Owner manual

1-800-MAGLINE (624-5463) Page 16 www.magliner.com
CooLift
®
The unit does not turn on.
 Is the main switch turned on?
 Has the battery been charged?
 Has the circuit breaker been tripped?
 Is the battery box fully plugged in?
 Check electrical connections for tightness, including battery terminals within the battery box.
The pump is running but the deck is not lifting.
 Is the uid level correct in the reservoir?
 Do you see any leaks in the hydraulic system?
 Is the manual pump release valve open?
 Is the breather cap for the pump reservoir plugged?
The deck lifts to the top position but then gradually lowers.
 Is the manual release valve fully closed?
 Do you see any leaks in the hydraulic system?
The deck lifts OK but lowers slowly.
 Does it go down quicker when opening the manual release valve?
 Do you see any uid leaking out of the gas springs?
The deck lifts slower than usual.
 Is the manual release valve closed all the way?
 Is the uid level correct in the reservoir?
 Do you see any leaks in the hydraulic system?
The brakes are not working or braking unevenly side to side.
 Do you see any leaks in the brake system?
 Is the brake uid level correct in the reservoir?
 If you pump the brake lever several times, does it start working?
 Are both of the calipers mounted tightly to the rail?
The CooLift is not charging up.
 Is the charger working correctly?
 Is the battery box connected correctly?
 Will the batteries charge up when using the charging port located on the side of the battery
box?
 Have all electrical connections been checked?
 Is the internal charger switch in the ON position?
 Is the power plug plugged in the charger socket?
 Is the charger ouput cord plugged into the battery pack charger port?
Troubleshooting