Operator`s manual

ENGINE SAFETY

Internal combustion engines present special hazards during operation and fueling! Failure to follow the

safety guidelines described below could result in severe injury or death. Read and follow all safety warnings

described in the engine operator's manual. A copy of this manual was supplied with unit when it was

shipped from the factory.

• DO NOT run engine indoors or in an area with poor ventilation. Diesel engine exhaust contains carbon

monoxide, a deadly, odorless and colorless gas which, if inhaled, can cause nausea, fainting or death.

Only use this unit outside and away from windows, doors and ventillation equipment.

• DO NOT fill fuel tank near an open flame, while smoking, or while engine is running. DO NOT fill tank

in an enclosed area with poor ventilation.

• DO NOT operate with the fuel tank cap loose or missing.

• DO NOT touch or lean against hot exhaust pipes or engine cylinders.

• DO NOT clean air filter with gasoline or other types of low flash point solvents.

• DO NOT remove engine coolant cap while engine is hot.

• DO NOT operate the unit without a functional exhaust system. Prolonged exposure to sound levels

in excess of 85 DBA can cause permanent hearing loss. Wear hearing protection when working around

a running engine.

• Keep hands, feet and loose clothing away from moving parts on the generator and engine.

• Keep area around exhaust pipes and air ducts free of debris to reduce the chance of an accidental fire.

• Batteries contain sulfuric acid which can cause severe injury or death. Sulfuric acid can cause eye

damage, burn flesh or eat holes in clothing. Protective eye wear and clothing are necessary when

working on or around the battery. Always disconnect the NEGATIVE (-) battery cable from the

corresponding terminal before performing any service on the engine or other components..

ELECTRICAL SAFETY

The unit is powered by a generator driven by a diesel engine. While the engine is running, potentially

lethal voltages are present at the 120V Ground Fault Circuit Interrupt (GFCI) outlets and the 240V twist

lock outlets located on the control panel, and at the connection lugs and cam lock receptacles. Failure to

follow the safety guidelines described below could result in severe injury or death.

• Only a qualified and licensed electrician should make connections to the generator.

• NEVER wash the unit with any high pressure hoses or power washers.

• NEVER start the unit under load. The circuit breakers must be in the “OFF” position when starting the

unit in MANUAL mode. The circuit breakers can be in the “ON” position only when started in the AUTO

mode. A transfer switch must be used in the AUTO mode to deflect the load upon start up.

• ALWAYS disconnect the NEGATIVE (-) battery cable from the corresponding terminal before

performing any service on the engine, generator or any other components. Remove the NEGATIVE

(-) battery cable from the corresponding terminal if the unit is to be stored or transported.

• ALWAYS use extreme caution when servicing this unit in damp conditions. Do not service the unit if

your skin or clothing is wet. Do not allow water to collect around the base of the unit.

• ALWAYS connect the unit to a good earthen ground before use. Follow any local, state or United

States National Electric Code (NEC) guidelines.