Installation GUIDE PRONGK1 / PROLPK1 Conversion Kit for 30” / 36” / 42” / 54” Outdoor Grills Power Burner Accessory Side Burner Accessory 1
IMPORTANT: PLEASE READ AND FOLLOW 1. Before beginning, please read these instructions completely and carefully. 2. Do not remove permanently affixed labels, warnings, or plates from product. This may void the warranty. 3. Please observe all local and national codes and ordinances. CAUTION: Before proceeding with the conversion, shut off the gas supply to the appliance prior to disconnecting the electrical power.
IMPORTANT: PLEASE READ AND FOLLOW GAS PLUMBING REQUIREMENTS • A pressure regulator must be installed on all gas equipment. All local codes require that a pressure regulator be installed. Removing or failing to install the pressure regulator can result in fire and serious bodily harm. • An installer supplied gas shut-off valve must be installed in an easily accessible location for all hardplumbed natural gas and liquid propane applications.
Converting the Grill Burners Refer to the chart to install correct orifices. Outdoor Grills • • • • • • • • • • • • • Remove cooking grates and briquette trays. Remove the main burners, lift up and then back, up and out. Remove the sear burner and lift up and then back, up and out. Maintenance: check burner throat for spider webs, run a bottle brush around the inside diameter, wire brush over burner to insure ports are clear. Using the ½” deep socket remove the orifices from the burner valves.
Checking for Gas Leaks WARNING To prevent fire or explosion hazard, DO NOT smoke or allow any potential source of ignition (sparks, electrical arcing, etc) in the area while performing a leak test. Leak tests should be conducted outdoors only. Never conduct a leak test using fire or flame. Create a soapy solution of 1 part soap and 3 parts water. • Confirm that all control knobs are in the off position. • Turn on the fuel supply. For natural gas, turn the valve handle 1/4 turn to align with the gas flow.
Final Preparation Note: When the conversion is complete, place the labels below in the required locations.
