: Nitrous gases Irritating fumes. Isocyanate vapors. 6. ACCIDENTAL RELEASE MEASURES Use personal protection recommended in Section 8, isolate the hazard area and deny entry to unnecessary and unprotected personnel. Environmental precautions: Ventilated area. Wear appropriate protective equipment and clothing during clean-up. Prevent further leakage or spillage if safe to do so. Do not allow product to enter sewer or waterways.
PAGE 4
Respiratory protection: Observe OSHA regulations for respirator use (29 CFR 1910.134). Use a NIOSH approved air-purifying respirator if the potential to exceed established exposure limits exists. Respirator with combination filter for vapor/particulate. Eye/face protection: Safety glasses with side-shields. Full face protection should be used if the potential for splashing or spraying of product exists.
PAGE 5
Potential Health Effects/Symptoms Inhalation: Skin contact: Eye contact: Ingestion: Hazardous Component(s) As a result of previous repeated overexposures or a single large dose, certain individuals will develop isocyanate sensitization (chemical asthma) which will cause them to react to a later exposure to isocyanate at levels well below the TLV. Chronic overexposure to isocyanates has been reported to cause lung damage.
PAGE 6
13. DISPOSAL CONSIDERATIONS Information provided is for unused product only. Recommended method of disposal: Dispose of according to Federal, State and local governmental regulations. Hazardous waste number: U223: Toluene Diisocyanate. It is the responsibility of the user to determine if an item is hazardous as defined in the Resource Conservation and Recovery Act (RCRA) at the time of disposal. Product uses, transformations, mixtures, processes, etc.
PAGE 7
16. OTHER INFORMATION This safety data sheet contains changes from the previous version in sections: This Safety Data Sheet contains changes from the previous version in Section(s): 3, 8, 11, 15 Prepared by: Mary Ellen Roddy, Sr. Regulatory Affairs Specialist Issue date: 07/21/2015 DISCLAIMER: The data contained herein are furnished for information only and are believed to be reliable.