COMMERCIAL COOKING APPLIANCES Model NPG-30 & NPG-60 Charbroiler Fixed Fuel Supply System Natural Gas and Propane Gas Use and Care Instructions Model # _________________________ Serial # __________________________ Date: ___________________________ Retain this Manual for future reference ANSI Z83.11a • CGA 1.8a-1997 509 Route 3A Bow, NH 03304 Voice (603) 225-6684 FAX (603) 225-8472 WWW.MAGIKITCHN.
TABLE OF CONTENTS 1. Safety Information 1 2. Charbroiler Assembly Instructions 3 3. Installation Instructions 4 4. Assembly Diagram 5 5. Operating, Lighting and Cleaning Instructions 6 6. Charbroiler Illustration and Parts List 7 7. Burner & Orifice Inspection 9 8. Options 9 9.
1. SAFETY INFORMATION Safety instructions should be obtained from your local gas supplier and posted in a prominent location near the area of operation. These instructions are to be followed in the event of a gas leak. FOR YOUR SAFETY DO NOT STORE OR USE GASOLINE OR OTHER FLAMMABLE VAPORS OR LIQUIDS IN THE VICINITY OF THIS OR ANY OTHER APPLIANCE. WARNING Improper installation, adjustment, alteration, service or maintenance can cause property damage, injury or death.
1. SAFETY INFORMATION (continued) • When the unit is not in use, the gas supply must be shut off at the main valve. • Minimum temperature for proper operation of the unit is 50°F (10°C). • When this unit is in operation, exterior surfaces may be hot enough to cause serious injury. • Do not locate this appliance under overhead unprotected combustible surfaces. • For installation in noncombustible location only. • For use only with the pressure regulator and piping assembly supplied with unit.
2. CHARBROILER ASSEMBLY INSTRUCTIONS These unassembled parts should be included in your charbroiler package, (Figure 1, Page 5): Item Number 1 2 6 8 9 10 24 C Description Cooking Grid (s) Radiants Burner Covers Frame Assembly Runner Tube Cover(s) Water Tub(s) Base Legs and Swivel Lock Casters Main Valve and Regulator Assembly A. Remove shipping bands from carton. B. Remove top of carton. C. Remove cooking grids(s), (1) from unit and set aside. D.
3. INSTALLATION INSTRUCTIONS • • • • Units may be installed with 0” minimum clearance from sides and back to non-combustible construction in areas that are non-combustible locations. This unit is not approved for installations in combustible constructions. Install the main valve and regulator piping assembly (C in Figure 1). This installation must conform to local codes. In the absence of local codes, the installation must conform with National Fuel Gas Code, ANSI Z223.
4.
5. OPERATION, LIGHTING and CLEANING • (Use Figure 2) Assemble unit per installation/assembly instructions. • Fill water tubs to within ½” of top edges (this will control grease flare-ups, provide for ease of cleaning and keep cooked foods moist). Re-fill tubs with water when they evaporate to within ½” of the bottom of the tubs. Failure to keep water in the water tubs will lead to grease fires and will void the warranty. Lighting Instructions A. Open the cooking hood, if so equipped.
6.
NPG CHARBROILER PARTS LIST (Continued) Item # 1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18 19 20 21 22 23 24 26 27 28 29 30 31 32 33 34 35 37 38 39 40 Description Cooking Top Grid, Heave Duty Cooking Top Grid, Standard Radiant Screw & Nut, ¼-20 x 1-1/2” Screw & Nut, ¼-20 x ½” Burner Frame Assembly Runner Tube Bracket Runner Tube Cover Water Tub Base Assembly Runner Tube, LH, Natural Gas, Runner Tube, LH, Propane Gas Runner Tube, RH, Natural Gas Runner Tube, RH, Propane Gas Runner Supply Tube End cap, RH, f
7. BURNER & ORIFICE INSPECTION A. Remove the service shelf by removing the two screws at the ends (29). B. Slide service shelf (30) forward and then lift it off the unit. C. The front of the burners, the valve bodies, and orifices are now exposed for inspection. Looking down into the unit, compare these components with the diagram above (Figure 3). D. If the components ARE NOT aligned as shown in the diagram, DISCONTINUE USE and contact the manufacturer. E.
9. WARRANTY: MagiKitch’n appliances are designed to give you long and satisfactory service if installed and operated in accordance with our instructions. This machine has been carefully tested, but in spite of such tests, there may be a defect not immediately noticeable. To protect you, we warrant this appliance against defective workmanship and material for 1 year from the date of shipment. NOT WARRANTED: Accident to, misuse of, harsh chemical cleaners, or natural wear of this appliance.
