Owner's Manual

ManualsBrandsMajestic ManualsFireplacesDirect Vent Natural Gas Fireplace

Hearth & Home Technologies • LCOR-DV36IN, RCOR-DV36IN Owner’s Manual • 2486-981 Rev. D • 7/18

Owner’s Manual

Care and Operation

INSTALLER: Leave this manual with party responsible for use and operation.

OWNER: Retain this manual for future reference.

Contact your dealer with questions regarding installation, operation or service.

NOTICE: DO NOT discard this manual!

This appliance may be installed as an OEM

installation in manufactured home (USA

only) or mobile home and must be installed

in accordance with the manufacturer’s

instructions and the Manufactured Home

Construction and Safety Standard, Title 24

CFR, Part 3280 in the United States, or the

Standard for Installation in Mobile Homes,

CAN/CSA Z240 MH Series, in Canada.

This appliance is only for use with the type(s)

of gas indicated on the rating plate. This

appliance is not convertible for use with other

gases, unless a certied kit is used.

In the Commonwealth of Massachusetts installation must be

performed by a licensed plumber or gas tter.

See appliance installation manual for additional

Commonwealth of Massachusetts requirements.

DANGER

HOT GLASS WILL

CAUSE BURNS.

DO NOT TOUCH GLASS

UNTIL COOLED.

NEVER ALLOW CHILDREN

TO TOUCH GLASS.

A barrier designed to reduce the risk of

burns from the hot viewing glass is provided

with this appliance and shall be installed for

the protection of children and other at-risk

individuals.

• DO NOT store or use gasoline or other am-

mable vapors and liquids in the vicinity of this

or any other appliance.

• What to do if you smell gas

- DO NOT try to light any appliance.

- DO NOT touch any electrical switch. DO

NOT use any phone in your building.

- Leave the building immediately.

- Immediately call your gas supplier from

a neighbor’s phone. Follow the gas sup-

plier’s instructions.

- If you cannot reach your gas supplier, call

the re department.

• Installation and service must be performed

by a qualied installer, service agency, or the

gas supplier.

WARNING:

FIRE OR EXPLOSION HAZARD

Failure to follow safety warnings exactly

could result in serious injury, death, or

property damage.

Models:

LCOR-DV36IN

RCOR-DV36IN

Summary of content (28 pages)

PAGE 1
Owner’s Manual Care and Operation INSTALLER: Leave this manual with party responsible for use and operation. OWNER: Retain this manual for future reference. Contact your dealer with questions regarding installation, operation or service. NOTICE: DO NOT discard this manual! Models: LCOR-DV36IN RCOR-DV36IN WARNING: FIRE OR EXPLOSION HAZARD Failure to follow safety warnings exactly could result in serious injury, death, or property damage.
PAGE 2
1 Welcome Read this manual before operating this appliance. Please retain this Owner’s Manual for future reference. Read the Installation Manual before making any installation or finishing changes. This owner’s manual should be retained for future A. Congratulations reference. We suggest that you keep it with your other important documents and product manuals. Congratulations on selecting a Hearth & Home Technologies gas fireplace, an elegant and clean alternative to wood burning fireplaces.
PAGE 3
Safety Alert Key: • • • • DANGER! Indicates a hazardous situation which, if not avoided will result in death or serious injury. WARNING! Indicates a hazardous situation which, if not avoided could result in death or serious injury. CAUTION! Indicates a hazardous situation which, if not avoided, could result in minor or moderate injury. NOTICE: Used to address practices not related to personal injury. Table of Contents 1 Welcome A. Congratulations . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
PAGE 4
B. Limited Lifetime Warranty Hearth & Home Technologies LIMITED LIFETIME WARRANTY Hearth & Home Technologies, on behalf of its hearth brands (“HHT”), extends the following warranty for HHT gas, wood, pellet, coal and electric hearth appliances that are purchased from an HHT authorized dealer.
PAGE 5
B. Limited Lifetime Warranty (continued) WARRANTY CONDITIONS: • • • • • This warranty only covers HHT appliances that are purchased through an HHT authorized dealer or distributor. A list of HHT authorized dealers is available on the HHT branded websites. This warranty is only valid while the HHT appliance remains at the site of original installation. This warranty is only valid in the country in which the HHT authorized dealer or distributor that sold the appliance resides.
PAGE 6
2 Product Specific Information A. Appliance Certification MODELS: LCOR-DV36IN, RCOR-DV36IN LABORATORY: Underwriters Laboratories, Inc. (UL) TYPE: Direct Vent Heater STANDARD: ANSI Z21.88-2017 • CSA 2.33-2017  This product is listed to ANSI standards for “Vented Gas Fireplace Heaters” and applicable sections of “Gas Burning Heating Appliances for Manufactured Homes and Recreational Vehicles”, and “Gas Fired Appliances for Use at High Altitudes”. NOTICE: This installation must conform with local codes.
PAGE 7
3 Important Safety and Operating Information A. Appliance Safety • Teach children to NEVER touch the fireplace. WARNING! DO NOT operate fireplace before reading and understanding operating instructions. Failure to operate fireplace according to operating instructions could cause fire or injury. • Consider not using the fireplace when children will be present. DANGER HOT GLASS WILL CAUSE BURNS. DO NOT TOUCH GLASS UNTIL COOLED. NEVER ALLOW CHILDREN TO TOUCH GLASS. • Keep children away.
PAGE 8
D. Good Faith Wall Surface/TV Guidelines B. General Operating Parts TO CEILING Figure 3.2 references the general operating parts of the appliance and the section of this manual in which they are discussed. 90°F 90°F FIREPLACE OPENING 95°F 95°F 48 in. 42 in. 100°F 36 in. 110°F 30 in. DECORATIVE DOORS (NOT SHOWN) SECTION 4.B. 120°F 130°F FIXED GLASS ASSEMBLY (NOT SHOWN) SECTION 4.B. 24 in. 18 in. 12 in. 6 in. MEASUREMENTS FROM TOP EDGE OF THE OPENING MANTEL FAN KIT SECTION 3.H & SECTION 3.
PAGE 9
Good Faith Guidelines for TV Installa ons above a Typical Gas Fireplace TV recessed into the wall TV on the wall TV TV Wall Bracket Item A B C A D Minimum Dimensions 2.5 inches 2 inches minimum to 3 inches maximum 18 inches Wall Brkt + TV Thickness + 2.5 inches B B Mantel D Fireplace A C C Fireplace Notes: 1. These are good faith recommended clearances only and not a guarantee of compliance with all TV manufacturers’ maximum allowable opera ng temperatures. 2.
PAGE 10
E. Before Lighting Appliance Before operating this fireplace for the first time, have a qualified service technician: • Verify all shipping materials have been removed from inside and/or underneath the firebox. • Review proper placement of logs, ember material and/or other decorative materials. • Check the wiring. • Check the air shutter adjustment. • Ensure that there are no gas leaks. • Ensure that the glass is sealed and in the proper position and that the integral barrier is in place.
PAGE 11
 F. Lighting Instructions (IPI) FOR YOUR SAFETY READ BEFORE LIGHTING WARNING A. This appliance is equipped with an intermittent pilot ignition (IPI) device which automatically lights the burner. DO NOT try to light the burner by hand. • Immediately call your gas supplier from a neighbor’s phone. Follow the gas supplier’s instructions. B. BEFORE LIGHTING, smell all around the appliance area for gas. Be sure to smell • WHAT TO DO IF YOU SMELL GAS C.
PAGE 12
G. Appliance Break-In Follow the initial break-in procedure below to cure the materials used to manufacture the fireplace and the finishing materials around it. • The fireplace should be run three to four hours continuously on high. • Turn the fireplace off and allow it to cool completely. • Remove fixed glass assembly. See Section 4.B. • Clean fixed glass assembly. See Section 4. • Replace the fixed glass assembly and run continuously on high an additional 12 hours.
PAGE 13
I. Operation During A Power Outage - Intellifire™ Touch The Intellifire™ Touch intermittent pilot ignition system comes with a battery backup system that enables the system to operate in a power outage. The system offers seamless transition from household AC power to battery backup. A factory-installed battery pack is located in the control cavity of the appliance. See Figure 3.5. Battery longevity and performance will be affected by long term exposure to the service temperatures of this appliance.
PAGE 14
J. Detailed Component Operating Instructions - Intellifire™ Touch IFT-ECM Detailed Operating Instruction The IFT-RC400 and IFT-RC150 remotes are an option for the LCOR-DV36IN/RCOR-DV36IN models. 1. The Electronic Control Module (IFT-ECM) has a three-position ON/OFF/REMOTE selector switch that must be set for proper operation. See Figure 3.6. When changing switch positions,it is important to pause in each position for 1-2 seconds. firebox to reduce condensation in cool, high humidity ambient conditions.
PAGE 15
- Wait five (5) minutes to allow possible accumulated gas to clear. - Set the IFT-ECM 3-position selector switch to ON or IFT-REM position. Module will beep once and flash a three GREEN LED code on successful startup. - If placed in ON position, the appliance will ignite normally if the error condition was corrected. - If placed in IFT-REM position, use the paired IFTRC400, IFT-RC150 or wired wall switch to start the appliance; appliance will ignite normally if the error condition was corrected.
PAGE 16
4 Maintenance and Service Any safety screen or guard removed for servicing must be replaced prior to operating the fireplace. When properly maintained, your fireplace will give you many years of trouble-free service. Contact your dealer to answer questions regarding proper operation, troubleshooting and service for your appliance. Visit www. hearthnhome.com to locate a dealer. We recommend annual service by a qualified service technician. A.
PAGE 17
Surrounds, Decorative Fronts Frequency: Annually By: Homeowner Tools needed: Protective gloves, stable work surface • Assess condition of screen and replace as necessary. LATCHES (BOTH BOTTOM AND TOP) • Inspect for scratches, dents or other damage and repair as necessary. • Check that louvers are not blocked. • Vacuum and dust surfaces. GLASS ASSEMBLY Optional Remote Control Figure 4.
PAGE 18
C. Maintenance Tasks - Qualified Service Technician Burner Ignition and Operation The following tasks must be performed by a qualified service technician. By: Qualified Service Technician Gasket Seal and Glass Assembly Inspection Frequency: Annually Frequency: Annually Tools needed: Protective gloves, vacuum cleaner, whisk broom, flashlight, voltmeter, indexed drill bit set, and a manometer. By: Qualified Service Technician • Verify burner is properly secured and aligned with pilot or igniter.
PAGE 19
5 Frequently Asked Questions and Troubleshooting A. Frequently Asked Questions - Appliance ISSUE SOLUTIONS Condensation on the glass This is a result of gas combustion and temperature variations. As the fireplace warms, this condensation will disappear. Blue flames This is a result of normal operation and the flames will begin to yellow as the fireplace is allowed to burn for 20 to 40 minutes. Odor from fireplace When first operated, this fireplace may release an odor for the first several hours.
PAGE 20
B. Frequently Asked Questions - IntelliFire™ Touch Controls (IFT-RC400) (Optional Remote) Symptom The appliance does not respond to commands from the remote control display does not light up when screen is touched. Possible Cause Corrective Action Batteries are depleted. Verify batteries are new. Batteries are incorrectly oriented. Verify batteries are installed in correct orientation as shown on batteries receptacle. Touchscreen has lost calibration. Touchscreen needs to be re-calibrated.
PAGE 21
C. Troubleshooting With proper installation, operation, and maintenance your gas appliance will provide years of trouble-free service. If you do experience a problem, this troubleshooting guide will assist a qualified service technician in the diagnosis of a problem and the corrective action to be taken. This troubleshooting guide can only be used by a qualified service technician. Contact your dealer to arrange a service call by a qualified service technician.
PAGE 22
Intellifire™ Touch - (continued) Symptom Pilot sparks for 60 sec, but will not light, 3 Red/1 Green Lockout. Pliot lights but main burner does not light. Pilot continues to spark for 60 sec then goes into 3 Red/1 Green Lockout. Pilot lights and rectifies, but main burner does not light. Pilot and main do not light, ECM goes into 5 Red/1 Green Lockout. Appliance lights and runs for a few minutes then shuts down and/or appliance cycle ON and OFF with less than 60 sec of ON time.
PAGE 23
6 Reference Materials A. Accessories Install approved accessories per instructions included with accessories. Contact your dealer for a list of approved accessories. WARNING! Risk of Fire and Electric Shock! Use ONLY Hearth & Home Technologies-approved optional accessories with this appliance. Using non-listed accessories could result in a safety hazard and will void the warranty.
PAGE 24
LCOR-DV36IN B. Service Parts Service Parts Beginning Manufacturing Date: March 2017 36” Left Corner Gas Fireplace - DV End Manufacturing Date: Active Log Set Assembly C 3 2 5 4 6 1 B D A 7 9 8 13 10 11 12 14 15 IMPORTANT: THIS IS DATED INFORMATION. Parts must be ordered from a dealer or distributor. Hearth and Home Technologies does not sell directly to consumers. Provide model number and serial number when requesting service parts from your dealer or distributor.
PAGE 25
RCOR-DV36IN Service Parts 36” Right Corner Gas Fireplace - DV Beginning Manufacturing Date: March 2017 End Manufacturing Date: Active Log Set Assembly C 3 2 1 B D 6 A 10 9 5 15 14 4 13 7 8 11 12 IMPORTANT: THIS IS DATED INFORMATION. Parts must be ordered from a dealer or distributor. Hearth and Home Technologies does not sell directly to consumers. Provide model number and serial number when requesting service parts from your dealer or distributor.
PAGE 26
Service Parts LCOR-DV36IN, RCOR-DV36IN Beginning Manufacturing Date: March 2017 End Manufacturing Date: Active #16 Valve Assembly 16.2 16.1 16.3 16.13 16.11 16.12 16.4 16.5 16.10 16.6 16.8 16.7 16.9 IMPORTANT: THIS IS DATED INFORMATION. Parts must be ordered from a dealer or distributor. Hearth and Home Technologies does not sell directly to consumers. Provide model number and serial number when requesting service parts from your dealer or distributor. ITEM 16.1 16.
PAGE 27
Service Parts LCOR-DV36IN, RCOR-DV36IN Beginning Manufacturing Date: March 2017 End Manufacturing Date: Active IMPORTANT: THIS IS DATED INFORMATION. Parts must be ordered from a dealer or distributor. Hearth and Home Technologies does not sell directly to consumers. Provide model number and serial number when requesting service parts from your dealer or distributor.
PAGE 28
C. Contact Information Hearth & Home Technologies 7571 215th Street West, Lakeville, MN 55044 www.hearthnhome.com Please contact your Hearth & Home Technologies dealer with any questions or concerns. For the location of your nearest Hearth & Home Technologies dealer, please visit www.hearthnhome.com.