SDS

IDH number: 234790
Product name: Loctite® Super Glue Control™ Gel
Page 3 of 6
Clean-up methods:
Do not use cloths for mopping up. Flood with water to complete
polymerization and scrape off the floor. Cured material can be disposed of as
non-hazardous waste. Refer to Section 8 "Exposure Controls / Personal
Protection" prior to clean up.
7. HANDLING AND STORAGE
Handling:
Prevent contact with eyes, skin and clothing. Do not breathe vapor and mist.
Wash thoroughly after handling. Avoid contact with fabric or paper goods.
Contact with these materials may cause rapid polymerization which can
generate smoke and strong irritating vapors, and cause thermal burns.
Storage:
Keep in a cool, well ventilated area away from heat, sparks and open flame.
Keep container tightly closed until ready for use.
For information on product shelf life contact Henkel Customer Service at [phone].
8. EXPOSURE CONTROLS / PERSONAL PROTECTION
Employers should complete an assessment of all workplaces to determine the need for, and selection of, proper exposure
controls and protective equipment for each task performed.
Hazardous Component(s)
ACGIH TLV
OSHA PEL
AIHA WEEL
OTHER
Ethyl 2-cyanoacrylate
0.2 ppm TWA
None
None
None
Filler
10 mg/m3 TWA
Inhalable dust.
3 mg/m3 TWA
Respirable fraction.
15 mg/m3 TWA Total
dust.
5 mg/m3 TWA
Respirable fraction.
None
None
Thickener
None
None
None
None
Engineering controls:
Use positive down-draft exhaust ventilation if general ventilation is insufficient
to maintain vapor concentration below established exposure limits.
Respiratory protection:
Use NIOSH approved respirator if there is potential to exceed exposure
limit(s).
Eye/face protection:
Safety goggles or safety glasses with side shields. Full face protection should
be used if the potential for splashing or spraying of product exists.
Skin protection:
Use nitrile gloves and aprons as necessary to prevent contact. Do not use
PVC, nylon or cotton.
9. PHYSICAL AND CHEMICAL PROPERTIES
Physical state:
Gel, Liquid
Color:
Colorless
Odor:
Irritating
Odor threshold:
Not available.
pH:
Not available.
Vapor pressure:
Not available.
Boiling point/range:
> 100 °C (> 212°F) None
Melting point/ range:
Not available.
Vapor density:
Not available.
Flash point:
80 - 93 °C (176°F - 199.4 °F)
Flammable/Explosive limits - lower:
Not available.
Flammable/Explosive limits - upper:
Not available.
Autoignition temperature:
Not available.
Evaporation rate:
Not available.
Solubility in water:
Polymerises in presence of water.
Partition coefficient (n-octanol/water):
Not available.
VOC content:
< 2 %; < 20 g/l (California SCAQMD Method 316B) (Estimated)
Viscosity:
Not available.
Decomposition temperature:
Not available.